Beruflich Dokumente
Kultur Dokumente
C83600
Leaded Red Brass Alloy , CDA 836 , SAE 40
Chemical Composition % by weight
Element
Aluminum Antimony Copper Iron Lead Nickel Phosphorus Silicon Sulfur Tin Zinc
Nominal
Minimum
85
84
5 5
4 4 Applications
Pump components, small gears, water impellers and housings, marine fittings, flanges, low pressure valves and fittings, pipe fittings, plumbing fixtures, ornamental fixtures Mechanical Properties M07 - As Continuous Cast Hardness* Tensile Strength** Yield Strength ** Elongation** Brinell Hardness (500 kg load) KSI KSI (0.5% Ext. under load) % in 2 inch 60 36 19 15
**Test values are nominal approximations and depend on specimen size and orientation. Physical Properties
Thermal Conductivity Specific Heat Thermal Expansion Density Electrical Conductivity Modulus of Elasticity
BTU/ (sq ft-ft-hr-F) BTU/lb/F @ 68F Per F from 68 F to 400 F lb/cu in @ 68 F % IACS @ 68 F KSI Fabrication Practices
Stress relieving temperature Time at temperature Responds to heat treatment Machinability rating (Free Cutting Brass=100) Suitability for being joined by:
500 F or 260 C 1 hour per inch of section thickness No 84 Soldering/Excellent Brazing/Good* Oxyacetylene Welding/Not Recommended Gas Shielded Arc Welding/Not Recommended Coated Metal Arc Welding/Fair
*Since brazing is performed at temperatures within the hot-short range, strain must be avoided during the brazing and cooling of this alloy.
The values listed above represent reasonable approximations suitable for general engineering use. Due to commercial variations in composition and to manufacturing limitations, they should not be used for specification purposes. See applicable A.S.T.M. specification references.