Beruflich Dokumente
Kultur Dokumente
MKE0706852CE B2
2007 Panasonic Shikoku Electronics Co., Ltd. All rights reserved. Unauthorized copying and distribution is a violation of law.
CONTENTS
Page
1 Safety Precautions 1.1. General Guidelines 1.2. Leakage Current Cold Check 1.3. Leakage Current Hot Check 1.4. Disposal Lamp 2 Warning 2.1. Prevention of Electro Static Discharge (ESD) to Electrostatically Sensitive (ES) Devices 3 Service Navigation 3.1. Introduction 3.2. About Lead Free Solder (PbF) 4 Specifications 5 Service Mode 6 Troubleshooting Guide 6.1. Troubleshooting Hints for Block Level Repair 7 Disassembly and Assembly Instructions 7.1. Cabinet Section 8 Measurements and Adjustments 8.1. Adjustment Procedures 1 9 Maintenance 9.1. Cleaning Methods 10 Voltage Chart and Waveform of Connectors 11 Block Diagrams 12 Schematic Diagrams 12.1. SCHEMATIC DIAGRAM & CIRCUIT BOARD LAYOUT NOTES 65 4 5 5 5 6 7 19 19 33 33 55 55 58 58 59 63 65 3 3 3 3 3 4 12.2. INTERCONNECTION SCHEMATIC DIAGRAM 12.3. POWER SCHEMATIC DIAGRAMS 12.4. SD/HDMI SCHEMATIC DIAGRAM 12.5. REAR JACK SCHEMATIC DIAGRAM
Page
66 67 68 69
12.6. FRONT JACK/OPERATION / POWER SWITCH / TUNER SCHEMATIC DIAGRAM 13 Printed Circuit Board 13.1. POWER P.C.B. 13.2. SD/HDMI P.C.B. 13.3. REAR JACK P.C.B. 13.4. FRONT JACK/OPERATION P.C.B. / TUNER P.C.B. / POWER SWITCH/OPERATION P.C.B. 14 Exploded Views 14.1. MAIN PARTS SECTION 14.2. BASE BODY SECTION 14.3. DISPLAY SECTION 14.4. SCREEN SECTION 14.5. OPT/TV UNIT SECTION 14.6. LAMP UNIT SECTION 14.7. PACKING PARTS AND ACCESSORIES SECTION 15 Replacement Parts List 15.1. REPLACEMENT NOTES 15.2. MECHANICAL REPLACEMENT PARTS LIST 15.3. ELECTRICAL REPLACEMENT PARTS LIST 78 79 79 81 82 84 86 87 88 89 89 90 91 74 75 75 76 77
1 Safety Precautions
1.1. General Guidelines
1. For continued safety, no modification of any circuit should be attempted. 2. Disconnect AC Plug before disassembling this unit. 3. It is advisable to use an isolation transformer in the AC supply before servicing. 4. When servicing, observe the original lead dress. If a short circuit is found, replace all parts which have been overheated or damaged by the short circuit. 5. After servicing, see to it that all the protective devices such as insulation barriers, insulation papers, shield, and isolation R-C combinations etc. are properly installed. 6. After servicing, be sure to restore the wires, leads, insulation barriers, shields, etc. 7. After servicing, make the leakage current checks to prevent the customer from being exposed to shock hazards. Caution: Use a separate Isolation Transformer for this unit when servicing.
Figure 1
1.4.
Disposal Lamp
1.2.
1. Unplug the AC cord and connect a jumper between the two prongs on the plug. 2. For physically operated power switches, turn power on. Otherwise skip step 2. 3. Measure the resistance value, with an ohmmeter, between the jumpered AC plug and each exposed metallic cabinet part on the receiver, such as screwheads, connectors, etc. When the exposed metallic part has a return path to the chassis, the reading should be between 1 M and 12 M. When the exposed metal does not have a return path to the chassis, the reading must be infinity.
1.3.
1. Plug the AC cord directly into the AC outlet. Do not use an isolation transformer for this check. 2. Connect "A" to exposed metallic part on the set. And connect "B" to a good earth ground, as shown in Figure 1. 3. Use an AC voltmeter, with 1 k/V or more sensitivity, to measure the potential across the resistor. 4. Check each exposed metallic part, and measure the voltage at each point. 5. Reverse the AC plug in the AC outlet and repeat each of the above measurements. 6. The potential at any point should not exceed 0.25 V RMS. A leakage current tester (Simpson Model 228 equivalent) may be used to make the hot checks. Leakage current must not exceed 1/2 mA. In case a measurement is outside of the limits specified, there is a possibility of shock hazard, and the receiver should be repaired and rechecked before it is returned to the customer. 3
2 Warning
2.1. Prevention of Electro Static Discharge (ESD) to Electrostatically Sensitive (ES) Devices
Some semiconductor (solid state) devices can be damaged easily by static electricity. Such components commonly are called Electrostatically Sensitive (ES) Devices. Examples of typical ES devices are integrated circuits and some field-effect transistors and semiconductor "chip" components. The following techniques should be used to help reduce the incidence of component damage caused by electro static discharge (ESD). 1. Immediately before handling any semiconductor component or semiconductor-equipped assembly, drain off any ESD on your body by touching a known earth ground. Alternatively, obtain and wear a commercially available discharging ESD wrist strap, which should be removed for potential shock reasons prior to applying power to the unit under test. 2. After removing an electrical assembly equipped with ES devices, place the assembly on a conductive surface such as aluminum foil, to prevent electrostatic charge buildup or exposure of the assembly. 3. Use only a grounded-tip soldering iron to solder or unsolder ES devices. 4. Use only an antistatic solder removal device. Some solder removal devices not classified as "antistatic (ESD protected)" can generate electrical charge sufficient to damage ES devices. 5. Do not use freon-propelled chemicals. These can generate electrical charges sufficient to damage ES devices. 6. Do not remove a replacement ES device from its protective package until immediately before you are ready to install it. (Most replacement ES devices are packaged with leads electrically shorted together by conductive foam, aluminum foil or comparable conductive material). 7. Immediately before removing the protective material from the leads of a replacement ES device, touch the protective material to the chassis or circuit assembly into which the device will be installed. CAUTION : Be sure no power is applied to the chassis or circuit, and observe all other safety precautions. 8. Minimize bodily motions when handling unpackaged replacement ES devices. (Otherwise harmless motion such as the brushing together of your clothes fabric or the lifting of your foot from a carpeted floor can generate static electricity (ESD) sufficient to damage an ES device).
3 Service Navigation
3.1. Introduction
This service manual contains technical information which will allow service personnels to understand and service this model. Please place orders using the parts list and not the drawing reference numbers. If the circuit is changed or modified, this information will be followed by supplement service manual to be filed with original service manual.
3.2.
4 Specifications
5 Service Mode
INDICATIONS FOR ERROR CONDITIONS
Each Indicator facilitates finding the cause of an error. When an error is detected, the Lamp goes off and the indicators on the front flash.
SOS
01 02 03 04 06 07 09 02 03 04 05 08 09 0A 0B 0C 0D
1 2 3 4 6 7 9
-
AC ON/OFF
2 3 4 5 8 9 10 11 12 13
Power ON/OFF
(Note 2)
AC ON/OFF
Power ON/OFF
Note: 1. The detected Error data will be stored in the EEPROM, and SOS History (Code) is displayed in Self Check mode or Service Adjust mode (SRV-TOOL). 2. The Lamp Indicator will flash X5 immediately after the Lamp goes off. For this SOS only, the TV power will remain on.
<Rear View>
OPT/TV Unit RF AMP Front Fan Power Supply P.C.B. Lamp Fan Top Duct Unit Air Filters Fan Case Unit Rear Fan (OPT Fan) Main P.C.B./ Drive P.C.B. Support Shield Thermal Fuse Lamp Unit Tuner P.C.B. Power P.C.B. Rear Cover Rear Jack P.C.B.
SELF CHECK
In this mode, the following information can be confirmed on the screen: - Peaks software version and EEPROM data version - Communication check between Peaks IC and each ICs - SOS History
SOS History
SOS POWER: 02 04 SOS LAMP : 08 09 0A 0B Copyright 2007 Matsushita Electric Industrial Co., Ltd.
The number of time Power Indicator flashed : 01 ~ 09 The number of time Lamp Indicator flashed : 02 ~ 0D
Self Check
Enter: VOLUME DOWN button + OK key (for more than 3 seconds in power on condition)
VOL _
(on the front)
Note: If the same SOS error occurs more than once, only one code will be displayed.
OK
(on the remote)
SELF CHECK
0.480 - 00.16
*1
DT OK MEM2 OK ADV OK GC5P OK VSW OK FPGA OK ADAV OK ASW OK TUN1 OK TUN2 OK FE OK GenX4 OK MEM1 OK SOS POWER: 02 04 SOS LAMP : 08 09 0A 0B Copyright 2007 Matsushita Electric Industrial Co., Ltd.
*2
*3
Fig. 1-1 *1. Peaks software version and Peaks EEPROM data version
SELF CHECK 0.480 - 00.16
_
(on the remote)
Peaks SOFT Peaks EEP LSI DATA GenX SOFT GenX EEP GenX ROMCOR GC5P EEP FPGA FACTDATA 0.480 0.16 0.00.5b 0.15.60 0.00.00 0.00.00 20 0.3a 12FF-FFFF SRVICE ADJUST WB-ADJ OPTION RM-SET SRV-TOOL MMD-CHK
Peaks EEPROM data version TV Microcontroller software version TV Microcontroller EEPROM data version
2 key
MMD-CHK FREQ
<Main Menu>
VIVID ON
1 key
<Main Menu>
<MMD-CHK 1/8>
10
MMD-CHK 1/8~8/8 and internal pattern Perform the Picture Position adjustment by pressing VOL+/- key, and display the internal pattern for LCD-CHK, GC-CHK.
3 key
MMD-CHK FREQ VIVID ON
3 key
OPT HPOS 0024
3 key
OPT HPOS 001F
3 key
<SRV-TOOL>
3 key
3 key
3 key
3 key
4 key
<MMD-CHK 4/8>
4 key
<MMD-CHK 5/8>
4 key
<MMD-CHK 6/8>
4 key
<MMD-CHK 7/8>
4 key
<MMD-CHK 8/8>
<MMD-CHK 1/8>
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
11
LAMP CAUTION
The Lamp Unit becomes very hot during operation. When replacing the Lamp Unit, wait until it has cooled off (1 hour or more).
0081-4506
Read every other number from the right: Read every other number from the left:
12
HOT CIRCUIT
Primary circuit exists on the Power P.C.B. This circuit is identified as "HOT" on the P.C.B. and in the Service Manual. Use extreme care to prevent accidental shock when servicing.
Use Marks shown in the chart below to distinguish the different models included in this Service Manual.
MODEL MARK A B C D E F G H I PT
DT OK MEM2 OK ADV OK GC5P OK VSW OK FPGA OK ADAV OK ASW OK TUN1 OK SOS History TUN2 OK FE OK GenX4 OK MEM1 OK SOS POWER: 02 04 SOS LAMP : 08 09 0A 0B Copyright 2007 Matsushita Electric Industrial Co., Ltd.
PT-50LCZ70 PT-56LCZ70 PT-61LCZ70 PT-50LCZ7 PT-56LCZ7 PT-61LCZ7 PT-50LCZ70-K PT-56LCZ70-K PT-61LCZ70-K NOT USED
<Self Check-2>
Note: Refer to Item 3 of Schematic Diagram Notes of Schematic Diagram and Circuit Board Layout Notes, for mark "PT."
13
AC Cord
OPT/TV Unit
Rear Fan
Fig. 9-1
14
After servicing, make sure that all wires, leads, and clampers are placed in their original position. It is important for the best operation of the unit. Note: Use extreme care especially for the following.
15
After servicing, make sure that all wires, leads, and clampers are placed in their original position. It is important for the best operation of the unit. Note: Use extreme care especially for the following.
Fig. 9-3
16
After servicing, make sure that all wires, leads, and clampers are placed in their original position. It is important for the best operation of the unit. Note: Use extreme care especially for the following.
CN6005 (From Lamp Unit) CN6003 (From Power Switch /Operation P.C.B.) CN1102 (From Thermal Fuse) CN1101 (From Power P.C.B.) CN3501 (From Main P.C.B.) CN2752 (From Rear Fan) CN151 (From Lamp Unit)
17
After servicing, make sure that all wires, leads, and clampers are placed in their original position. It is important for the best operation of the unit. Note: Use extreme care especially for the following.
OPT/TV Unit
Fig. 9-5
18
6 Troubleshooting Guide
6.1. Troubleshooting Hints for Block Level Repair
MAIN PARTS LOCATION <Front View>
<Rear View>
OPT/TV Unit RF AMP Front Fan Power Supply P.C.B. Lamp Fan Top Duct Unit Air Filters Fan Case Unit Rear Fan (OPT Fan) Main P.C.B./ Drive P.C.B. Support Shield Thermal Fuse Lamp Unit Tuner P.C.B. Power P.C.B. Rear Cover Rear Jack P.C.B.
19
SOS
01 02 03 04 06 07 09 02 03 04 05 08 09 0A 0B 0C 0D
1 2 3 4 6 7 9
-
AC ON/OFF
2 3 4 5 8 9 10 11 12 13
Power ON/OFF
(Note 2)
AC ON/OFF
Power ON/OFF
Note: 1. The detected Error data will be stored in the EEPROM, and SOS History (Code) is displayed in Self Check mode or Service Adjust mode (SRV-TOOL). 2. The Lamp Indicator will flash X5 immediately after the Lamp goes off. For this SOS only, the TV power will remain on.
20
Protection Circuit
AC STOP(L)
Q4502
CN1101
9 10 11 30
IC1107
1
IC8001 (PEAKS)
2 34
IC1104,Q1106
CN6005
DC-DC CONVERTER
+5V REG.
48 13
L6 G1
57
Q6008
7 67
Error Information
CN3001
SOS (L)
29 117
114
Q1102 SW
FAN SOS
LAMP FAN SOS OPT FAN SOS FRONT FAN SOS REAR FAN SOS NORMAL REAR JACK P.C.B. CONNECTION ERROR
:APPROX. 0V :APPROX. 0.5V :APPROX. 1.3V :APPROX. 2V :APPROX. 2.8V :APPROX. 3.3V
IC1101,IC1102, IC1205
OVER CURRENT DETECT CIRCUIT
MAIN P.C.B.
IC1107
(+9V)
1
SUB+5V
POWER TRANS.
IC1105
1 2
IC1001
2
SWITCHING CONTROL
14
IC1104,Q1106
DC-DC CONVERTER
IC1103,Q1107
DC-DC CONVERTER
(FEEDBACK LOOP) R1017
IC1002
FEED BACK
IC1003
3
R1018
1
FHD+3.3V
SHUNT REG.
