6-3

[D5A0] 5. Wiring Diagram

WIRING DIAGRAM

5. Wiring Diagram
A: POWER SUPPLY ROUTING

12

WIRING DIAGRAM

[D5A0] 6-3 5. Wiring Diagram

13

6-3

[D5A0] 5. Wiring Diagram

WIRING DIAGRAM

No. MB-1 MB-2 MB-3

MB-4 MB-5 MB-6 MB-7 MB-8 MB-9 MB-10 MB-11 SBF-7 ALT ST FB-1 FB-2 FB-3 FB-4 FB-5 FB-6 FB-7 FB-8 FB-9 FB-10

FB-11

FB-12

Load Power window and sunroof circuit breaker Door lock timer Data link connector Engine control module Fuel pump relay Main relay Daytime running light control module Diode (Daytime running light) Lighting switch Cruise control sub switch Horn switch Transmission control module AT shift lock control module Hazard switch Key warning switch Horn Headlight LH Combination meter Front fog light relay Front fog light switch Headlight RH A/C relay holder ABS control module Combination meter Daytime running light control module Engine control module (AT) Inhibitor switch (AT) Starter interlock relay (MT) Main fan relay Parking switch Blower motor relay Front fog light relay ABS control module Stop light switch Rear accessory power supply relay Airbag control module Airbag control module Engine control module Fuel pump relay Ignition coil Transmission control module Blower motor relay Mode control panel Rear defogger switch A/C relay Sub fan relay Thermal protector

No.

FB-13

FB-14 FB-15 FB-16 FB-17 FB-18 FB-19

FB-20 FB-21

FB-22

FB-23

FB-24

FB-25

FB-26

FB-27

FB-28

FB-29

FB-30

Load Back-up light switch (MT) Check connector Combination meter Daytime running light control module Daytime running light hi-beam relay Daytime running light relay Hazard switch Inhibitor switch (AT) Key warning module Power window and sunroof relay Vehicle speed sensor 2 (MT) Rear defogger switch Rear defogger Rear defogger switch Lighting switch Parking switch Parking switch Clock Illumination control module Illumination light AT shift lock control module Front accessory power supply Remote control rearview mirror switch Rear accessory power supply relay Radio Front washer motor Front wiper motor Front wiper & washer switch Rear washer motor Rear wiper motor Rear wiper relay Combination meter Radio Room light Spot light Trunk room light License plate light LH License plate light RH Tail light LH Tail light RH Front clearance light LH Front clearance light RH Combination meter Hazard switch Rear turn signal light LH Turn signal switch Front turn signal light LH Side turn signal light LH Combination meter Hazard switch Rear turn signal light RH Turn signal switch Front turn signal light RH Side turn signal light RH ABS control module AT shift lock control module Cruise control main switch Cruise control module

