Beruflich Dokumente
Kultur Dokumente
Increasing the power to the heating continued until the average surface
temperature of the reactor is not reached in 1260 about C in heater power
consumption of 810 watts. Operation in this mode lasted almost 10 days.
After that, the power was raised up to 900 watts. As a result, within a
few minutes the reactor temperature increased to 1400 about C. Further
work took place at about the power of electric heating 900 W up to a prescheduled time off (32 days after the reactor fuel ). Brief description
of the test reactor Rossi In the first stage for 23 hours the reactor was
operated without fuel, which made ??calibration measurements after This
fuel was loaded weight of about 1 g, which has the form fine powder, and
incorporated gradually rising heat.
Rossi reactor during the test on each side are three ceramic tube with
wires on which brings the power required for the preliminary heating the
reactor.
The isotopic composition of lithium and nickel in the source and spent
fuel (%), Measured by ToF-SIMS and ICP-MS, as well as natural isotope
ratio of these elements. The original fuel Spent fuel Nature ToF-SIMS
ICP-MS ToF-SIMS ICP-MS
The ratio of the isotopes of lithium and nickel in the fuel source is
practically differs from the natural.
2. In the spent fuel has significantly increased the relative content 6
Li and decreased content 7 Li. 3. In the spent fuel greatly reduce the
content of all the isotopes nickel, except 62 Ni. The content of the
isotope increased from 3.6% to 99%.
What's inside the reactor at high Rossi temperature. When heated, the
decomposition of lithium aluminum hydride. 1 g of lithium aluminum
hydride 0.105 g ??allocates 1.17 liters of hydrogen, or (Under normal
conditions) Assuming the interior of the reactor - channel 4 mm in
diameter cavity volume of about 2 ml. 100 mg of lithium aluminum hydride
allocates about 100 ml hydrogen under normal conditions. If 100 ml
squeeze 2 ml, the pressure increase up to 50 atmospheres. Additional
growth pressure associated with heating. Therefore, when the temperature
1000 about C in a sealed capsule reactor Rossi pressure strand 100
atmospheres. At temperatures typical for working reactor Rossi, nickel
mixed with molten aluminum and lithium is in a hydrogen atmosphere and
lithium vapor. Balance air, reacting hydrogen, and lithium aluminum forms
a small admixture of nitrogen and ammonia, and oxides and nitrides
lithium and aluminum.
During operation of the reactor removed the cover from the thermal
insulation and the vessel reactor
Complex equipment From left to right: the power supply of the reactor,
the meter count rate meter Geiger, ammeter, signal amplifier thermocouple
temperature indicator reactor, a computer recorder PCLAB-2000 digital
voltmeter. Right reactor in the calorimeter. On the cover - a Geiger
counter SI-8B, on the side surface dosimeter DC-02. In the background - a
computer that registers the temperature in the recorder mode reactor and
the count rate of a Geiger counter.
about With the heat of the reactor greatly exceeds the energy consumed.
During his time at These conditions (90 minutes) of electricity consumed
in excess produced about 3 MJ or 0.83 kilowatt-hours of energy.
Calculations made ??for three modes of operation with a temperature of
about 1000 about C about 1150 about C and 1200 - 1300 about From
Output Experiments with analogue high-temperature heat source Rossi,
loaded with a mixture of nickel and lithium aluminum hydride, showed that
temperatures of about 1100 about C or higher. This device does produce
more energy than it consumes.