IC1202,Q1201
R1019
DC-DC CONVERTER
DDR+3.3V
IC1201,Q1202
DC-DC CONVERTER
IC1101,IC1102, IC1205
Over current Detect
Q1102 SW
FHD+1.2V
Normal SOS
SOS (L)
POWER P.C.B.
MAIN P.C.B.
CN1101
CN1003
9 10 11
+9V
DTV+9V SENS
30
MAIN P.C.B.
21
POWER P.C.B.
[POWER Indicator three blinks] Abnormal voltage (SUB+5V line) detection circuit
SUB+5V
IC1107
2
+5V REG.
+9V
SUB+5V SENS
34
MAIN P.C.B.
[POWER Indicator four blinks] Abnormal voltage (MAIN+3.3V line) detection circuit
MAIN+3.3V
IC1104,Q1106
DC-DC CONVERTER +9V
MAIN+3.3V SENS
57
MAIN P.C.B.
[POWER Indicator six blinks] Audio Amp (IC4501) failure detection circuit
IC6004 (TV MICROCONTROLLER)
SOS Normal Q4502
5
72
MAIN P.C.B.
[POWER Indicator seven blinks] Communication error between Peaks (IC8001) and TV microcontroller (IC6004) detection circuit
IC6004 (TV MICROCONTROLLER)
Normal SOS
IC8001 (PEAKS)
L6
48
MAIN P.C.B.
22
[POWER Indicator nine blinks] Communication error between Peaks (IC8001) and TV microcontroller (IC6004) detection circuit
IC6004 (TV MICROCONTROLLER)
Normal SOS
IC8001 (PEAKS)
G1
13
MAIN P.C.B. [POWER Indicator ten blinks] Abnormal voltage (LCD+17V line) detection circuit
LCD+17 V
CN1101
CN1003
+17V
LCD+17V SENS
10
MAIN P.C.B. [LAMP Indicator two blinks] Lamp does not light up detection circuit [LAMP Indicator three blinks] Lamp failure detection circuit [LAMP Indicator four blinks] Abnormal Lamp temperature detection circuit [LAMP Indicator five blinks] Lamp communication error detection circuit [LAMP Indicator thirteen blinks] Abnormal Lamp input voltage (+26V) detection circuit
IC6004 (TV MICROCONTROLLER)
Q6008 Q6005
2
POWER P.C.B.
88
LAMP ON (H)
CN6005
Q6017
66 1
Q6018
67 7
SOS Information
SUB+5 V
MAIN P.C.B.
+12V F801 8A/125V AC IN RL802 AC LINE FILTER
TEMPERATURE SENSOR
CN851
AC LINE FILTER
CN1
AC IN AC IN
+26V GND
CN151
+26V GND
POWER P.C.B.
LAMP UNIT
23
[LAMP Indicator eight blinks] LAMP Fan stops detection circuit [LAMP Indicator nine blinks] OPT Fan stops detection circuit [LAMP Indicator ten blinks] Front Fan or Rear Fan stops detection circuit [LAMP Indicator eleven blinks] Rear Fan or Front Fan stops detection circuit [LAMP Indicator twelve blinks] Rear Jack P.C.B. connection error detection circuit
IC6004 (TV MICROCONTROLLER)
CN3001
29
CN3501
29
Q2752
LAMP FAN SOS OPT FAN SOS FRONT FAN SOS REAR FAN SOS NORMAL REAR JACK P.C.B. CONNECTION ERROR
:APPROX. 0V :APPROX. 0.5V :APPROX. 1.3V :APPROX. 2V :APPROX. 2.8V :APPROX. 3.3V
IC2751
+9V Q2751
2
DRIVE
5
(+8 V)
4
REAR FAN CN2752-1 CN2752-2 CN2752-3 OPT FAN CN2754-1 CN2754-2 CN2754-3 LAMP FAN CN2753-1 CN2753-2 CN2753-3
IC2753
DRIVE
2 5 4
(+6.0V~ +6.5 V)
Q2753
IC2754
2
DRIVE
(+7 V)
Q2754
FRONT/REAR FAN SD CONTROL <FROM TV MICROCONTROLLER (IC6004)> OPT FAN SD CONTROL <FROM TV MICROCONTROLLER (IC6004)>
MAIN P.C.B.
24
D802
7 3 6
STBY+7V Normal
CN1003
AC VOLTAGE DETECT
CN1101
D811
AC STOP (L)
POWER P.C.B.
MAIN P.C.B.
14
DRIVE CONTROL
SWITCHING TRANSFORMER
TV SUB ON(H)
1 2
MAIN P.C.B.
CN1102
+12V RL802
Q806
AC LINE FILTER
POWER P.C.B.
25
Possible Solution
1. Replace the Power P.C.B. 2. If still NG, replace the OPT/TV Unit.
2 3 4 6 7
[POWER Indicator two blinks] DT+9V line error. [POWER Indicator three blinks] SUB+5V line error. [POWER Indicator four blinks] MAIN+3.3V line error. [POWER Indicator six blinks] AUDIO AMP (IC4501) failure
1. Check that Connector CN1102 (Thermal Fuse) on the Main P.C.B. is connected firmly. 2. If still NG, replace the Power P.C.B. 3. If still NG, replace the OPT/TV Unit. 1. Replace the OPT/TV Unit.
[POWER Indicator seven blinks] Communication error between Peaks (IC8001) and TV microcontroller (IC6004) on the Main P.C.B.
[POWER Indicator nine blinks] Communication error between Peaks (IC8001) and TV microcontroller (IC6004) on the Main P.C.B.
26
Problem
[LAMP Indicator two blinks] Lamp does not light up.
Possible Solution
1. Try to turn on the power several times. (Wait 5 minutes before retrying.) 2. If still NG, replace the Lamp Unit.
2 3 4
[LAMP Indicator three blinks] 1. Try to turn on the power several times. (Wait 5 minutes before retrying.) Lamp failure (Internal Lamp thermistor open or short). 2. If still NG, replace the Lamp Unit. [LAMP Indicator four blinks] Abnormal Lamp temperature (more than 92 C). 1. Relocate the unit to a proper location. Keep the unit at least 100 mm (4") away from the wall to provide proper ventilation because warm air is discharged. Blocking the ventilation opening of the cooling fan may damage the unit. 2. Wait until the Lamp has cooled off (approximately 1 hour) and try to turn on the power several times. 3. If still NG, check whether the Fans rotate normally. 4. If still NG, replace the Lamp Unit. 1. Try to turn on the power several times. (Wait 5 minutes before retrying.) 2. If still NG, check that the cable between CN6005 on the Main P.C.B. and Lamp Unit is connected firmly. 1. Check that Connector CN2753 on the Rear Jack P.C.B. is connected firmly. 2. If still NG, replace the Lamp Fan. 1. Check that Connector CN2754 on the Rear Jack P.C.B. is connected firmly. 2. If still NG, replace the OPT/TV Unit (Fan Case Unit (OPT Fan)). 1. Check that Connector CN2751 or CN2752 on the Rear Jack P.C.B. is connected firmly. 2. If still NG, check whether the Front Fan or Rear Fan stopped and replace it. (Note: They are same Fan.) 1. Check that Connector CN2752 or CN2751 on the Rear Jack P.C.B. is connected firmly. 2. If still NG, check whether the Front Fan or Rear Fan stopped and replace it. (Note: They are same Fan.) 1. Check that Connector CN3501 on the Rear Jack P.C.B. is connected into Connector CN3001 on the Main P.C.B. firmly. 1. Try to turn on the power several times. (Wait 5 minutes before retrying.) 2. If still NG, check that Connector CN1 and CN151 on the RF AMP Power Supply P.C.B. are connected firmly. 3. If still NG, unplug the AC Cord and disconnect CN151 connector cable and check voltage at Pin 1, 2 or 3 of CN151 on the RF AMP Power Supply P.C.B. See Figure a. If OK (+26V), replace the Lamp Unit. If NG, check the voltage between Pin 1 and Pin 2 of CN1 on the RF AMP Power Supply P.C.B. If OK (AC120V), replace the RF AMP Power Supply P.C.B. If NG, replace the Power P.C.B.
5 8 9 10 11 12 13
[LAMP Indicator five blinks] Lamp communication error. [LAMP Indicator eight blinks] Cooling Fan (Lamp Fan) malfunction. [LAMP Indicator nine blinks] Cooling Fan (OPT Fan) malfunction. [LAMP Indicator ten blinks] Cooling Fan (Front Fan or Rear Fan) malfunction. [LAMP Indicator eleven blinks] Cooling Fan (Rear Fan or Front Fan) malfunction. [LAMP Indicator twelve blinks] Rear Jack P.C.B. connection error. [LAMP Indicator thirteen blinks] Abnormal Lamp input voltage (+26V) Normal: +26V Abnormal: less than +20V
27
Note: 1. Before performing troubleshooting, confirm that all connector cables are connected properly. 2. When repeating troubleshooting, be sure to turn the power off and unplug the AC Cord. 3. If the same error indication repeatedly occurs after several attempts, proceed to the next step.
Is there a snap sound of the Relay turning ON ? (Relay: RL801/RL802 on the Power P.C.B.) YES
NO Does the Power Indicator (D6803) on the Power Switch/Operation P.C.B. flash green? YES
Power/Lamp Indicator flashes continuously. Refer to "How to solve problems indicated by the Error Indication." Perform troubleshooting.
Disconnect
Figure. a
28
Replace the OPT/TV Unit or the Rear Jack P.C.B. Replace the Tuner P.C.B. or the OPT/TV Unit.
29
Does the "BALANCE" screen becomes center position? NO Set to the center position. Still NG Swap the Speaker Connectors to confirm the Speaker failure. NO Replace the OPT/TV Unit. YES Replace the L-CH Speaker.
Does the "BALANCE" screen becomes center position? NO Set to the center position. Still NG Swap the Speaker Connectors to confirm the Speaker failure. NO Replace the OPT/TV Unit. YES Replace the R-CH Speaker.
30
DRIVE P.C.B.
CN3502 IC8001
PEAKS INTERNAL PATTERN FOR GC-CHK
IC8802
DEMODU.
IC5510
IC7101
IC2901
LCD/PRISM UNIT
CN2001
HDMI SW /EQL
HDMI I/F /AD CONV. I/P CONVERTER PICTURE CONTROL OSD MIX LVDS TRANS.
CN2101
IC2902
CN9802
CN8201
CN2201
LVDS REC.
Display the internal pattern for "LCD-CHK" in Service Adjust Mode. Refer to "HOW TO DISPLAY THE INTERNAL PATTERN FOR LCD-CHK" as shown in Figure A.
If the internal pattern is OK, the circuit shown in dark gray can be judged OK.
Display the internal pattern for "GC-CHK" in Service Adjust Mode. Refer to "HOW TO DISPLAY THE INTERNAL PATTERN FOR GC-CHK" as shown in Figure B.
If the internal pattern is OK, the circuit shown in gray can be judged OK.
31
_ VOL
(on the front)
SRVICE ADJUST WB-ADJ OPTION RM-SET SRV-TOOL MMD-CHK Peaks SOFT Peaks EEP LSI DATA GenX SOFT GenX EEP GenX ROMCOR GC5P EEP FPGA FACTDATA 0.480 0.16 0.00.5b 0.15.60 0.00.00 0.00.00 20 0.3a 12FF-FFFF
<Main Menu>
2 key
MMD-CHK FREQ
VIVID ON
3 key
OPT HPOS 0024
3 key
OPT HPOS 001F
3 key
<SRV-TOOL>
3 key
3 key
3 key
3 key
3 key
4 key
<MMD-CHK 1/8> <MMD-CHK 2/8>
4 key
<MMD-CHK 3/8>
4 key
<MMD-CHK 4/8>
4 key
<MMD-CHK 5/8>
4 key
<MMD-CHK 6/8>
4 key
<MMD-CHK 7/8>
4 key
<MMD-CHK 8/8>
4 key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
VOL+ key
VOL- key
32
REMOVAL OF THE OPT/TV UNIT REMOVAL OF THE RF AMP POWER SUPPLY P.C.B. REMOVAL OF THE FRONT FAN AND THE REAR FAN REMOVAL OF THE TUNER P.C.B., THE REAR JACK P.C.B. AND THE POWER P.C.B. REMOVAL OF THE FRONT COVER UNIT AND THE DISPLAY REMOVAL OF THE SCREEN UNIT FROM THE DISPLAY DISASSEMBLY FLOWCHART
This flow chart indicates the disassembly steps of the cabinet parts and the P.C.Boards in order to gain access to item (s) to be serviced. When reassembling, perform the step (s) in the reverse order. Bend, route and dress the wires as they were originally. FRONT COVER UNIT (DISPLAY) SCREEN UNIT MIRROR BACK COVER REAR COVER UNIT
OPT/TV UNIT RF AMP POWER SUPPLY P.C.B. LAMP UNIT TUNER P.C.B. REAR JACK P.C.B. POWER P.C.B. TOP DUCT UNIT DRIVE P.C.B. MAIN P.C.B.
Note: The optical parts will be exposed to the dust in the air when the Top Duct Unit is removed. Therefore, it is strongly recommend to remove the Top Duct Unit only in a clean room.
Note : a. Place a cloth or some other soft material under the P.C. Boards or Unit to prevent damage. b. When reinstalling, ensure that the connectors are connected firmly and electrical components have not been damaged. c. Do not supply power to the unit during disassembly and reassembly.
33
LAMP CAUTION:
The Lamp Unit becomes very hot during operation. When replacing the Lamp Unit, wait until it has cooled off (1 hour or more).
Latch tabs
401
Rear Cover
Fig. D1-1
34
Before trying to remove the OPT/TV Unit, check the area under the Lamp shown by the arrow in the following picture. Note: If debris is present, clean the debris with a vacuum cleaner. (1) Spread blanket or drop cloth (or similar material) on the floor to collect the debris that may fall during the removal of the OPT/TV Unit and the Lamp Unit. (2) Vacuum the debris thoroughly.
401
CN4501 CN8201
401
Locking Tab
CN5503
CN6003
CN3502
401
Check for debris here.
478
Support Shield
If debris is present, remove all dust and debris with a vacuum cleaner.
Fig. D1-2
Replacement Note of OPT/TV Unit: After replacing the OPT/TV Unit, be sure to perform "ADJUSTMENT of OPT/TV Unit." Refer to "WHEN INSTALLING THE OPT/TV UNIT INTO THE UNIT AT THE USERS LOCATION:."
35
Cabinet
Note: If debris is present, remove all dust and debris with a vacuum cleaner.
OPT/TV Unit
Fig. D1-3
36
Clampers CN1102
Thermal Fuse
482
CN2753 CN2752 CN2751
453
453
CN1 CN6005
453
CN151
453
Fig. D1-4
37
3. Remove the Lamp Shield Case Assy with Fans by removing the 8 screws.
Note: Clean the surface of the plate under the Lamp with a vacuum cleaner.
