Beruflich Dokumente
Kultur Dokumente
Cobble Impregnator
Water based penetrating sealer
Characteristics and Technical Data % Solids by Weight (+/- 3%): 17%
1. Manufacturer
SurfaceLogix a Reliance Supply company 1880 NW 18th Street Pompano Beach FL 33069 www.surfacelogix.net Email support@surfacelogix.net
5.
2. Product Description
Clear protector for stone, pavers, and concrete. Cobble Impregnator offers outstanding protection to interior and exterior stone, marble, porous tile, pavers, and concrete. Protects against stains, water and sun damage. This low VOC water based formula will leave the substrates natural look with a breathable, and stain-resistant finish.
Before you begin: Surfaces must be clean and free of any contaminants before sealing. Cobble Impregnators performance is directly related to how thoroughly the surfaced is prepared. Do not apply when the temperature of the air or the surface to be coated is below 50F. Testing on your surface is always recommended to ensure desired results. Preparation: Stir product. Concrete should cure a minimum of 28 days before sealing. Read label instructions carefully. Smooth concrete must be etched. Cobble Clean and Cobble Prep may be used for specific cleaning situations. One uniform coat should provide the best results. Remove excessive or puddled product from the surface within 15 minutes. Applications Roller: Smaller surfaces can be applied with a 3/8 to nap roller cover. Sprayer: Either a pump sprayer or airless sprayer may be used. On bare surface: One coat provides the best results on uncoated surfaces. If necessary to recoat, do so while coat is still wet. Cleaning Tools Use soap and water to clean tools
Directions
3.
Use Cobble Impregnator penetrating sealer with no surface film on driveways, pool decks, public entryways, walkways, median strips, and patios constructed of: Concrete Brick, pavers Natural stone Granite Slate Also protects tile roofs
Applications
4.
Properties/Special Features
Cobble Impregnator
Water based penetrating sealer
6.
Packaging
Size 1 gal Package Pail Per Case 4 Units/ Pallet 148
11. Shipping
Land and sea: NOT REGULATED Packing Group: III Flash Point: NA
5 gal
Pail
NA
36
7. Coverage
1 gal. covers 200 to 300 square feet per coat. Coverage will depend on surface porosity and method of application.
8. Curing Information
Dry to touch: 30 minutes If necessary to recoat while the first coat is still wet. Full cure: 48 hours
Eye Contact: Wear Eye Protection. May irritate eyes. If in eyes, flush with water for at least 15 minutes. Inhalation: Use a NIOSH approved respirator. Ingestion: If swallowed, DO NOT induce vomiting. Seek medical attention. Skin: Avoid prolonged contact with skin.
Product must be kept in its original, unopened and tightly sealed container, and stored in a dry and well ventilated place with controlled temperature (50F to 90F). Keep sheltered from weather and direct sunlight. In proper storage conditions, the products shelf life is 12 months following production (see date on packaging). Store product in original container and close lid tightly after each use.
For friendly, knowledgeable, and courteous technical service call 954-971-9111 or send us a query from our website at www.surfacelogix.net
16. Disclaimer
All SurfaceLogix products are manufactured with the finest raw materials. It is the applicator's responsibility to determine the appropriate use of the product. All recommendations and suggestions are made without guarantee, since conditions of use are beyond our control.
10. Maintenance
Cobble Clean is recommended for routine maintenance cleaning for surfaces protected with Cobble Impregnator. Follow Cobble Clean instructions for dilution ratios.