Beruflich Dokumente
Kultur Dokumente
SMARTRAK
To be mounted by a ATOMIC Authorized dealer only.
MOUNTING SMARTRAK
MOUNTING
1. Insert the Thin Plate in the seating ahead the plate ( g. .1) 2. Place it correctly with a rotational motion ( g. 2) . 3. From the rear, slide the Toe piece on the interface until it corresponds with or is just above your boot sole length using the manual lock to authorize the sliding ( g. 3 & 4) . 4. From the rear, slide the Heel piece on the interface until it corresponds with or is just above your boot sole length using the manual lock to authorize the sliding ( .g. 5) 5. Mount the Brake following the usual procedure ( g. 6) .
ADJUSTING EXAMPLE
6. Identify the length of the boot. 7. If you have boot sole L 306 mm, adjust the Toe on the 308 mm mark. The range in this case is 301 mm to 308 mm ( g. 7). 8. If you have chosen the L 306 mm, adjust the Heel piece on the 312 location. The range in this case is 305 mm to 312 mm ( g. 8) . 9. Step in the boot and check forward pressure ( g. 9). The arrow on the housing must be within the scribed area.
NO
OK
ALPINE BINDINGS