Fig. D1-5
38
453 453
LAMP CAUTION:
The Lamp Unit becomes very hot during operation. When replacing the Lamp Unit, wait until it has cooled off (1 hour or more).
453
453
Connector Cables
453
453
Lamp Ass'y
Note: Clean the surface of the plate with a vacuum cleaner, after removing the Lamp Unit.
Fig. D1-6
39
3. Remove the 4 plates (Lamp Stay Plate, Lamp Bracket Top, Lamp Support Shield and Lamp Bracket Under) by removing the 11 screws.
482
482
Lamp Bracket Under
482
482
<Lamp Unit>
The Lamp Unit includes the Lamp Fan. <Bottom View>
Fig. D1-7
40
494
Name Plate
493
493
493
Lamp Fan
Fig. D1-8
41
Reassembly Note for Lamp Shield Case Assy: Before installing the Lamp Shield Case Assy with Fans, wire the Lamp Fan Cable and the Front Fan Cable as shown.
Place
Front Fan Cable Lamp Shield Case Ass'y with Fans Pass
Pass
Clamp
Fig. D1-9
42
401
CN4501 CN8201
401
Locking Tab
CN5503
CN6003
CN3502
401
478
Support Shield
Fig. D2-1
43
Cabinet
OPT/TV Unit
Fig. D2-2
44
Spacer
479
CN1
479
479
CN151
Name Plate
404 404
CN2751 CN2752
404
404
Rear Fan
Fig. D3-2
Front Fan
45
REMOVAL OF THE TUNER P.C.B., THE REAR JACK P.C.B. AND THE POWER P.C.B.
1. Remove the OPT/TV Unit. Refer to Steps 1~2 in "REMOVAL OF THE OPT/TV UNIT." 2. Remove the Tuner P.C.B. by removing the 3 screws (CN8970 is disconnected). 3. 1) Remove the Rear Jack Holder by removing the 6 screws. 2) Disconnect Connectors CN2751, CN2752, CN2753, CN2754. 3) Disconnect Connector CN3501 and remove the Rear Jack P.C.B. by removing the 5 screws.
Tuner P.C.B.
479
CN8970
479
479
453
453
Slide
453 453
CN2753 CN2754
453
46
4. 1) Disconnect Connectors CN1, CN1101 and remove the 5 screws. 2) Slide out the Power P.C.B. with the Shield together while releasing the 6 locking tabs.
Locking Tab
453 453
Clamper Lift up to release
453
CN1
Locking Tabs
453
CN1101
Clamper
453
Fig. D4-2
47
3) Remove the Power P.C.B. by removing the 5 screws and the 2 spacers, then disconnect the AC Cord.
479
479
Spacers
479
479
479
AC Cord
Power P.C.B.
Fig. D4-3
48
50 inch model
1) Open the Front Door about 45 degrees and then pull it out gently.
Fig. D5-1a
49
3) Hold the portion 1 of the bottom of the front cover and the portion 2 of the side with fingers and pull forward slightly at the portion 1 and pull downward slightly at the portion 2 . Then, do 3 & 4 in the same way to remove the front cover.
4 3 1
3 inch
3 inch
Fig. D5-2a
50
Fig. D5-1b
51
3) Hold the portion 1 of the bottom of the front cover and the portion 2 of the side with fingers and pull forward slightly at the portion 1 and pull downward slightly at the portion 2 to release locking tabs. There are X3 locking tabs. Then, do 3 & 4 in the same way.
4 3 1
<Bottom View>
4) While pulling forward slightly at the center of the front cover (portion 5 ), release the locking tabs A (X2) at both ends of the front cover one by one to remove the front cover.
Locking tab A Locking tab A
Locking tab A
1
Locking tab A
Fig. D5-2b
52
50 inch model
1) When installing the front cover, place portions A(X2) in proper position. Then, slide the front cover upward. Confirm the tabs(X8) on the top of the front cover are in position while sliding up.
Portion A
2) Then, press upward slightly at the following portions(X3) of the bottom of the front cover in the order shown below to lock the locking tabs.
3 inch
7 inch
3 inch
Fig. D5-3a
53
3) Hold and press it about 45 degrees at the following portion to lock completely. Confirm there is no gap on the top viewing from the front and no bend on the bottom portions viewing from side.
3 inch
No Gap
Confirm there is no bend of the bottom side viewing from the sides. The bend can be seen if the locking is not good enough.
45 degree
Fig. D5-4a
54
Locking tab A
Locking tab A
2) Then, slide the front cover upward. Confirm the tabs(X8) on the top of the front cover are in position while sliding up.
Fig. D5-3b
55
3) Then, press upward slightly at the following portions(X3) of the bottom of the front cover in the order shown below to lock the locking tabs.
5 inch
7 inch
5 inch
4) Hold and press it about 45 degrees at the following portion to lock completely. Confirm there is no gap on the top viewing from the front and no bend on the bottom portions viewing from side.
5 inch
No Gap
Confirm there is no bend of the bottom side viewing from the sides. The bend can be seen if the locking is not good enough.
45 degree
Fig. D5-4b
56
3. 1) To remove Display, remove the 5 screws from front side. 2) Lift up the Display.
Display
401
4
401
5
401 401
1
401
Fig. D5-2
57
Screen Unit
401
Fig. D6-1
58
3. 1) Remove the 4 Screen Support Corners, 2 Screen Support H Units and the 2 Screen Support V Units by removing the 22 screws. 2) Remove the Fresnel Lens and the Lenticular Screen.
Fresnel Lens
Screen Support Corner
Screen Support H Unit Serial No. Label Screen Support V Unit Screen Support Corner
465
Front
Serial No. Label of Lenticular Screen Serial No. Label of Fresnel Lens
Fig. D6-2 Replacement Note for Screen Units: When replacing the Fresnel Lens and the Lenticular Screen, it is imperative that dust, etc., does not adhere between the Fresnel Lens and the Lenticular Screen. Due to this risk, it is strongly recommended to replace the Screen Unit as a unit.
59
WHEN INSTALLING THE OPT/TV UNIT INTO THE UNIT AT THE USERS LOCATION:
The following ADJUSTMENT of the OPT/TV Unit must be performed. a. Focus Adjustment Note: The Focus Adjustment is not normally necessary when reinstalling. However, the Focus Adjustment should be performed when replacing the new OPT/TV Unit. b. Mechanical Picture Position Adjustment (Tilt) c. Electrical Picture Position Adjustment (H/V) Adjustment Preparation: 1. Install all parts except the Front Cover Unit and the Front Door.
<MMD-CHK 1/8>
4 key
<MMD-CHK 2/8> <MMD-CHK 3/8>
To release this mode: 1. After changing the value of OPT HPOS/OPT VPOS, the adjustment data will be written to the EEPROM. 2. Press 1 key to return to the Main Menu or turn off the power. 3. Install the Front Cover Unit with the screws and the Front Door.
60
a. Focus Adjustment
1) Confirm that the black line (C, D) in the nine portions are visible.
OPT HPOS 0024
Screw Screw
<MMD-CHK 2/8>
<Front View>
Fig. M1-5 2) Adjust the Projection Lens by twisting so that the long line "g" and the long line "h" are within 4 dots. (The long line "g" and the long line "h" will be almost aligned horizontally.)
D
OPT HPOS 0024
2) If not, loosen the Knob on the Projection Lens until the Knob can be moved. Then, adjust the focus by moving up or down the Knob.
Tighten Knob
"G"
<MMD-CHK 2/8>
"H"
"G" Up
within 4 dots
"H"
Note: If the Projection Lens is twisted left, the Focus Screen twists left. If the Projection Lens is twisted right, the Focus Screen twists right. 3) Tighten the 4 Screws while fixing the Projection Lens.
Down
<Front View>
61
"A"
"F" "J"
"C"
"D"
"K" "G"
"L"
<MMD-CHK 2/8>
"B"
"H"
"C"
"D" width "c" = width "d" width "c" "A" width "a" width "d"
5) Confirm that all "A", "B", "C", "D", "E", "F", "G", "H", "I", "J", "K", "L" are each almost symmetrical. 6) If not, adjust the "OPT HPOS" and "OPT VPOS" (repeat steps 1-6) until the picture is in the correct position. 7) After changing the value, the adjustment data will be written to the EEPROM.
62
9 Maintenance
9.1. Cleaning Methods
THE PROJECTION LENS Use lens cleaning paper and cleaner available at your local camera shop, etc. Dampen the cleaning paper with cleaner and gently wipe the surface of the lens from the center outward to remove dust. Lens THE SCREEN UNIT AND THE MIRROR - THE SCREEN UNIT (Lenticular Screen, Fresnel Lens) It is strongly recommended that the Lenticular Screen surface (outside) and the Fresnel Lens surface (inside) should be wiped gently with a clean, soft, dry cloth to remove the dirt. Note: 1. If the dirt cannot be removed by wiping with a clean, soft, dry cloth, use a clean, soft, dry cloth moistened with diluted neutral pH liquid cleanser or a lens cleaner (usually containing a small amount of ethyl alcohol) and wipe lightly. Take care not to leave any streaks. Do not use cleaning materials containing methyl alcohol, acetone, or dichloromethane. 2. Use an air blower to clean the inner surface of the Lenticular Screen and the outer surface of the Fresnel Lens (the surfaces that one another). These surfaces must not be wiped with a cloth. - THE MIRROR Remove any dirt with an air blower or wipe with a clean, soft, dry cloth. If wiped too forcefully, the surface of the Mirror can be damaged. If wiping with a clean, dry cloth does not remove the dirt, the Mirror must be replaced.
Mirror
Fig. 6-2 THE FILTER ON THE OPT/TV UNIT CAUTION: Operating with torn or damaged Air Filter may cause damage to the OPT/TV Unit. Remove the OPT/TV Unit from rear. Then, clean the air filters. Gently remove any accumulated dust from filter with a vacuum cleaner; use extreme care so as not to damage or tear the filters.
Air Filter
Screen Unit
Air Filter
Fig. 6-3
Lenticular Screen surface (outside)
63
64
65
V1 +1.00 Vp-p
V1 +0.70 Vp-p
0.5 V
20 s
0.2 V
20 s
WF1
V1 +1.00 Vp-p
WF6
V1 +2.00 Vp-p
0.2 V
20 s
0.5 V
20 s
WF2
V1 +0.80 Vp-p
WF7
V1 +1.50 Vp-p
0.5 V
5 ms
0.2 V
20 s
WF3
V1 +1.00 Vp-p
WF8
V1 +3.40 Vp-p
1 V
5 ms
0.2 V
20 s
WF4
V1 +0.70 Vp-p
WF9
0.2 V
20 s
WF5
66
11 Block Diagrams
OVERALL BLOCK DIAGRAM
REAR JACK P.C.B.
IC4101
COMPONENT AUDIO IN 1 (L/R) COMPONENT AUDIO IN 2 (L/R) AUDIO IN 1 (L/R) AUDIO IN 2(L/R) COMPONENT AUDIO IN 1 (L/R) COMPONENT AUDIO IN 2 (L/R) AUDIO IN 1 (L/R) AUDIO IN 2 (L/R) HDMI AUDIO AUDIO IN 3 (L/R) DVII AUDIO IN (L/R) HDMI AUDIO IN 1 (L/R) PC AUDIO IN (L/R) TUNER AUDIO IN (L/R) DTV AUDIO IN (L/R) DTV AUDIO CN3501
MAIN P.C.B.
CN3001
IC4501 IC4001
CN4501
SPEAKER (R-CH)
SPEAKER (L-CH)
AUDIO SW
AUDIO DSP
IC6004
SOUND SOS (H) FAN SOS SOS (L)
FRONT FAN
REAR FAN
DRIVE
IC2753 CN2754
IC4003
AUDIO OUT (L/R) OP AMP
OPT FAN
DRIVE
VIDEO OUT
VIDEO OUT
IC3001
COMPONENT IN 1(Y/PB/PR) COMPONENT IN 2(Y/PB/PR) VIDEO IN 1 VIDEO IN 2 COMPONENT1 Y/PB/PR COMPONENT2 Y/PB/PR
IC2754
CN2753
DRIVE
FAN SOS DETECTOR
LAMP RXD LAMP TXD AC SOTP (L)
TV MICROCONTROLLER VIDEO SW
CN6005
TV SUB ON (H) IR DATA POWER LED ON (L) LAMP LED ON (H) POWER SW ON (L)
POWER P.C.B.
DC/DC
CN1101
CN1003
S-VIDEO IN 1
KEY DATA PC-IN(R/G/B) DTV VIDEO I2C SERIAL DATA/CLOCK3 I2C SERIAL DATA/CLOCK0 SERIAL DATA/CLOCK I2C SERIAL DATA/CLOCK SERIAL DATA/CLOCK I2C SERIAL DATA/CLOCK2 CN6701 CN3502
AC IN AC120V CN1
+26V CN151
EEPROM
SOS History White Balance adjustment data Non-uniformity Color Compensation data LCD Drive Control data Color Temperature Compensation data
CN8801 CN3001 CN3501
CN6003
CN6801
REMOTE SENSOR
POWER DRIVE DRIVE +3.3V LAMP
TUNER P.C.B.
TUNER CN8970 TUNER AUDIO (ANALOG) TUNER VIDEO (ANALOG) ANT-IN IF (DIGITAL) I2C SERIAL DATA/CLOCK
POWER SW
IC8001
PANEL STATUS(SOS (L)) PANEL SOS (L) SERIAL DATA/CLOCK I2C SERIAL DATA/CLOCK0 I2C SERIAL DATA/CLOCK3
IC7103
EEPROM
I2C SERIAL DATA/CLOCK
Model ID CPRM key for GalleryPlayer Setting data for Peaks Factory Adjustment data
IC8202,IC8203
PC AUDIO IN (L/R) 512M SDRAM
IC8404
PC-IN
IC7119
I2C SERIAL DATA/CLOCK0
IC7101
FPGA/LVDS TRANSMITTER
IC2901
CN2001
LCD/PRISM UNIT
LVDS RECEIVER
R DATA (40bit)
IC8802
LCD (R)
DEMODULATOR
IC5500
IC5501
PEAKS
G DATA (8bit)
G DATA (8bit)
LVDS DATA/CLOCK
G DATA (8bit)
EEPROM
HDMI2 INFORMATION DATA HDMI IN1 (AV IN) HDMI IN2 (AV IN)
EEPROM
HDMI1 INFORMATION DATA
CN2101
B DATA (8bit) TTL PARALLEL TO LVDS SERIAL CONVERTER B DATA (8bit)
IC5503
TMDS DATA/CLOCK
IC5510
I2C SERIAL DATA/CLOCK2 TMDS DATA/CLOCK I2C SERIAL DATA/CLOCK1
B DATA (8bit)
HDMI SW /EQUALIZER
IC2902
COLOR CORRECTION
R DATA (8bit)
G DATA (40bit)
LVDS RECEIVER
LCD (G)
IC7117
CN9804
EEPROM
HDMI3 INFORMATION DATA HDMI IN3 (AV IN) CN9801 SD DATA (4bit) TMDS DATA/CLOCK
EEPROM
I2C SERIAL DATA/CLOCK
MPEG DECODER JPEG DECODER VIDEO DECODER IP CONVERTER D/A CONVERTER AUDIO DECODER MICROCONTROLLER PICTURE CONTROL OSD
IC7113
MEMORY FPGA Software LVDS DATA/CLOCK
CN2201
G DATA (8bit)
IC7106
OSD FIFO MEMORY
B DATA (8bit)
B DATA (40bit)
IC9801
LCD (B)
HDCP KEY
TMDS DATA/CLOCK CN9802 CN8201 SD DATA (4bit)
EQUALIZER
SD CARD
TIMING GENERATOR
68
12 Schematic Diagrams
12.1. SCHEMATIC DIAGRAM & CIRCUIT BOARD LAYOUT NOTES
1. Important safety notice have special Components identified by the sign characteristics important for safety. When replacing any of these components. Use only the specified parts. 2. Do not use the part number shown on this drawing for ordering. The correct part number and part value is shown in the parts list, and may be slightly different or amended since this drawing was prepared. 3. Use only original replacement parts: To maintain original function and reliability of repaired units, use only original replacement parts which are listed with their part numbers in the parts list section of the service manual. 4. Parts different in shape or size may be used. However, only interchangeable parts will be supplied as service replacement parts. 5. Test point information : Test point with a jumper wire across a hole in P.C.B. : Test point with no test pin. 3. Parts marked "PT" are not used in any models included in this service model.
