Beruflich Dokumente
Kultur Dokumente
CREDITS
Publisher Wilco Publishing www.wilcopub.com Producer Fred Goldman Victor Racz www.feelthere.com Lead Programer Alex Koshterek 3D Artist, models and textures Aeroplane Heaven www.aeroplaneheaven.com 2D Artist Andrey Martyanov Technical Consultant Christophe Modave Manual Mike Ray www.UTEM.com Wilco Publishing Beta Testers Sylvain Coolsaet Matthew Davies Josh Katz Tanguy Perera Andy Porter Jean-Jacques Struyf The use of this product is restricted to the private domain. Usage of this product for any professional or commercial activity is strictly forbidden. The code used in Wilco Publishing products may under no circumstances be used for any other purposes without the permission of Wilco Publishing and its developers. All trademarks and brand names are trademarks or registered trademarks of the respective owners. Wilco and associated logos are registered trademarks. Microsoft and Windows are trademarks or registered trademarks of Microsoft Corporation in the United States and/or other countries. This product is neither produced nor endorsed by another third party. Published and distributed exclusively by Wilco Publishing.
TABLE OF CONTENTS
Welcome ....................................................... Guppy history .................................................. The fabulous 737 cockpit .................................... How to start the Engines ? .................................. How to start the APU ? .................................... Setup for start .............................................. Engine start flow ........................................... After start stuff ............................................ Five easy pieces ............................................... MCP / EADI / EHSI / EFIS / CDU Simplified procedures ........................................ Step 1: Get information .................................. Step 2: Load the CDU ..................................... Step 3: Configure the Flight Controls ................... Step 4: Setup EFIS and MCP .............................. Takeoff V speeds ........................................... How to read the speed tape ? ........................... Takeoff ......................................................... The heading selector ...................................... Climb and descent using the MCP ....................... The LNAV function ......................................... Approach and landing ........................................ Approach .................................................... Slow up ...................................................... Extending the landing gear ............................... Flying ILS approach with autoland ...................... Control wheel steering ....................................... Inertial Reference System (IRS) ............................. Engine fire ...................................................... APU fire ......................................................... Check-lists ......................................................
(c) 2011 Wilco Publishing www.wilcopub.com
4 10 11 12 13 14 15 17 19 26 27 31 38 39 40 41 44 46 47 48 49 52 53 54 55 57 58 59 61 63
Worldwide Navaid Database is kindly provided by Navigraph. Regular updates are available from :
http://www.navigraph.com
The procedures and technical pages included in this manual are being printed with the kind permission of Captain Mike Ray. If you like Mikes work and his personal way of writing, we recommend you to visit his website at
www.utem.com
QUALITY FIRST ! By not making illegal copies and purchasing only original WILCO PUBLISHING products, you will allow us to continue developing and improving the quality of our software. THANK YOU.
For Microsoft Flight Simulator use only. Not for use in real aviation.
1. WELCOME A. Installation
Installation is automatic. Insert the CD - or double-click on the downloaded file - and Autorun will take you to the start-up screen. If Autorun is disabled on your system, open Windows Explorer or My Computer, browse to your CD Rom drive and double click HJJ_FSX_vx.exe (where x is your version). Once setup is running, follow the on-screen prompts and ensure that the installation points directly to the Microsoft Flight Simulator folder (usually C:\Program Files\Microsoft Games\FlightSimulator...). THE FOLLOWING PACKS MUST BE INSTALLED BEFORE THIS ADD-ON INSTALLATION : FSUIPC (free version) to run the Weather Radar. FSUIPC is available from http://www.schiratti.com/dowson.html. + MICROSOFT FLIGHT SIMULATOR X SERVICE PACKS 1 AND 2 ARE REQUIRED (freely available from www.fsinsider.com - Downloads) CHECK OUT WILCO PUBLISHING WEBSITE :
C. Quick Start
1. To Choose the aircraft 1. Start Flight Simulator 2. From the menus, select AIRCRAFT 3. Choose manufacturer : Boeing feelThere/Wilco 4. Select the aircraft and its livery
2. Engines Start Up To start up engines from a 'Cold & Dark Cockpit', please refer to the next pages for complete procedures.
MCP Combo II - Boeing MCP MCP Combo II - Airbus FCU Prop Cockpit Trainer
Realistic propeller type cockpit training device with full control and instrument display system for VFR/IFR flight. The MCP Combo II panels features the most important parts of your aircraft : radio instruments, autopilot, navigation and more with programmable push-buttons and rotary knobs. Built with full metal case and plate.
