Beruflich Dokumente
Kultur Dokumente
The ball turning toolpost consist of three main components: base section , body and the tool holder. For the base I ended up using 1/2" aluminum plate 4" x 4" ( didn't have any 1/2" steel plate on hand ) The body is built from a piece of 2.5" OD stainless steel. and the toolholder is built from 1/2" steel. I have included the measurements I ended up with but don't get hung up on them. There is only one critical measurement , the cutting tool bit height. This measurement can be made once the base and body are completed.
A 1/2" x 1/2" slot was milled across the center for the tool bit holder
Using the mini mill I recessed , drilled and tapped 3 holes to accept 3 1/4"-20 set screws
The 3 1/4" set screws are for adjusting the cutting tool holder
Next / Page 2
9 x 20 Projects Page
9 x 20 Home
Comments / Questions / Suggestions or Add Your Link This information is provided for personal use only
Copyright 2002 Steve Bedair