Example:
C6011 100P PT
C6011 PT
R6097 PT
4. Jumper wires are used for WA10, WA5 etc and these are not supplied as replacement parts.
IMPORTANT SAFETY NOTICE: COMPONENTS IDENTIFIED BY THE SIGN HAVE SPECIAL CHARACTERISTICS IMPORTANT FOR SAFETY. WHEN REPLACING ANY OF THESE COMPONENTS, USE ONLY THE SPECIFIED PARTS.
(14 Pins)
AC CORD
(2 Pins)
CN6003
(8 Pins)
(2 Pins) CN1
(12 Pins)
SD CARD SLOT HDMI IN 1 RGB IN DRIVE P.C.B. PC AUDIO IN HDMI IN 2 SPEAKER (R-CH) (2 Pins)
496
CN2001 (84 Pins) CN2753 LCD PANEL (GREEN) CN2901 CN2101 (50 Pins) (84 Pins) FRONT FAN CN2751 (3 Pins)
REAR FAN (35 Pins) FRONT JACK/OPERATION P.C.B. (2 Pins) VIDEO IN 3 AUDIO IN 3 L-CH AUDIO IN 3 R-CH CN6701 CN3502 (8 Pins) (6 Pins) REAR JACK P.C.B. CN3501 CN2752 (3 Pins)
PB COMPONENT IN 1
COMPONENT IN 2
AUDIO IN 1 R-CH
AUDIO IN 2 R-CH
AUDIO IN 1 L-CH
AUDIO IN 2 L-CH
S-VIDEO IN 1
VIDEO IN 1
VIDEO OUT
VIDEO IN 2
PR
PR
PB
70
CAUTION: FOR CONTINUED PROTECTION AGAINST FIRE HAZARD, REPLACE ONLY WITH THE SAME TYPE 6.3A 125V FUSE. ATTENTION: POUR UNE PROTECTION CONTINUE LES RISQUES D INCENDIE N UTILISERQUE DES FUSIBLE DE MME 6.3A 125V TYPE 6.3A 125V
IMPORTANT SAFETY NOTICE: COMPONENTS IDENTIFIED BY THE SIGN HAVE SPECIAL CHARACTERISTICS IMPORTANT FOR SAFETY. WHEN REPLACING ANY OF THESE COMPONENTS, USE ONLY THE SPECIFIED PARTS.
POWER(AC-DC)
T1002 ETS39AG4K5NC 18 17 16 15 14 13 12 D1001 B0EBNT000008 C1001 0.1u TP1002 HEAT SINK DRAIN(C) 9 C1002 560u 200V L1001 G0B123K00004 4 3 L1006 PT 2 VIN 7 L1005 PT SOURCE(E)/OCL 5 VCC 4 GND 3 F/B 2 Z/C IC1001 C0DACYY00003 (SWITCHING CONTROL) TP1001 1 C1011 1000p[KB] C1009 2200p 2kV D1006 B0EAKV000052 1NU41(TPA2,Q) 1000V,0.5A 6 L1003 J0JKA0000015 R1032 PT L1004 J0JHB0000021 * * 11 10 V1 V2 NC NC P2 NC PT NC P1 S3 S4 S5B S5A S1B S1A S2A S2B 2 3 4 5 6 7 8 9 *D1018 PT C1013 PT TP1003 J1003 WA5
COLD
TP1004
*C1035 PT
5600 R1024
TP1005
HOT
R1022 1/2W 150
D1011 B0JBSK000017
C1014 PT
D1015 MAZ41600MF
D1002 MAZ71200BC
D1004 MAZ73000BC
R1026 0.82 7W
R1006 2W 0.12
D1008 B0JCME000041
D1010 B0JBSK000017
PR1001 D4FA7R00A002 7A
*J1001 WA5
17
L1009 J0JHC0000031
R1011 10
L1011 J0JHC0000031
5600 R1027
L.F
Z1008 EYF52BCY
6.3A 125V
6.3A 125V
F1001 K5D632AQ0002
TP1006
L1007 J0JHC0000031
2 3
Audio_+18V Audio_+18V Audio_GND Audio_GND STBY_+7V AC_STOP REG_+30V TV_SUB_ON_H LCD_DRIVE_+17V REG_+9V REG_+9V GND GND GND
L1010 J0JHC0000031 1/2W D1007 B0HAJL000001 R1009 33 L1014 J0JHC0000031 L1015 J0JHC0000031 L1013 J0JHC0000031
4 5 6 7 8 9 10 11
R1021 0
R1005 3.9k
R1007 3.9k
L1012 J0JHC0000031
C1008 2200p
15 R1031 PT
K REF
COLD
1 R1019 3k PT R1030 0
RL801 K6B1CGA00055
IC1003 C0DAEZZ00003 (SHUNT REGULATOR) D809 B0EAKP000012 R808 2700 TV_SUB_ON_H TP805 WA10 Q801 2SD1819AHL (SWITCHING)
A
2
J853 WA5 RL802 K6B1CGA00055 L851 PT TO RF AMP POWER SUPPLY P.C.B. CN851 B0EAKP000012 D852
GND
VIN
Vo
Vc
R807 5600
SENSE
J854 WA5
GND
C816 PT
IC1004 C0DBZHG00012
CN1004
1 R826 2700 R827 5600 R1028 0 R1029 0 1.6 x 0.8 C1037 47u 50V 2
1 2
C852 PT
PT
D851
C851 0.47u
L.F L853 PT
1.6 x 0.8
L852 PT J852 WA5 J851 WA5 1/2W D808 R806 10 B0HAJL000001 Q1001 B1AAGD000016 (+12V REGULATOR) C1023 0.1u 50V
TP810 WA10
RELAY 12V
8A 125V
CN804 TP801 8A 125V Z801 Z802 EYF52BCY EYF52BCY F801 K5D802AQ0004 TP802 N D801 ERZV10V361CS GAP3.5 GAP3.5 GAP3.5 C801 1000p 250V C807 1000p 250V
HOT
1 NC S3 9 NC 8 S2 7 3 C809 PT J801 WA10 J804 WA10 GAP3.5 4 NC T801 G4C2AAD00008 S1 6 NC 5 * * L803 PT C808 PT * GAP3.5
BLACK
TP803
1/2W
C806 1u
L.F
D812 PT
COLD
COLD
POWER SCHEMATIC DIAGRAM PT-50LCZ70/PT-56LCZ70/PT-61LCZ70/PT-50LCZ7/PT-56LCZ7 /PT-61LCZ7/PT-50LCZ70-K/PT-56LCZ70-K/PT61LCZ70-K
71
D814 MAZ42700MF
D802 B0EDKT000009
R812 10k
R811 10k
AC_STOP
TP813
R818 15k +
R9888 0 R9889 0
PT
PT
C9823 PT
R9810
VCCA
8 VCCB 7 R9884 PT
SCLA
GND
R9901 PT
R9816 56
IC9803
SCLB
R9809
Q9802
R9900 PT
TP9808
TP9809
C9821 PT
TP9816
L9805 J0JHC0000045
R9840 56 R9841 56
47k
C9840 PT R9895 PT
C9822 PT
R9814 1k
CN9804
R9832 4700 C9813 10V 10u 24 23 GND 22 21 20 19 18 17 16 15 14 13
12
Q9801
R9808 0
ACKP
ACKN
ADT1P
ADT1N
ADT0P
C9803 PT C9801 C9802 0.1u[ZF] 0.1u[ZF] R9823 10k TP9806 TP9804 TP9807 TP9805 R9822 HPDT +5V DDCG SDA SCL N.C. CEC CLKCLKG CLK+ D0D0G D0+ D1D1G D1+ D2D2G D2+ 1 3 2 R9831 0 5 4 R9829 R9830 3.9 0 7 6 13 12 11 10 9 8 R9827 R9828 3.9 3.9 R9826 3.9 R9825 3.9 15 14 R9824 17 16 L9804 J0JHC0000045 3.9 19 18 L9801 J0JHC0000045 1k
Vcc
WP
SDA
SCL
C9826 C9825 PT PT
PT
SCL 6
B1
SDA B2 3 SCL A1 2
IC9804
-OE2 7 Vcc PT
C9807 0.1u[KB]
38 39 40
SEL VCC
CE YCKN YCKP
ADT0N
D9811 EZAEG2A50AX
GND
GND
VCC
0.1u[ZF]
6.3V
HDMI IN 3
4700
CN9803
IC9801
C1AB00002641 (EQUALIZER)
VCC TEST
VCC
R9801 10k
TP9810 TP9811
R9807 0
R9818 10k
R9821 39
36
35
34
33
32
31
30
29
28
27
26
R9894
R9891 PT
C9819 0.01u[KB]
37
25
2SD1819A0L (SWITCHING)
R9805 4700
SDA 5
A2
GND
IC9802
LSSK0120 (EEPROM)
R9833 PT
-OE1
PT
0.1u[KB] C9810
D2- 7 D2G 8
C9804 PT
C9805 22u
C9806
R9804
D9815 PT D9816 PT
GND
R9812 10k
C9817 0.01u[KB]
A0
A1
A2
BDT0N
Q9804
2SD1819A0L (SWITCHING)
R9813 10k
BDT0P
10
D9812 MAZ80560ML
11
13 14 Main2 3.3V 15 Main2 3.3V 16 Main5V 17 18 19 R9880 R9879 R9878 L9808 PT 0 0 0 AG_HDMI_5V_DET3 20 HPD3 21 HDMI_CE1 22 DDC5V 23 24 R9896 R9881 0 R9897 0 0 0 SCL 25 WP 26 SDA 27 CEC 28 29 TP9803 30 C9835 1000p[KB] C9834 1000p[KB] C9833 1000p[KB] C9832 1000p[KB] C9836 1000p[KB] C9837 1000p[KB] C9839 1000p[KB]
C9812 0.1u[KB]
CN9802
TO MAIN P.C.B. CN8201
D9801 EZAEG2A50AX D9802 EZAEG2A50AX D9803 EZAEG2A50AX D9804 EZAEG2A50AX D9805 EZAEG2A50AX D9806 EZAEG2A50AX D9809 EZAEG2A50AX D9810 EZAEG2A50AX