D. Cockpit views
2D Panel Views The following 2D panels are available using the following key combinations : Shift Shift Shift Shift Shift Shift Shift Shift Shift + + + + + + + + + 1 2 3 4 5 6 7 8 9 : : : : : : : : : Hide main panel Overhead IRS panel FMC Throttles Pedestal EFIS Control Panel Hide/Show Simicon PFD enlarge
GPS 5
large integrated display for all GPS features.
M Panel
Compact unit to control and display essential flight functions.
CDU II
Control Display Unit for Flight Management Computer (FMC) features.
http://www.wilcopub.com
YOU WILL FIND INFORMATION, NEWS, AND FREQUENTLY ASKED QUESTIONS.
Simicons Press SHIFT+ 8 to display the simicons panel. From left to right : Overhead / Throttle control FS default map / IRS + Rear overhead ATC menu / EFIS Control Panel Pedestal / FMC 3D Virtual Cockpit Views Display the different Cockpit views using the normal Flight Simulator keystroke, A under FS X.
V1000
G1000 Primary Flight Display and Multi-Function Display.
JetPit
Large instrument panel for jetliners.
ProPit
Large instrument panel for propellers.
B. Extra (for CD-Rom version only) We have included a full set of files and videos on your CD-Rom. Use your Windows Explorer to locate them into the EXTRA WILCO directory.
To fully enjoy the 3D Virtual Cockpit, tracking movement systems let you control your field of view in flight simulators by simply looking around by few degrees. We recommend Track IR (Natural Point) available from Wilco Publishing http://www.wilcopub.com.
4
E. Doors
To open the external doors : Shift + E : Main door left side front Shift + E + 2 : Rear left door shift + E + 3 : Services doors right side shift + E + 4 : Luggage/Cargo doors
Available from www.wilcopub.com & www.vrinsight.com or your favourite ight simulation store.
5
For Microsoft Flight Simulator use only. Not for use in real aviation.
Since 1993
ured within clouds that generate normal reflections. So only precipitation based turbulence can be displayed, gusty winds and other air turbulence cannot. Colors code : dark magenta intense magenta
H. Weather Radar
The turbulence image is an overlay to the normal weather radar image so if no turbulence is measured, the normal RGB Weather Radar image is drawn. The turbulence detection is limited to a Range of 40NM. A special high sensitivity mode makes it possible to detect WINDSHEAR out of water particles. Windshear is always present at low altitudes just above ground. Additional due to the high sensitivity, other particles than water may produce enough reflection energy to be detected and displayed as windshear. Windshear is only working below 2500ft AGL and in ranges up to 5 NM. This mode is only intended for take off and final approach phase. Windshear areas are marked by red rings. NOTES ABOUT WEATHER RADAR : 1. The Weather Radar technology requires a lot of PC resources and therefore may result in a huge impact on the frame rate. 2. When switching ON the Weather Radar, the radar pulse generators need to warm up, which can take up to 40 seconds. 3. The tilt adjusting is available in Virtual Cockpit mode only (below engine instruments).
Flight Simulator X setup under Windows Vista/Seven & installation under 64bits Operating Systems.
* Go into program files\microsoft games\ * Highlight Flight Simulator X folder and rightclick on it * Select the SECURITY tab and click on your username (not on Administrator 1) * Click on the 'edit' option (it should have a pic of a shield on the button with edit next to it) * You should be prompted by Vista security module, click on 'ALLOW' * Tick the 'Full Control' box and press 'OK' * Installation of the add-on can now start. Make sure to run the installation of the add-on and of Flight Simulator with full Administrator rights by right-clicking on the application file and selecting the "As Administrator" feature. Make sure to accept the DLL Warning after the aircraft selection. Using a 64bits Operating Systems, if the installer can't find your Flight Simulator folder, it is located into a folder called "Programsx86". During the installation process, simply browse the installer to this folder.
The weather radar included with 737 Pilot in Command Evolution is based on the real Collins WXR2100. The most important is to locate hazardous weather areas, and avoid them. This system is able to show the pilot where dense precipitation is located and turbulence is expected. In an aviation based weather radar, only water and wet hail produces reflections. Only the clouds located at the aircraft level can be displayed. Colors code : Green Yellow Red
I. Extra Information
PANEL LIGHT
PERSONALIZED SERVICE QUALIFIED CREW READY TO ASSIST YOU FAIR PRICES SPECIAL OFFERS AND DISCOUNTS LARGE SHOW-ROOM
ORDER online by phone or
Join us !