14

WIRING DIAGRAM B: GROUND DISTRIBUTION

[D5B0] 6-3 5. Wiring Diagram

15

6-3

[D5B0] 5. Wiring Diagram

WIRING DIAGRAM

16

WIRING DIAGRAM

[D5B0] 6-3 5. Wiring Diagram

17

6-3

[D5C0] 5. Wiring Diagram

WIRING DIAGRAM

C: AIRBAG SYSTEM

18

WIRING DIAGRAM D: AIR CONDITIONING SYSTEM

[D5D0] 6-3 5. Wiring Diagram

19

6-3

[D5D0] 5. Wiring Diagram

WIRING DIAGRAM

20

WIRING DIAGRAM E: ANTI-LOCK BRAKE SYSTEM

[D5E0] 6-3 5. Wiring Diagram

21

6-3

[D5E0] 5. Wiring Diagram

WIRING DIAGRAM

22

WIRING DIAGRAM F: A/T CONTROL SYSTEM

[D5F0] 6-3 5. Wiring Diagram

23

6-3

[D5F0] 5. Wiring Diagram

WIRING DIAGRAM

24

WIRING DIAGRAM G: A/T SHIFT LOCK SYSTEM

[D5G0] 6-3 5. Wiring Diagram

25

6-3

[D5H0] 5. Wiring Diagram

WIRING DIAGRAM

H: AUDIO SYSTEM

26

WIRING DIAGRAM I: CHARGING SYSTEM

[D5I0] 6-3 5. Wiring Diagram

27

6-3

[D5J0] 5. Wiring Diagram

WIRING DIAGRAM

J: COMBINATION METER

28

WIRING DIAGRAM K: DOOR LOCK SYSTEM

[D5K0] 6-3 5. Wiring Diagram

29

6-3

[D5L1] 5. Wiring Diagram

WIRING DIAGRAM

L: ENGINE ELECTRICAL SYSTEM

1. 2200 cc CALIFORNIA SPEC. VEHICLES

30

WIRING DIAGRAM

[D5L1] 6-3 5. Wiring Diagram

31

6-3

[D5L1] 5. Wiring Diagram

WIRING DIAGRAM

32

WIRING DIAGRAM

[D5L1] 6-3 5. Wiring Diagram

33

6-3

[D5L2] 5. Wiring Diagram

WIRING DIAGRAM

2. EXCEPT 2200 cc CALIFORNIA SPEC. VEHICLES

34

WIRING DIAGRAM

[D5L2] 6-3 5. Wiring Diagram

35

6-3

[D5L2] 5. Wiring Diagram

WIRING DIAGRAM

36

WIRING DIAGRAM

[D5L2] 6-3 5. Wiring Diagram

37

6-3

[D5M0] 5. Wiring Diagram

WIRING DIAGRAM

M: FUEL GAUGE SYSTEM

38

WIRING DIAGRAM N: HORN AND FRONT ACCESSORY POWER SUPPLY SYSTEM

[D5N0] 6-3 5. Wiring Diagram

39

6-3

[D5O0] 5. Wiring Diagram

WIRING DIAGRAM

O: LIGHTING SYSTEM (BACK-UP LIGHT)

40

WIRING DIAGRAM

[D5P0] 6-3 5. Wiring Diagram

P: LIGHTING SYSTEM (CLEARANCE LIGHT AND ILLUMINATION LIGHT)

41

6-3

[D5P0] 5. Wiring Diagram

WIRING DIAGRAM

42

WIRING DIAGRAM Q: LIGHTING SYSTEM (FRONT FOG LIGHT)

1. WITHOUT DAYTIME RUNNING LIGHT MODEL

[D5Q1] 6-3 5. Wiring Diagram

43

6-3

[D5Q2] 5. Wiring Diagram

WIRING DIAGRAM

2. WITH DAYTIME RUNNING LIGHT MODEL

44

WIRING DIAGRAM R: LIGHTING SYSTEM (HEADLIGHT)

1. WITHOUT DAYTIME RUNNING LIGHT MODEL

[D5R1] 6-3 5. Wiring Diagram

45

6-3

[D5R2] 5. Wiring Diagram

WIRING DIAGRAM

2. WITH DAYTIME RUNNING LIGHT MODEL

46

WIRING DIAGRAM S: LIGHTING SYSTEM (IN COMPARTMENT)

[D5S0] 6-3 5. Wiring Diagram

47

6-3

[D5T0] 5. Wiring Diagram

WIRING DIAGRAM

T: LIGHTING SYSTEM (STOP LIGHT)

48

WIRING DIAGRAM

[D5U0] 6-3 5. Wiring Diagram

U: LIGHTING SYSTEM (TURN SIGNAL LIGHT AND HAZARD LIGHT)

49

6-3

[D5V0] 5. Wiring Diagram

WIRING DIAGRAM

V: OIL PRESSURE AND TEMPERATURE GAUGE SYSTEM

50

WIRING DIAGRAM

[D5W0] 6-3 5. Wiring Diagram

W: PARKING BRAKE AND BRAKE FLUID LEVEL WARNING SYSTEM

51

6-3

[D5X1] 5. Wiring Diagram

WIRING DIAGRAM

X: POWER WINDOW SYSTEM

1. COUPE MODEL

52

WIRING DIAGRAM
2. SEDAN AND WAGON MODEL

[D5X2] 6-3 5. Wiring Diagram

53

6-3

[D5X2] 5. Wiring Diagram

WIRING DIAGRAM

54

WIRING DIAGRAM Y: RADIATOR FAN SYSTEM

[D5Y0] 6-3 5. Wiring Diagram

55

6-3

[D5Z0] 5. Wiring Diagram

WIRING DIAGRAM

Z: REAR ACCESSORY POWER SUPPLY SYSTEM

56

WIRING DIAGRAM AA: REAR WINDOW DEFOGGER SYSTEM

[D5AA0] 6-3 5. Wiring Diagram

57

6-3

[D5AB0] 5. Wiring Diagram

WIRING DIAGRAM

AB: REMOTE CONTROLLED REARVIEW MIRROR SYSTEM

58

WIRING DIAGRAM AC: SEAT BELT WARNING AND KEY WARNING SYSTEM

[D5AC0] 6-3 5. Wiring Diagram

59

6-3

[D5AD0] 5. Wiring Diagram

WIRING DIAGRAM

AD: STARTER SYSTEM

60

WIRING DIAGRAM AE: SUNROOF SYSTEM

[D5AE0] 6-3 5. Wiring Diagram

61

6-3

[D5AF0] 5. Wiring Diagram

WIRING DIAGRAM

AF: WIPER AND WASHER SYSTEM (FRONT)

62

WIRING DIAGRAM AG: WIPER AND WASHER SYSTEM (REAR)

[D5AG0] 6-3 5. Wiring Diagram

63

6-3

[D5AH0] 5. Wiring Diagram

WIRING DIAGRAM

AH: MULTIPLE POWER SUPPLY (OPTION)

64

WIRING DIAGRAM AI: CRUISE CONTROL SYSTEM (OPTION)

[D5AI0] 6-3 5. Wiring Diagram

65

6-3

[D5AI0] 5. Wiring Diagram

WIRING DIAGRAM

MEMO:

66