3.3V GND SDCLK GND SDCMD GND SDDTC SDDAT0 SDDAT2 SDDAT1 SDDAT3 SDWP
1 2 3 4 5 6 7 8 9 10 11 12 R9855 180
R9862 0 6.3V C9830 47u R9865 R9864 R9860 22 R9851 22 R9854 22 R9863 180 R9866 180 R9850 22 R9852
PT
R9873
R9872
R9868
R9876
R9870
R9871
R9869
R9874
CN9801
9 1 2 3 DAT2 DAT3 CMD GND VCC CLK GND DAT0 DAT1
180
4 5 6 7
R9867 180
10 CD D.SW 12 WP W.P.
COM 11
22
R9875 PT
R9861
R9877
72
2 4
VIDEO SIGNAL AUDIO SIGNAL
D3504 PT D3506 PT D3503 PT D3505 PT R3501 75 R3502 75 JK3501 S-VIDEO IN1 C Y G Y-G C-G G V V-G L L-G R-SW R R-G
1 2 3 4 5 6
D3502 PT
D3501 PT
R3503 75
R AUDIO IN1(R)
C3502 PT
C3501 PT
R3504 180k
JK3502 R3506 75 V V-G L L-G R R-G V L R VIDEO IN2 AUDIO IN2(L) AUDIO IN2(R)
R3507 180k
R3508 180k
R3509 PT JK3503 + C3505 470u 10V D3519 PT D3520 PT V V-G L L-G R R-G V L R VIDEO OUT AUDIO OUT(L) AUDIO OUT(R)
C3506 PT
D3521 PT D3522 PT
C3507 PT
D3523 PT D3524 PT
JK3504 GR GR-G B B-G R R-G JK3505 W-G WHITE R-G COMPONENT AUDIO IN1(L) COMPONENT AUDIO IN1(R) GR COMPONENT-Y1 B R COMPONENT-PB1 COMPONENT-PR1
JS2752 WA5
JS2751 PT
D3526 PT
D3525 PT
R3510 75
D3527 PT
R3511 75
D3529 PT D3531 PT
R3512 75
RED
R2786
1k
R2789
150k
R2788
1 1V 2
OUTPUT
V+ OUTPUT -
8 7 6 HZ L HH LL 2.5V
Q2756 PT
R2784
18k
R2787
270k
R3514 180k
R3513 180k
1k
JK3506 C3511 C3510 PT PT GR GR-G B B-G R R-G JK3507 GR COMPONENT-Y2 B R COMPONENT-PB2 COMPONENT-PR2
10k
10k
R2785
6800
22k
15k
56k
56k
56k
R2790
R2780
R2779
R2783
R2782
R2776
R2781
SDA_5V
SCL_5V
D3542 PT D3544 PT
RED
R2753 56k
R2755 56k
R2757 56k
R2759 56k
R2767 PT
R2760 1800
R2758 4700
R2756 10k
TP2751 2 L2757 PT 3 L2751 PT R2762 100 CN2752 (TO REAR FAN) 1 (FAN LOCK DET) Q2754 2SD1819AHL (FAN LOCK DET) R2764 100 L2753 PT R2763 100 TP2752 L2756 PT 9V L2752 PT C3509 PT IC2751 C0DBEKG00003 (FAN DRIVE) C3508 PT
120k[D]
R2777
3225
Q2753 2SD1819AHL
2 3 L2758 PT
C2758 0.1u[ZF]
C4140 1u[KB]
C4139
R2778
27k[D]
C2754 0.1u[ZF]
RD
C2767 PT
C2753 0.1u[ZF]
C2771 PT
J0JHC0000078
C2757 0.1u[ZF]
FAN 8V
VIN 1 Vc 2
GND
GND Vout
ADJ
TP2759
L4101 + +
100k
220
220
C4138
R4140
R4139
R4136
C2764 PT
C2766 PT
44
43
42
41
40
39
38
37
36
R4135
35 SCL
R4134
ROUT2 LOUT2 GND ROUT3
R2766 PT
L13
L12
L11
BIAS
2 AV2_L AV2_R (TO OPT FAN) CN2754 FAN3_+B FAN_GND FAN3_LOCK 1 2 3 L2759 PT L2761 PT L2762 PT TP2757 AV1_L C4106 C4107 C4108 C4109 C4110 C4111 1u[KB] 1u[KB] 1u[KB] 1u[KB] 1u[KB] 1u[KB] FAN3_LOCK_H C4103 C4104 1u[KB] 1u[KB] R4103 R4104 220 220 3 4 5 6 220 220 220 220 220 220 7 8 9 10 11
SDA
R12
R11
O2
ROUT1 LOUT1
L1
34
82k
33 32 31 30 29 28 27 26 25 24 R4126 R4125 R4124 R4123 220 220 1k 1k MAIN_R MAIN_L MON_R MON_L C4124 C4123 1u[KB] 1u[KB] R4148 R4147 100 100 JK3509 W-G WHITE R-G RED DVI AUDIO IN2(L)
22
GND 6
LOUT5 ROUT5
L6 O1
0.1u[ZF]
R5
FAN 6V
VIN Vc 1 2
AV1_R
L4 R4 L5
C2755
GND
Vout
C2759 0.1u[ZF]
ADJ
22
R10
L10
R6
R7
R8
R9
L7
L8
L9
23
R3522 180k
R2768 100k[D]
C3513 PT
C3512 PT
R4149
C2772 PT
C2752 0.1u[ZF]
R2769 27k[D]
RD
R4121
C2762
R4112
R4113
R4114
R4115
R4116
R4117
R4120
100k
R4141
Q4102 2SD0601ARL (MUTE-ON) Q4101 R4146 100 2SB0709A0L (DRIVE) R4145 100
220
220
220
220
220
220
220
220
1u[KB]
1u[KB]
1u[KB]
1u[KB]
1u[KB]
R2752 100 PT (TO LAMP FAN) CN2753 1 (TO THERMO2) PT CN2756 1 2 2 3 FAN4_+B FAN_GND FAN4_LOCK CN2755 1 2 3 L2760 PT L2763 PT L2764 PT TP2758
1u[KB]
1u[KB]
1u[KB]
C4112
C4114
C4115
C4116
C4120
C4113
DVI1_R
DVI1_L
TNR_R
DTV_R
C4117
FAN 7V
1 2 VIN Vc
GND
0.1u[ZF]
C2756
GND
Vout
C2751 0.1u[ZF]
TP2754
C2760 0.1u[ZF]
L2755 J0JCC0000077
R2751
FAN4_LOCK_H
R2770 120k[D]
ADJ
C2763 PT
R2771 27k[D]
R2773 PT R2772 PT
C2773 PT
AV3_R
DTV_L
AV3_L
C4121
73
180k
180k
R4122
R4150
D3548 PT
D3546 PT
R3521 180k
12
13
14
15
16
17
18
19
20
21
22
D3547 PT
D3545 PT
+ +
+ +
2 4
1 2 3 4 5 6
C4122 PT
C4125 PT
CN3501 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35
JS2751 PT
JS2753 PT R2765 PT
JS2752 WA5
R2786
1k
1k
R2789
150k
R2788
1 1V 2
OUTPUT
V+ OUTPUT -
8 7 6 HZ L HH LL 2.5V
10k
Q2756 PT
R2784
18k
R2787
270k
3 4
6800 56k
R2785
5
22k 56k
15k
56k
R2780
R2779
R2783
R2753 56k
R2755 56k
R2757 56k
R2759 56k
R2767 PT
R2760 1800
R2758 4700
R2756 10k
TP2751 2 L2757 PT
C2757 0.1u[ZF]
FAN 8V
VIN Vc 1 2
GND
L2752 PT
R2782
R2776
R2781
Q2753 2SD1819AHL
R2763 100
TP2752 L2756 PT
9V
+
74
J0JHC0000078
GND
Vout
ADJ
R2790
10k
TP2759
L4101
VIDEO SIGNAL
AUDIO SIGNAL
D3504 PT D3506 PT D3503 PT D3505 PT R3501 75 R3502 75
D3502 PT
D3501 PT
R3503 75
R AUDIO IN1(R)
C3501 PT
R3504 180k
JK3502 R3506 75 V V-G L L-G R R-G V L R VIDEO IN2 AUDIO IN2(L) AUDIO IN2(R)
R3507 180k
R3508 180k
R3509 PT JK3503 YUV2_U + C3505 470u 10V D3519 PT D3520 PT V V-G L L-G R R-G V L R VIDEO OUT AUDIO OUT(L) AUDIO OUT(R)
C3506 PT
D3521 PT D3522 PT
C3507 PT
D3523 PT D3524 PT
JK3504 GR GR-G B B-G R R-G JK3505 W-G WHITE R-G COMPONENT AUDIO IN1(L) COMPONENT AUDIO IN1(R) GR COMPONENT-Y1 B R COMPONENT-PB1 COMPONENT-PR1
D3526 PT
D3525 PT
R3510 75
D3528 PT
D3527 PT
R3511 75
D3530 PT
D3529 PT D3531 PT
R3512 75
RED
R2789
150k
R3514 180k
R2784
18k
R2787
270k
R3513 180k
JK3506 C3511 C3510 PT PT GR GR-G B B-G R R-G JK3507 GR COMPONENT-Y2 B R COMPONENT-PB2 COMPONENT-PR2
SDA_5V
SCL_5V
D3542 PT D3544 PT
RED
C3509 PT
C3508 PT
TP2759
J0JHC0000078 L4101 +
75
R2765
PT
R2786
1k
R2789
150k
1k
R2788
1 1V 2
OUTPUT
V+ OUTPUT -
8 7 6 HZ L HH LL 2.5V
Q2756 PT
R2784
18k
R2787
270k
10k
R2785
6800
22k
15k
56k
56k
R2780
R2779
R2783
R2753 56k
R2755 56k
R2757 56k
R2759 56k
R2767 PT
R2760 1800
R2758 4700
R2756 10k
TP2751 2 L2757 PT 3 L2751 PT R2762 100 CN2752 (TO REAR FAN) 1 (FAN LOCK DET) Q2754 2SD1819AHL (FAN LOCK DET) R2764 100 L2753 PT R2763 100 TP2752 L2756 PT 9V L2752 PT
R2782
R2776
C2757 0.1u[ZF]
FAN 8V
VIN Vc 1 2
GND
R2781
56k
120k[D]
R2777
3225
Q2753 2SD1819AHL
2 3 L2758 PT
C2758 0.1u[ZF]
R2778
27k[D]
C2753 0.1u[ZF]
C2754 0.1u[ZF]
RD
C2767 PT
C2771 PT
C2764 PT
C2766 PT
AV2_L AV2_R (TO OPT FAN) CN2754 FAN3_+B FAN_GND FAN3_LOCK 1 2 3 L2759 PT L2761 PT L2762 PT TP2757 AV1_L
+
R4103 R4104 C4105 R4106 R4107 R4108 R4109 R4110 R4111
R2766 PT
C4103 C4104 1u[KB] 1u[KB] C4106 C4107 C4108 C4109 C4110 C4111 1u[KB] 1u[KB] 1u[KB] 1u[KB] 1u[KB] 1u[KB]
GND 6
FAN 6V
VIN Vc 1 2
0.1u[ZF]
C2755
GND
Vout
TP2753 PT [COVER SW for HID] CN2757 COVER_SW GND 1 2 L2754 J0JCC0000077 FAN3_LOCK_H
C2759 0.1u[ZF]
R2768 100k[D]
ADJ
C2752 0.1u[ZF]
R2769 27k[D]
RD
C2772 PT
C2762
R2752 100 PT (TO LAMP FAN) CN2753 1 (TO THERMO2) PT CN2756 1 2 2 3 FAN4_+B FAN_GND FAN4_LOCK CN2755 1 2 3 L2760 PT L2763 PT L2764 PT TP2758
FAN 7V
1 2 VIN Vc
GND
0.1u[ZF]
C2756
GND
Vout
C2751 0.1u[ZF]
TP2754
C2760 0.1u[ZF]
L2755 J0JCC0000077
R2751
FAN4_LOCK_H
R2770 120k[D]
ADJ
C2763 PT
R2771 27k[D]
R2773 PT R2772 PT
76
C2773 PT
J0JHC0000078
GND
Vout
ADJ
R2790
10k
TP2759
L4101 + + + + + + +
D3530 PT
D3529 PT D3531 PT
R3512 75
RED
R2789
150k
R3514 180k
R2784
18k
R2787
270k
R3513 180k
JK3506 C3511 C3510 PT PT GR GR-G B B-G R R-G JK3507 GR COMPONENT-Y2 B R COMPONENT-PB2 COMPONENT-PR2
SDA_5V
SCL_5V
D3542 PT D3544 PT
RED
C3509 PT
C3508 PT
TP2759
C4140 1u[KB]
C4139
RD
J0JHC0000078
L4101 +
100k
220
220
C4138
R4140
R4139
C2764 PT
C2766 PT
R4136
R4135 36
R4134 35
ROUT2 LOUT2 GND ROUT3
R2766 PT
44
43
42
41
40
39
38
BIAS
2 AV2_L AV2_R TP2757 AV1_L AV1_R YUV2_L IC2753 C0DBEKG00003 (FAN DRIVE) YUV2_R YUV1_L YUV1_R C4106 C4107 C4108 C4109 C4110 C4111 1u[KB] 1u[KB] 1u[KB] 1u[KB] 1u[KB] 1u[KB] C4103 C4104 1u[KB] 1u[KB] R4103 R4104 220 220 3 4 5 6 220 220 220 220 220 220 7 8 9 10 11
SDA
SCL
L13
L12
R12
R11
L11
O2
37
ROUT1 LOUT1
L1
34
82k
33 32 31 30 29 28 27 26 25 24 R4126 R4125 R4124 R4123 220 220 1k 1k MAIN_R MAIN_L MON_R MON_L C4124 C4123 1u[KB] 1u[KB] R4148 R4147 100 100 JK3509 W-G WHITE R-G RED DVI AUDIO IN2(L)
22
LOUT5 ROUT5
L6 O1
R4 L5
R5
L4
22
R10
L10
R6
R7
R8
R9
L7
L8
L9
R3522 180k
C3513 PT
C3512 PT
R4149
C2772 PT
R4121
R4112
R4113
R4114
R4115
R4116
R4117
R4120
100k
Q4102 2SD0601ARL (MUTE-ON) Q4101 R4146 100 2SB0709A0L (DRIVE) R4145 100
220
220
220
220
220
220
220
220
R4141
1u[KB]
1u[KB]
1u[KB]
1u[KB]
1u[KB]
1u[KB]
1u[KB]
1u[KB]
C4112
C4114
C4115
C4116
C4120
C4113
TP2758
DVI1_R
DVI1_L
TNR_R
DTV_R
C4117
R2773 PT R2772 PT
C2773 PT
AV3_R
DTV_L
AV3_L
C4121
77
180k
180k
R4122
R4150
D3548 PT
D3546 PT
R3521 180k
13
14
15
16
17
18
19
20
21
12
22
23
D3547 PT
D3545 PT
+ +
VIDEO SIGNAL
CN6701 1 2 3 TO REAR JACK P.C.B. CN3502 4 5 6 7 TO MAIN P.C.B. CN4501-1,2 8 LINE3_V
AUDIO SIGNAL
TUNER
JK6701 GND LINE3_L_AUDIO GND LINE3_R_AUDIO
R6709 180k R6708 180k R6707 75
TU8970 ENGE6601KF ENGE6601KF L8973 J0JHC0000045 1 2 3 4 5 AH_R_ANALOG SDA L8970 J0JHC0000045 SCL AH_AFT C8984 L8971 J0JHC0000034 VIDEO_OUT 6 7 8 9 10 11 12 13 47 47 IF_OUT_P IF_OUT_N 14 15 16 17 18 19 20 L8972 R8973 R8974 J0JHC0000045 0.39u 0.39u R8972 0 AH_L_ANALOG 2 3 4 5
5V_BB
BB
NC NC L OUT R OUT
CN8970
1
D6701 PT
D6702 PT
D6703 PT
NC
C8972 1000p[KB] 6.3V C8973 330u + C8974 0.1u[KB] TP6707 1/10W 1.6 x 0.8 R6706 PT PT SW6706 OK PT SW6707 MENU C8975 0.01u[KB] C8976 50V 56u + 30V_TU C8977 82p C8978 82p C8979 50V 10p
6 AGC Monitor
TU BV NC BTL SDA SCL AFT NC
7 8 9 10 11 12 13 14 15
TP6701 1/10W 1.6 x 0.8 R6701 1.74k EVQ11G05R SW6701 VOL DOWN
TP6706
17 18
5V_BV
19 20 21
0V
JS8970 WA5
R6801 22k
B3AAA0000975 D6802
RM6801 B3RAD00001431
GND VCC OUT
LAMP
(LED DRIVE) Q6803 2SB1218A0L Q6802 2SB1218A0L (LED DRIVE)
R6803 PT
R6810 R6812 10k 10k
R6807 0
6.3V
R6816 10k
R6815 10k
R6804 180
R6805 100
C6801 R6809 RD R6802 100 R6811 10k D6803 B3AGA0000072 STANDBY 10k R G
6 7 8
LAMP_LED
47u
FRONT JACK/OPERATION SCHEMATIC DIAGRAM POWER SWITCH/OPERATION SCHEMATIC DIAGRAM TUNER SCHEMATIC DIAGRAM PT-50LCZ70/PT-56LCZ70/PT-61LCZ70/PT-50LCZ7/PT-56LCZ7 /PT-61LCZ7/PT-50LCZ70-K/PT-56LCZ70-K/PT61LCZ70-K
78
L802 C801
COLD
TP801
COLD
L851
L803 L853
HOT
L852
HOT
6.3A 125V
C802
L1006
8A 125V
L1005
F1001
T801 C851 C1001 1 1 2 RL801 RL802 R1010 R1025 C1011 D1002 4 3 IC1002 1 2 3 4 D852
C1008
C B E
2 C808
3 C809 C807
R801
HOT
D851 D1001
COLD
TP805 Q1001 B C E C1022 C1023 R1023 C1026 CN1003 L1009 1 D1016
R827
R826 C852
C BE
COLD
R808 9 7 6 2 D802 D814 3 4 TP803 D808 TP810 D812
C B E
1 C804
Q806 TP804
3 D809
Q801
R807 C816
R1006
D1015
C1002
D1004
C805
C1004
D1003
R1009 R1022
Q803
C1010
C815
7 8 9 10 11 12
2 3 4 5 14
R1011
HOT
L1004
COLD
TP1005 C1015 R1016 D1017 D1010
C1031
R1027
C1012
R806
D811
PR1001 L1011
D1012 C1014
13 15
6 16 7
C1016
1 11 10
HOT COLD
8 9
C1036
C1018
1 C1019
5 R1028 R1029
COLD
C1037
COLD
HOT CIRCUIT. BE CAREFUL AND USE AN ISOLATION TRANSFORMER WHEN SERVICING.
LSJB3237
79
(COMPONENT SIDE)
(FOIL SIDE)
TP9801
CL9801 R9878
TP9815
R9880
R9897
Q9802 B R9802
R9803 L9806
L9808
R9896
R9885
L9809 C9839
R9855
R9868 R9856
L9805 R9815
C9823
R9861
R9889
R9888
CL9803
R9866
R9867 R9850
IC9803
11 10
R9863
1 9
R9854 R9853 R9865 R9859 R9873 R9851 R9860 R9872 R9864 R9857 R9858
C9824
R9876
C9812 C9817
C9811
R9832
R9813
E B
C9816
C9831
R9895
C9810 C9819
TP9818
R9814
D9809
48
D9803
36 37
R9886
Q9804
TP9813 4 IC9802
R9823
C9803
D9802
R9821 L9804
C9802
D9811
R9801
C9807 Q9801
E B C
R9825 R9826
R9804
R9827 R9828
R9829
R9830 R9831
D9801
R9824 19
D9816
TP9808
D9815
D9808 D9807
R9852
TP9811
TP9807
D9812
SD CARD SLOT
L9801
TP9809
R9818 C9801
C9818
TP9817
R9899
C9813 FL9801
R9901
C9814
TP9816 TP9819
LSJB3241
LSJB3241
80
R9816
R9884 R9883 8 5
TP9803
JK3501
CN3501 1
C2751
C2766
R2761
L2755
L2752
R2754
Q2751
EB C
JK3506
JK3504
C2764 R2778
JK3503
JK3502
TP2752 R2756
C2758
R3515
L2758 C2753
C4113
C4112
R2759 CN2752 1 3
D3520 D3535 COMPONENT -Y1 D3536 JK3505 D3525 VIDEO OUT D3519 D3526 VIDEO IN 2
L2756
L4101 R4111 R4110 R4109 R4108 R4107 C4105 C4101 R4106 R4104 R4103 C4138 C4104 C4103 COMPONENT AUDIO IN2(L) D3543 COMPONENT -PR2 D3542 C4111 C4110 C4109 C4108 C4107 C4106 JK3507 COMPONENT -Y2
R3503
R2757
R2787 R2784
R2762
CN2755 C2757 1 3
C2754
R2758
C4116
R4115
R3518
C3509
Q2754
C4124
C4123
R2790
R2753
C4120 C4121
D3527
R3507 C3504
R2764
D3537
D3531
R3504
R2763 R2760
R2766
C3502
CN2753 1 3
L2764
CN2754 3 1
Q2753
R4117 R4116
C BE
R4114
C4117
C3511
R4147
R4148
L2760 C2760
D3538
C3506
TP2754
R4149
R4150
R4124
C3508
R2786
R3508
C2763
R4134
R4135 R4136
R3512
C2773 5 IC2754
C2761
R3517
C2762 C2772
5 1
C4139
D3544
C3507
D3539 D3533
R3513 C3510
B E Q4102
B E Q4103
R4123
C3503 D3517 AUDIO IN 2(R) D3518 D3511 AUDIO IN 1(R) R3505 D3548 C3501 D3512 D3546
C3512
R3521
44
R3516
IC2756
IC4101
R3511
D3532
D3528
D3522
R3522
TP2751
C3513
L2757 L2751
C Q2752 BE C BE
R4113
R4112
R3510
C4115
R3506
C4114
D3514
R3501
C2771
C2767
C3505
R3509
R3502
R2767
34
C B E Q4101
R3519
R4139
R4140
D3540
IC2753
LSJB3230
81
TP6703
TP6702
TP6701
TP6705
TP6706
TP6707
R6702
R6701
R6704
R6705
R6706
CH UP
CH DOWN
VOL OP
VOL DOWN
TV/VIDEO
OK
MENU
CN6701
LSJB3231
R6805
CN6801
W8978 W8979
LAMP
Q6804 R6815
R6811
D6803
STANDBY
SW6801 POWER
R6801
R6809
1
C8970 C8971 W8980 L8973 L8970 C8975 C8976 R8970 TU8970 C8977 R8971 W8977 W8976 1 2 W8975 W8974 W8973 CN8970 W8972 C8978 C8979 W8981 L8972 C8981 C8980 C8982 C8972
R6804
LSJB3232
C8973 C8974
L8971 C8984
21 R8972 19 20 C8983
LSJB3233
FRONT JACK/OPERATION P.C.B. LSEP3231A TUNER P.C.B. LSEP3233A POWER SWITCH/OPERATION P.C.B. LSEP3232A PT-50LCZ70/PT-56LCZ70/PT-61LCZ70/PT-50LCZ7/PT-56LCZ7 /PT-61LCZ7/PT-50LCZ70-K/PT-56LCZ70-K/PT61LCZ70-K
82
14 Exploded Views
14.1. MAIN PARTS SECTION
83
84
85
86
87
88
89
90
91
92
NR: MGF CHIP: C CHIP: COMPLX CMP: W FLMPRF: C.B.A.: P.C.B.: E.S.D.:
93
Ref. No. 50 51 51 51 51 51 51 52 52 52 53 53 53 54 55 55 56 57 57 57 58 58 58 59 60 61 61
Part No. LFS4000PA1EB LSYK2135 LSYK2136 LSYK2137 LSYK2190 LSYK2191 LSYK2192 LSGP0556 LSGP0560 LSGP0562 LSGP0555 LSGP0559 LSGP0561 LSXA0886 LSXA0945 LSXA0887 TBMA220 LSGV0137 LSGV0139 LSGV0140 LSDL0411 LSDL0311 LSDL0312 LSMA1011 LSMA1017 LSYF0602 LSYF0602 LSYF0603 LSMA0991 LSMF0499 LSMF0500 LSQL2173 LSMA1005 LSMA1006 LSJA0641 LSRF0016 TMM5439-1 LSPG2449 LSPG2450 LSPG2451 LSPG2496 LSPG2497 LSPG2498 LSPG2443 LSPG2445 LSPG2447 LSPN0803 LSPN0804 LSPN0805 LSPN0806 LSPN0831 LSPF0111 LSPF0161 N2QAYB000100 LSQF1254 LSQF1255 LSPN0807 LSPN0808 LSPN0809 LSPN0810 LSFQ0003-B LSSC0963 LSSC0992-1 L6FAYYYH0053 KGLS-6S LSGQ0176 LSMA1009
Remarks
Definition of Parts supplier: 1. Parts with mark "PSEC" in the Remarks column are supplied from PSEC. 2. Parts without mark in the Remarks column are supplied from PSTC-NPC.
62 63 65 65 66 68 72 73 74 83 101 101 101 101 101 101 102 102 102 103 104 105 106 107 108 108 109 111 111 112 113 114 114 118 205 206 207 208 209 213
6 PSEC ESCUTCHEON SUB UNIT ( A,G ) 4 ESCUTCHEON SUB UNIT ( B,H ) 4 ESCUTCHEON SUB UNIT ( C,I ) 4 ESCUTCHEON SUB UNIT ( D ) 4 ESCUTCHEON SUB UNIT ( E ) 4 ESCUTCHEON SUB UNIT ( F ) 4 LENTICULAR SCREEN ( A,D,G ) 4 LENTICULAR SCREEN ( B,E,H ) 4 LENTICULAR SCREEN ( C,F,I ) 4 FRESNEL LENS ( A,D,G ) 4 FRESNEL LENS ( B,E,H ) 4 FRESNEL LENS ( C,F,I ) 4 SCREEN SUPPORT H UNIT 4 SCREEN SUPPORT V UNIT ( A,D,G 4 ) SCREEN SUPPORT V UNIT ( 4 B,C,E,F,H,I ) PANASONIC BADGE 4 BACK COVER ( A,D,G ) 3 BACK COVER ( B,E,H ) 3 BACK COVER ( C,F,I ) 3 MIRROR ( A,D,G ) 3 MIRROR ( B,E,H ) 3 MIRROR ( C,F,I ) 3 LAMP BRACKET TOP 6 LAMP BRACKET UNDER 6 MIRROR HOLDER H UNIT ( A,D,G 3 ) MIRROR HOLDER H UNIT ( 3 B,C,E,F,H,I ) MIRROR HOLDER V UNIT 3 RFP STAY PLATE 6 SPACER ( A,B,D,E,G,H ) 3 SPACER ( C,F,I ) 3 LABEL ( B,C,E,F,H,I ) 4 SCREEN SUPPORT CORNER ( 4 B,C,E,F,H,I ) LAMP SUPPORT SHIELD 6 AC CORD 5 BLOWER 6 CLAMPER 6 PSEC CARTON BOX ( A,G ) 7 CARTON BOX ( B,H ) 7 CARTON BOX ( C,I ) 7 CARTON BOX ( D ) 7 CARTON BOX ( E ) 7 CARTON BOX ( F ) 7 CARTON BOX BOTTOM ( A,D,G ) 7 CARTON BOX BOTTOM ( B,E,H ) 7 CARTON BOX BOTTOM ( C,F,I ) 7 CUSHION TOP L 7 CUSHION TOP R 7 CUSHION BOTTOM L 7 CUSHION BOTTOM R 7 CUSHION BOTTOM CENTER 7 BAG,POLYETHYLENE ( 7 A,B,C,E,F,G,H,I ) BAG,POLYETHYLENE ( D ) 7 REMOTE CONTROL UNIT 7 FAN BAG UNIT ( A,B,C,D,E,F ) 7 FAN BAG UNIT ( G,H,I ) 7 CUSHION SIDE L 7 CUSHION SIDE R 7 CUSHION BACK ( B,E,H ) 7 CUSHION BACK ( C,F,I ) 7 CLEANING CLOTH 7 LAMP SHIELD CASE FRONT 5 FAN SHIELD REAR 5 DC FAN MOTORS 5 CLAMPER 5 CLAMPER 5 POWER P.C.B. SHIELD 5
94
Ref. No. 214 215 223 236 237 238 239 401 403 404 410 417 421 434 452 453 454 465 465 478 479 482 493 494 710 711 712 713 714 716 721 724 725 726 750 E20 E30 E40 E50 E60 E70 301 302 495 496
Part No. LSMZ0426 LSJH0096 LSXK0303 LSMF0367 LSJA0635 LSJA0636 LSJA0639 XTV4+16AFJ XTV3+8FFJK XTV3+30JFJ XYN4+J8FJ XYN3+K10FN XTV3+8GFJ XYN3+F10FJ XTV3+8FFJ XTV3+10JFJ XTV4+16AFJK XTV4+12AFJ XTV4+12AFJ LSHD0099-FJ XYE3+FJ8FJ XYN3+J8FJ XVE3B10FN XVE3B20FN LSMP0559-1 LSMP0558 LSMC0161 K1PY30Y00005 LSJA0629 LSSC0978 EYF52BCY LSSC0766 LSSC0996 LSSC0997 VZFS0006 LSEP3231A LSEP3232A LSXA0915 LSEP3237B LSEP3230A LSEP3233A LSMF0549 LSMF0550 XWA3BFN LSJA0626
Part Name & Description BARRIER REAR JACK HOLDER RF AMP POWER SUPPLY P.C.B.NR
Remarks
5 5 5 PSEC SHEET,NYLON-RAYON 5 LAMP-MAIN HARNESS 5 RF AMP POWER-LAMP HARNESS 5 THERMAL FUSE 5 TAPPING SCREW,STEEL 1,3 TAPPING SCREW,STEEL 2 TAPPING SCREW,STEEL 5 SCREW W/WASHER,STEEL 6 PSEC SCREW W/WASHER,STEEL 5 TAPPING SCREW,STEEL 1 SCREW W/WASHER,STEEL 5 TAPPING SCREW,STEEL 2,5 TAPPING SCREW,STEEL 5 TAPPING SCREW,STEEL 1 TAPPING SCREW,STEEL ( A,D,G ) 2,3,4 TAPPING SCREW,STEEL ( 2,3,4 B,C,E,F,H,I ) SCREW,STEEL 1 SCREW W/WASHER,STEEL 5 SCREW W/WASHER,STEEL 5,6 PSEC SCREW,STEEL 6 SCREW,STEEL 6 SD SHIELD CASE 2 SD SUPPORT ANGLE 2 SD EARTH SPRING 2 HDMI INTERNAL HARNESS 2 SD-MAIN HARNESS 2 HEAT SINK 5 FUSE HOLDER 5 HEAT SINK 5 ELECTROMAGNETIC WAVE 5 ABSORPTION SHEET ELECTROMAGNETIC WAVE 5 ABSORPTION SHEET CLAMPER 2 FRONT JACK/OPERATION P.C.B. 2 RTL POWER SWITCH/OPERATION P.C.B. 2 RTL SD/HDMI P.C.B. 2 RTL POWER P.C.B. 5 RTL REAR JACK P.C.B. 5 RTL TUNER P.C.B. 5 RTL SPONGE 1 5 SPONGE 2 5 SPRING WASHER 6 FRONT MAIN HARNESS 2
FRONT JACK/OPERATION P.C.B. RTL POWER SWITCH/OPERATION P.C.B. RTL SD/HDMI P.C.B. E.S.D. RTL POWER P.C.B. RTL REAR JACK P.C.B. RTL TUNER P.C.B. RTL
PIN HEADER
Ref. No. CN6701 Part No. K1KA08BA0061 Part Name & Description CONNECTOR 8P Remarks
SWITCHES
Ref. No. SW6701 SW6702 SW6703 SW6704 SW6705 Part No. EVQ11G05R EVQ11G05R EVQ11G05R EVQ11G05R EVQ11G05R Part Name & Description SWITCH SWITCH SWITCH SWITCH SWITCH PUSH PUSH PUSH PUSH PUSH Remarks
JACK
Ref. No. JK6701 Part No. K2HA306A0037 Part Name & Description JACKS FOR SMALL (EQUIPMENT SIDE ) SIGNAL Remarks
95
DIODES
Ref. No. D6802 or D6802 D6803 Part No. B3AAA0000975 B3AAA0000538 B3AGA0000072 Part Name & Description LIGHT EMITTING DIODE LIGHT EMITTING DIODE LIGHT EMITTING DIODE GREEN Remarks
RESISTORS
Ref. No. R6801 R6802 R6804 R6805 R6806 R6807 R6808 R6809 R6810 R6811 R6812 R6815 R6816 Part No. ERJ3GEYJ223V ERJ3GEYJ101V ERJ3GEYJ181V ERJ3GEYJ101V ERJ3GEYJ471V ERJ3GEY0R00V ERJ3GEYJ101V ERJ3GEYJ103V ERJ3GEYJ103V ERJ3GEYJ103V ERJ3GEYJ103V ERJ3GEYJ103V ERJ3GEYJ103V MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF Part Name & Description CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 22K 100 180 100 470 0 100 10K 10K 10K 10K 10K 10K Remarks
Ref. No. D9806 D9807 D9808 D9809 D9810 D9811 D9812 D9813 D9814
Part No. EZAEG2A50AX EZAEG2A50AX EZAEG2A50AX EZAEG2A50AX EZAEG2A50AX EZAEG2A50AX MAZ80560ML MA22F2000L MA22F2000L
Part Name & Description OTHER FILTERS OTHER FILTERS OTHER FILTERS OTHER FILTERS OTHER FILTERS OTHER FILTERS DIODE ZENER CHIP 5.6V SMALL CAPACITY SILICON RECTIFIER DIODES SMALL CAPACITY SILICON RECTIFIER DIODES
Remarks
RESISTORS
Ref. No. R9801 R9802 R9803 R9804 R9805 R9806 R9807 R9808 R9811 R9812 R9813 R9814 R9815 R9816 R9818 R9821 R9822 R9823 R9824 R9825 R9826 R9827 R9828 R9829 R9830 R9831 R9832 R9840 R9841 R9850 R9851 R9852 R9853 R9854 R9855 R9856 R9857 R9858 R9859 R9860 R9861 R9862 R9863 R9864 R9865 R9866 R9867 R9876 R9878 R9879 R9880 R9881 R9882 R9888 R9889 R9896 R9897 R9898 Part No. ERJ3GEYJ103V ERJ3GEYJ103V ERJ3GEYJ103V ERJ3GEYJ472V ERJ3GEYJ472V ERJ3GEYJ473V ERJ3GEY0R00V ERJ3GEY0R00V ERJ3EKF4701V ERJ3GEYJ103V ERJ3GEYJ103V ERJ3GEYJ102V ERJ3GEY0R00V ERJ3GEYJ560V ERJ3GEYJ103V ERJ3GEYJ390V ERJ3GEYJ102V ERJ3GEYJ103V ERJ3GEYJ3R9V ERJ3GEYJ3R9V ERJ3GEYJ3R9V ERJ3GEYJ3R9V ERJ3GEYJ3R9V ERJ3GEYJ3R9V ERJ3GEYJ3R9V ERJ3GEYJ3R9V ERJ3GEYJ472V ERJ3GEYJ560V ERJ3GEYJ560V ERJ3GEYJ220V ERJ3GEYJ220V ERJ3GEYJ220V ERJ3GEYJ220V ERJ3GEYJ220V ERJ3GEYJ181V ERJ3GEYJ220V ERJ3GEYJ220V ERJ3GEYJ220V ERJ3GEYJ220V ERJ3GEYJ220V ERJ3GEY0R00V ERJ6GEY0R00V ERJ3GEYJ181V ERJ3GEYJ181V ERJ3GEYJ181V ERJ3GEYJ181V ERJ3GEYJ181V ECJ1VC1H470J ERJ3GEY0R00V ERJ3GEY0R00V ERJ3GEY0R00V ERJ3GEY0R00V ERJ3GEYJ473V ERJ3GEY0R00V ERJ3GEY0R00V ERJ3GEY0R00V ERJ3GEY0R00V ERJ3GEY0R00V Part Name & Description MGF CHIP 1/16W 10K MGF CHIP 1/16W 10K MGF CHIP 1/16W 10K MGF CHIP 1/16W 4.7K MGF CHIP 1/16W 4.7K MGF CHIP 1/16W 47K MGF CHIP 1/16W 0 MGF CHIP 1/16W 0 MGF CHIP 1/16W 4.7K MGF CHIP 1/16W 10K MGF CHIP 1/16W 10K MGF CHIP 1/16W 1K MGF CHIP 1/16W 0 MGF CHIP 1/16W 56 MGF CHIP 1/16W 10K MGF CHIP 1/16W 39 MGF CHIP 1/16W 1K MGF CHIP 1/16W 10K MGF CHIP 1/16W 3.9 MGF CHIP 1/16W 3.9 MGF CHIP 1/16W 3.9 MGF CHIP 1/16W 3.9 MGF CHIP 1/16W 3.9 MGF CHIP 1/16W 3.9 MGF CHIP 1/16W 3.9 MGF CHIP 1/16W 3.9 MGF CHIP 1/16W 4.7K MGF CHIP 1/16W 56 MGF CHIP 1/16W 56 MGF CHIP 1/16W 22 MGF CHIP 1/16W 22 MGF CHIP 1/16W 22 MGF CHIP 1/16W 22 MGF CHIP 1/16W 22 MGF CHIP 1/16W 180 MGF CHIP 1/16W 22 MGF CHIP 1/16W 22 MGF CHIP 1/16W 22 MGF CHIP 1/16W 22 MGF CHIP 1/16W 22 MGF CHIP 1/16W 0 MGF CHIP 1/10W 0 MGF CHIP 1/16W 180 MGF CHIP 1/16W 180 MGF CHIP 1/16W 180 MGF CHIP 1/16W 180 MGF CHIP 1/16W 180 C CHIP 50V 47PF MGF CHIP 1/16W 0 MGF CHIP 1/16W 0 MGF CHIP 1/16W 0 MGF CHIP 1/16W 0 MGF CHIP 1/16W 47K MGF CHIP 1/16W 0 MGF CHIP 1/16W 0 MGF CHIP 1/16W 0 MGF CHIP 1/16W 0 MGF CHIP 1/16W 0 Remarks
CAPACITOR
Ref. No. C6801 Part No. ECEA0JKA470 Part Name & Description ELECTROLYTIC 6.3V 47UF Remarks
PIN HEADER
Ref. No. CN6801 Part No. K1KA08BA0061 Part Name & Description CONNECTOR 8P Remarks
SWITCH
Ref. No. SW6801 Part No. EVQ11G05R Part Name & Description SWITCH PUSH Remarks
MISCELLANEOUS
Ref. No. RM6801 Part No. B3RAD0000143 Part Name & Description INFRARED RECEIVER Remarks
E.S.D.
TRANSISTORS
Ref. No. Q9801 or Q9801 or Q9801 Q9802 or Q9802 or Q9802 Q9804 or Q9804 or Q9804 Part No. 2SD1819A0L B1ABCF000020 B1ABCF000112 2SD1819A0L B1ABCF000020 B1ABCF000112 2SD1819A0L B1ABCF000020 B1ABCF000112 Part Name & Description TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP Remarks
DIODES
Ref. No. D9801 D9802 D9803 D9804 D9805 Part No. EZAEG2A50AX EZAEG2A50AX EZAEG2A50AX EZAEG2A50AX EZAEG2A50AX Part Name & Description OTHER OTHER OTHER OTHER OTHER FILTERS FILTERS FILTERS FILTERS FILTERS Remarks
96
CAPACITORS
Ref. No. C9801 C9802 C9805 C9806 C9807 C9808 C9809 C9810 C9811 C9812 C9813 C9814 C9815 C9816 C9817 C9818 C9819 C9820 C9830 C9831 Part No. F1H1E104A030 F1H1E104A030 F2G0J2200006 F1H1E104A030 F1H1C104A065 F1H1C104A065 F1H1C104A065 F1H1C104A065 F1H1C104A065 F1H1C104A065 F1J1A106A024 F1H1C104A065 ECJ1VB1H103K ECJ1VB1H103K ECJ1VB1H103K ECJ1VB1H103K ECJ1VB1H103K ECJ1VB1H103K EEE0JA470SR F1H1C104A008 Part Name & Description C CHIP 25V 0.1UF C CHIP 25V 0.1UF ELECTROLYTIC CHIP 6.3V 22UF C CHIP 25V 0.1UF C CHIP 16V 0.1UF C CHIP 16V 0.1UF C CHIP 16V 0.1UF C CHIP 16V 0.1UF C CHIP 16V 0.1UF C CHIP 16V 0.1UF C CHIP 10V 10UF C CHIP 16V 0.1UF C CHIP 50V 0.01UF C CHIP 50V 0.01UF C CHIP 50V 0.01UF C CHIP 50V 0.01UF C CHIP 50V 0.01UF C CHIP 50V 0.01UF ELECTROLYTIC 6.3V 47UF C CHIP 16V 0.1UF Remarks
Ref. No. D808 D809 D811 D814 D852 D1001 D1002 D1003 D1004 D1006 D1007 D1008 D1009 D1010 D1011 D1012 D1015 D1016 D1017
Part No. B0HAJL000001 B0EAKP000012 MA3X152E0L MAZ42700MF B0EAKP000012 B0EBNT000008 MAZ71200BC B0HAJL000001 MAZ73000BC B0EAKV000052 B0HAJL000001 B0JCME000041 MAZ40910HF B0JBSK000017 B0JBSK000017 B0HAJL000001 MAZ41600MF MAZ41300MF MAZ43000MF
Part Name & Description DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE SI SI SI CHIP ZENER 27V SI SI ZENER 12V SI ZENER 300V SI SI SI CHIP ZENER 9.4V SI SI SI ZENER 16V ZENER 13V ZENER 30V
Remarks
RESISTORS
Ref. No. R801 R806 R807 R808 R811 R812 R813 R818 R820 R821 R822 R823 R826 R827 R1001 R1005 R1006 R1007 R1008 R1009 R1010 R1011 R1012 R1013 R1014 R1016 R1017 R1018 R1019 R1021 R1022 R1023 R1024 R1025 R1026 R1027 Part No. D0AF825KA002 ERDS1TJ100T ERJ6GEYJ562V ERJ6GEYJ272V ERJ6GEYJ103V ERJ6GEYJ103V ERA3YED222V ERJ6ENF1502V ERJ6GEYJ104V ERJ6GEYJ103V ERJ6GEYJ104V ERJ6ENF1502V ERJ6GEYJ272V ERJ6GEYJ562V ERJ6GEYJ103V ERJ6ENF2202V ERX2SZJR10P ERJ6GEY0R00V ERJ6GEYJ562V ERDS1TJ330T ERJ6ENF1802V ERD25FJ100P ERJ6GEYJ102V ERJ6GEYJ152V ERJ6GEYJ102V ERDS2TJ392 ERA3YED561V ERA3YED752V ERA3YED302V ERJ6GEY0R00V ERDS1TJ151T ERDS2TJ153 ERDS2TJ562T ERJ6ENF3300V ERF7ZKR82 ERDS2TJ562T Part Name & Description CARBON 2/2W 8.2M CARBON 1/2W 10 MGF CHIP 1/10W 5.6K MGF CHIP 1/10W 2.7K MGF CHIP 1/10W 10K MGF CHIP 1/10W 10K MGF CHIP 1/16W 2.2K MGF CHIP 1/10W 15K MGF CHIP 1/10W 100K MGF CHIP 1/10W 10K MGF CHIP 1/10W 100K MGF CHIP 1/10W 15K MGF CHIP 1/10W 2.7K MGF CHIP 1/10W 5.6K MGF CHIP 1/10W 10K MGF CHIP 1/10W 22K METAL FILM 2W 0.1 MGF CHIP 1/10W 0 MGF CHIP 1/10W 5.6K CARBON 1/2W 33 MGF CHIP 1/10W 18K CARBON 1/4W 10 MGF CHIP 1/10W 1K MGF CHIP 1/10W 1.5K MGF CHIP 1/10W 1K CARBON 1/4W 3.9K MGF CHIP 1/16W 560 MGF CHIP 1/16W 7.5K MGF CHIP 1/16W 3K MGF CHIP 1/10W 0 CARBON 1/2W 150 CARBON 1/4W 15K CARBON 1/4W 5.6K MGF CHIP 1/10W 330 W FLMPRF 7W 0.82 CARBON 1/4W 5.6K Remarks
COILS
Ref. No. L9801 L9804 L9805 L9806 L9807 L9809 Part No. J0JHC0000045 J0JHC0000045 J0JHC0000045 J0JHC0000031 J0JHC0000031 J0JHC0000031 EMI EMI EMI EMI EMI EMI Part Name & Description FILTER FILTER FILTER FILTER FILTER FILTER CHIP CHIP CHIP CHIP CHIP CHIP Remarks
PIN HEADERS
Ref. No. CN9801 CN9802 CN9803 CN9804 Part No. K1NA09E00078 K1KA12AA0105 K1FA119E0002 K1KA30AA0009 Part Name & Description SD UNIT CONNECTOR 12P HDMI JACK SOCKET CONNECTOR 30P Remarks
MISCELLANEOUS
Ref. No. 403 452 710 711 712 713 714 Part No. XTV3+8FFJK XTV3+8FFJ LSMP0559-1 LSMP0558 LSMC0161 K1PY30Y00005 LSJA0629 Part Name & Description TAPPING SCREW,STEEL TAPPING SCREW,STEEL SD SHIELD CASE SD SUPPORT ANGLE SD EARTH SPRING HDMI INTERNAL HARNESS SD-MAIN HARNESS Remarks
TRANSISTORS
Ref. No. Q801 Q803 Q804 Q805 Q806 Q1001 Part No. 2SD1819AHL 2SD1819AHL 2SD1819AHL 2SD1819AHL 2SD1819AHL B1AAGD000016 Part Name & Description TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR SI SI SI SI SI SI NPN NPN NPN NPN NPN NPN CHIP CHIP CHIP CHIP CHIP Remarks
CAPACITORS
Ref. No. C801 C802 C804 C805 C806 C807 C815 C851 C1001 C1002 C1003 Part No. F1BAF102A087 F0CAF105A021 ECA1CHG102B ECA1EHG102B F0CAF105A021 F1BAF102A087 ECA1CM100B F0CAF474A021 F0CAF104A021 ECEC2DP561BB F1BAF102A087 Part Name & Description CERAMIC 250V 1000UF POLYESTER 3.5V 1UF ELECTROLYTIC 16V 1000UF ELECTROLYTIC 25V 1000UF POLYESTER 3.5V 1UF CERAMIC 250V 1000UF ELECTROLYTIC 16V 10UF POLYESTER 3.5V 0.47UF POLYESTER 125V 0.1UF ELECTROLYTIC 200V 560UF CERAMIC 250V 1000UF Remarks
DIODES
Ref. No. D801 D802 D807 Part No. ERZV10V361CS B0EDKT000009 B0HAJL000001 Part Name & Description SURGE ABSORBER 360V DIODE SI CHIP DIODE SI Remarks
97
Ref. No. C1004 C1005 C1008 C1009 C1010 C1011 C1015 C1016 C1017 C1018 C1019 C1021 C1022 C1023 C1025 C1026 C1027 C1028 C1029 C1030 C1031
Part No. ECJ1VB1H104K ECJ1VC1H101J ECJ2VB1H222K F1B3D222A010 F2A1V1010029 ECJ2VB1H102K F2A1V331A800 ECA1HHG470B F1H1A105A025 F2A1C3920011 F2A1C3920011 F2A1C3920011 ECEA1HKAR47 ECJ1VB1H104K F2A1V331A800 ECJ1VB1H104K ECJ1VB1H104K ECJ1VB1H104K ECJ1VB1H104K ECJ1VB1H104K ECJ1VB1H104K
Part Name & Description C CHIP 50V 0.1UF C CHIP 50V 100PF C CHIP 50V 0.0022UF CERAMIC 25V 2200PF ELECTROLYTIC 35V 100UF C CHIP 50V 1000PF ELECTROLYTIC 35V 330UF ELECTROLYTIC 50V 47UF C CHIP 10V 1UF ELECTROLYTIC 16V 3900UF ELECTROLYTIC 16V 3900UF ELECTROLYTIC 16V 3900UF ELECTROLYTIC 50V 0.47UF C CHIP 50V 0.1UF ELECTROLYTIC 35V 330UF C CHIP 50V 0.1UF C CHIP 50V 0.1UF C CHIP 50V 0.1UF C CHIP 50V 0.1UF C CHIP 50V 0.1UF C CHIP 50V 0.1UF
Remarks
TRANSISTORS
Ref. No. Q2751 or Q2751 or Q2751 Q2752 or Q2752 or Q2752 Q2753 or Q2753 or Q2753 Q2754 or Q2754 or Q2754 Q2755 or Q2755 or Q2755 Q4101 Q4102 or Q4102 or Q4102 Q4103 or Q4103 or Q4103 Part No. 2SD1819AHL B1ABCF000020 B1ABCF000112 2SD1819AHL B1ABCF000020 B1ABCF000112 2SD1819AHL B1ABCF000020 B1ABCF000112 2SD1819AHL B1ABCF000020 B1ABCF000112 2SD0601A0L B1ABCF000011 B1ABCF000106 2SB0709A0L 2SD0601A0L B1ABCF000011 B1ABCF000106 2SD0601A0L B1ABCF000011 B1ABCF000106 Part Name & Description TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI PNP CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP TRANSISTOR SI NPN CHIP Remarks
COILS
Ref. No. L802 L1001 L1003 L1004 L1007 L1009 L1010 L1011 L1012 L1013 L1014 L1015 Part No. G0B452L00001 G0B123K00004 J0JKA0000015 J0JHB0000021 J0JHC0000031 J0JHC0000031 J0JHC0000031 J0JHC0000031 J0JHC0000031 J0JHC0000031 J0JHC0000031 J0JHC0000031 Part Name & Description COMMON-MODE LINE CHOKE COILS LINE FILTER FERRITE BEAD WITH LEAD EMI FILTER CHIP EMI FILTER CHIP EMI FILTER CHIP EMI FILTER CHIP EMI FILTER CHIP EMI FILTER CHIP EMI FILTER CHIP EMI FILTER CHIP EMI FILTER CHIP Remarks
PIN HEADERS
Ref. No. CN804 CN851 CN1003 Part No. K1KA02A00736 LSJA0644 LSJA0645 Part Name & Description CONNECTOR 2P POWER-RF AMP POWER HARNESS POWER-MAIN HARNESS Remarks
RESISTORS
Ref. No. R2753 R2754 R2755 R2756 R2757 R2758 R2759 R2760 R2761 R2762 R2763 R2764 R2768 R2769 R2770 R2771 R2774 R2776 R2777 R2778 R2779 R2780 R2781 R2782 R2783 Part No. ERJ3GEYJ563V ERJ3GEYJ473V ERJ3GEYJ563V ERJ3GEYJ103V ERJ3GEYJ563V ERJ3GEYJ472V ERJ3GEYJ563V ERJ3GEYJ182V ERJ3GEYJ101V ERJ3GEYJ101V ERJ3GEYJ101V ERJ3GEYJ101V ERA3YKD104V ERA3YED273V ERA3YKD124V ERA3YED273V ERJ3GEYJ274V ERJ3GEYJ682V ERA3YKD124V ERA3YED273V ERJ3GEYJ563V ERJ3GEYJ223V ERJ3GEYJ563V ERJ3GEYJ563V ERJ3GEYJ153V MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF Part Name & Description CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 56K 47K 56K 10K 56K 4.7K 56K 1.8K 100 100 100 100 100K 27K 120K 27K 270K 6.8K 120K 27K 56K 22K 56K 56K 15K Remarks
RELAY
Ref. No. RL801 RL802 Part No. K6B1CGA00055 K6B1CGA00055 Part Name & Description MAGNET RELAYS (FOR PCB) MAGNET RELAYS (FOR PCB) Remarks
TRANSFORMER
Ref. No. T801 T1002 Part No. G4C2AAD00008 ETS39AG4K5NC Part Name & Description POWER SUPPLY TRANSFORMERS TRANSFORMER SWITCHING Remarks
MISCELLANEOUS
Ref. No. 417 434 716 721 724 Part No. XYN3+K10FN XYN3+F10FJ LSSC0978 EYF52BCY LSSC0766 Part Name & Description SCREW W/WASHER,STEEL SCREW W/WASHER,STEEL HEAT SINK FUSE HOLDER HEAT SINK Remarks
98
Ref. No. R2784 R2785 R2786 R2787 R2788 R2789 R2790 R3501 R3502 R3503 R3504 R3505 R3506 R3507 R3508 R3510 R3511 R3512 R3513 R3514 R3515 R3516 R3517 R3518 R3519 R3521 R3522 R4103 R4104 R4106 R4107 R4108 R4109 R4110 R4111 R4112 R4113 R4114 R4115 R4116 R4117 R4120 R4121 R4122 R4123 R4124 R4125 R4126 R4134 R4135 R4136 R4137 R4139 R4140 R4141 R4142 R4143 R4144 R4145 R4146 R4147 R4148 R4149 R4150
Part No. ERJ3GEYJ183V ERJ3GEYJ103V ERJ3GEYJ102V ERJ3GEYJ274V ERJ3GEYJ102V ERJ3GEYJ154V ERJ3GEYJ103V ERJ3GEYJ750V ERJ3GEYJ750V ERJ3GEYJ750V ERJ3GEYJ184V ERJ3GEYJ184V ERJ3GEYJ750V ERJ3GEYJ184V ERJ3GEYJ184V ERJ3EKF75R0V ERJ3EKF75R0V ERJ3EKF75R0V ERJ3GEYJ184V ERJ3GEYJ184V ERJ3EKF75R0V ERJ3EKF75R0V ERJ3EKF75R0V ERJ3GEYJ184V ERJ3GEYJ184V ERJ3GEYJ184V ERJ3GEYJ184V ERJ3GEYJ221V ERJ3GEYJ221V ERJ3GEYJ221V ERJ3GEYJ221V ERJ3GEYJ221V ERJ3GEYJ221V ERJ3GEYJ221V ERJ3GEYJ221V ERJ3GEYJ221V ERJ3GEYJ221V ERJ3GEYJ221V ERJ3GEYJ221V ERJ3GEYJ221V ERJ3GEYJ221V ERJ3GEYJ221V ERJ3GEYJ221V ERJ3GEYJ104V ERJ3GEYJ102V ERJ3GEYJ102V ERJ3GEYJ221V ERJ3GEYJ221V ERJ3GEYJ823V ERJ3GEYJ220V ERJ3GEYJ220V ERJ3GEYJ104V ERJ3GEYJ221V ERJ3GEYJ221V ERJ3GEYJ102V ERJ3GEYJ473V ERJ3GEYJ274V ERJ3GEYJ105V ERJ3GEYJ101V ERJ3GEYJ101V ERJ6GEYJ101V ERJ6GEYJ101V ERJ6GEYJ184V ERJ6GEYJ184V MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF
Part Name & Description CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/10W 1/10W 1/10W 1/10W 18K 10K 1K 270K 1K 150K 10K 75 75 75 180K 180K 75 180K 180K 75 75 75 180K 180K 75 75 75 180K 180K 180K 180K 220 220 220 220 220 220 220 220 220 220 220 220 220 220 220 220 100K 1K 1K 220 220 82K 22 22 100K 220 220 1K 47K 270K 1M 100 100 100 100 180K 180K
Remarks
Ref. No. C2759 C2760 C2761 C2765 C2769 C2774 C2775 C2776 C3505 C4101 C4103 C4104 C4105 C4106 C4107 C4108 C4109 C4110 C4111 C4112 C4113 C4114 C4115 C4116 C4117 C4120 C4121 C4123 C4124 C4138 C4139 C4140 C4141
Part No. F1H1E104A030 F1H1E104A030 ECA1HHG470B ECA1HHG470B ECA1HHG470B ECA1HHG470B ECA1HHG470B ECA1HHG470B F2A1A4710030 ECEA1CKA101 F1H1A105A025 F1H1A105A025 F1H1E104A030 F1H1A105A025 F1H1A105A025 F1H1A105A025 F1H1A105A025 F1H1A105A025 F1H1A105A025 F1H1A105A025 F1H1A105A025 F1H1A105A025 F1H1A105A025 F1H1A105A025 F1H1A105A025 F1H1A105A025 F1H1A105A025 F1H1A105A025 F1H1A105A025 ECEA1CKA220 F1H1A105A025 F1H1A105A025 F1J1A106A024
Part Name & Description C CHIP 25V 0.1UF C CHIP 25V 0.1UF ELECTROLYTIC 50V ELECTROLYTIC 50V ELECTROLYTIC 50V ELECTROLYTIC 50V ELECTROLYTIC 50V ELECTROLYTIC 50V ELECTROLYTIC 10V ELECTROLYTIC 16V C CHIP 10V 1UF C CHIP 10V 1UF C CHIP 25V 0.1UF C CHIP 10V 1UF C CHIP 10V 1UF C CHIP 10V 1UF C CHIP 10V 1UF C CHIP 10V 1UF C CHIP 10V 1UF C CHIP 10V 1UF C CHIP 10V 1UF C CHIP 10V 1UF C CHIP 10V 1UF C CHIP 10V 1UF C CHIP 10V 1UF C CHIP 10V 1UF C CHIP 10V 1UF C CHIP 10V 1UF C CHIP 10V 1UF ELECTROLYTIC 16V C CHIP 10V 1UF C CHIP 10V 1UF C CHIP 10V 10UF
Remarks
22UF
COIL
Ref. No. L4101 Part No. J0JHC0000078 Part Name & Description EMI FILTER CHIP Remarks
PIN HEADERS
Ref. No. CN2751 CN2752 CN2753 CN2754 CN3501 CN3502 Part No. K1KA03AA0193 K1KA03AA0193 K1KA03AA0226 K1KA03AA0225 K1KA35BA0138 K1KA06BA0061 Part Name & Description CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR 3P 3P 3P 3P 35P 6P Remarks
JACKS
Ref. No. JK3501 JK3502 JK3503 JK3504 JK3505 JK3506 JK3507 JK3509 Part No. K1U413A00008 K2HA306A0037 K2HA306A0037 K2HA306A0038 K2HA204A0051 K2HA306A0038 K2HA204A0051 K2HA204A0051 Part Name & Description S-JACK SOCKET JACKS FOR SMALL (EQUIPMENT SIDE ) JACKS FOR SMALL (EQUIPMENT SIDE ) JACKS FOR SMALL (EQUIPMENT SIDE ) JACKS FOR SMALL (EQUIPMENT SIDE ) JACKS FOR SMALL (EQUIPMENT SIDE ) JACKS FOR SMALL (EQUIPMENT SIDE ) JACKS FOR SMALL (EQUIPMENT SIDE ) Remarks
CAPACITORS
Ref. No. C2753 C2754 C2755 C2756 C2757 C2758 Part No. F1H1E104A030 F1H1E104A030 F1H1E104A030 F1H1E104A030 F1H1E104A030 F1H1E104A030 C C C C C C Part Name & Description CHIP CHIP CHIP CHIP CHIP CHIP 25V 25V 25V 25V 25V 25V 0.1UF 0.1UF 0.1UF 0.1UF 0.1UF 0.1UF Remarks
99
Ref. No. R8973 R8974 W8972 W8973 W8974 W8975 W8976 W8977 W8978 W8979 W8980 W8981 W8982
Part No. ERJ3GEY0R00V ERJ3GEY0R00V ERJ6GEY0R00V ERJ6GEY0R00V ERJ6GEY0R00V ERJ6GEY0R00V ERJ6GEY0R00V ERJ6GEY0R00V ERJ6GEY0R00V ERJ6GEY0R00V ERJ3GEY0R00V ERJ6GEY0R00V ERJ6GEY0R00V MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF MGF
Part Name & Description CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP 1/16W 1/16W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/16W 1/10W 1/10W 0 0 0 0 0 0 0 0 0 0 0 0 0
Remarks
CAPACITORS
Ref. No. C8970 C8971 C8972 C8973 C8974 C8975 C8976 C8977 C8978 C8979 C8980 C8981 C8982 C8984 Part No. F2A0J331B003 F1H1C104A065 F1H1H102A219 F2A0J331B003 F1H1C104A065 ECJ1VB1H103K F2A1H560B358 ECJ1VC1H820J ECJ1VC1H820J ECJ1VC1H100C F2A0J331B003 F1H1C104A065 F1H1H102A219 ECJ1VC1H101J Part Name & Description ELECTROLYTIC 6.3V 330UF C CHIP 16V 0.1UF C CHIP 50V 1000PF ELECTROLYTIC 6.3V 330UF C CHIP 16V 0.1UF C CHIP 50V 0.01UF ELECTROLYTIC 50V 56UF C CHIP 50V 82PF C CHIP 50V 82PF C CHIP 50V 10PF ELECTROLYTIC 6.3V 330UF C CHIP 16V 0.1UF C CHIP 50V 1000PF C CHIP 50V 100PF Remarks
COILS
Ref. No. L8970 L8971 L8972 L8973 Part No. J0JHC0000045 J0JHC0000034 J0JHC0000045 J0JHC0000045 EMI EMI EMI EMI Part Name & Description FILTER FILTER FILTER FILTER CHIP CHIP CHIP CHIP Remarks
PINHEADER
Ref. No. CN8970 Part No. K1KA20A00331 Part Name & Description CONNECTOR 20P Remarks
MISCELLANEOUS
Ref. No. TU8970 725 726 Part No. ENGE6601KF LSSC0996 LSSC0997 Part Name & Description TV TUNERS ELECTROMAGNETIC ABSORPTION SHEET ELECTROMAGNETIC ABSORPTION SHEET Remarks
WAVE WAVE
100