=> Light precipitations => Moderate precipitations => Severe precipitations The panel light in the Virtual cockpit can be turned ON/OFF just like the one can be found on the pedestal.
The INTENSITY OF TURBULENCE within clouds can also be displayed. The turbulence is calculated out of the velocity changes for the reflections. This turbulence can only be meas6
www.simw.com
7
Phone : + 32 (0)2 331.25.09 - Fax +32 (0)2 331.27.04 E-Mail : info@simw.com - Technical support : support@simw.com Chausse de Ruisbroek 290 1620 Drogenbos Belgium Show-room/shop open from Tuesday to Friday (10am-1pm & 2-5pm)
For Microsoft Flight Simulator use only. Not for use in real aviation.
ity. Flight Simulator can pause 20 Nm before you reach the TOD point. It's handy on long range flights. THRUST VARIES WITH OAT TEMPERATURE (drops on hot days and raises at cold ones) All temperature dependent thrust tables are rogrammed into the FMS so it detects the outside temperature and set the thrust accordingly, just like in the real life. SELECTABLE THRUST RATING Exclusive feature ! The 737 was delivered with various engine ratings in real life and we wanted to simulate them all. It is a checkbox in the setup utility and you can simulate any of these ratings customising to the airline's rating you fly. WIND REQUEST From the LEGS page of the FMS, you can request wind data to the enroute part of the flight plan and the FMS will take this information into consideration allowing an even more precise fuel prediction. SECURITY EQUIPMENT The trigger for the security equipment is the hand microphone located on each pilot's side console. Just click the mic and the security gear will load/unload in the exterior model : engine muffs, pre-flight flags (animated) and wheel chocks.
By adding flaps and pulling back the throttle to idle if you don't have the gear down a horn will sound. You can silence it by using the Gear Warning Cut OFF button.
J. Latest Features
GROUND POWER UNIT To call GPU, the plane should stay with engines OFF, parking brake ON, and click the Ground Power Available light. Then, wait a minute. Ground Power Unit is fully simulated. When you turn your engines OFF and set the parking brake ON by clicking on the Ground Power Available light you can have GPU in a minute. APU BURNS FUEL Exclusive feature ! Just like in the real plane, the APU uses fuel. This is simulated only on feelThere aircraft. Nowhere else! AUTOMATIC NOSE STEERING LIMITER Above 40kts, the nose wheel steering is limited to 6 degrees without effecting the rudder. Very realistic but can be turned OFF in the setup utility. PAUSE BEFORE TOP OF DESCENT (TOD) Another nice and useful feature in the setup util8
NAVDATA OUT OF DATE EFIS MESSAGE This message doesnt prevent you from using the already-installed navigation database. Worldwide Navaid Database updates are available from :
http://www.navigraph.com
For Microsoft Flight Simulator use only. Not for use in real aviation.
10
For Microsoft Flight Simulator use only. Not for use in real aviation.
11
12
For Microsoft Flight Simulator use only. Not for use in real aviation.
13
14
For Microsoft Flight Simulator use only. Not for use in real aviation.
15
16
For Microsoft Flight Simulator use only. Not for use in real aviation.
17
18
For Microsoft Flight Simulator use only. Not for use in real aviation.
19
20
For Microsoft Flight Simulator use only. Not for use in real aviation.
21
22
For Microsoft Flight Simulator use only. Not for use in real aviation.
23
24
For Microsoft Flight Simulator use only. Not for use in real aviation.
25
26
For Microsoft Flight Simulator use only. Not for use in real aviation.
27
28
For Microsoft Flight Simulator use only. Not for use in real aviation.
29
30
For Microsoft Flight Simulator use only. Not for use in real aviation.
31
32
For Microsoft Flight Simulator use only. Not for use in real aviation.
33
34
For Microsoft Flight Simulator use only. Not for use in real aviation.
35
36
For Microsoft Flight Simulator use only. Not for use in real aviation.
37
38
For Microsoft Flight Simulator use only. Not for use in real aviation.
39
40
For Microsoft Flight Simulator use only. Not for use in real aviation.
41
42
For Microsoft Flight Simulator use only. Not for use in real aviation.
43
44
For Microsoft Flight Simulator use only. Not for use in real aviation.
45
46
For Microsoft Flight Simulator use only. Not for use in real aviation.
47
48
For Microsoft Flight Simulator use only. Not for use in real aviation.
49
50
For Microsoft Flight Simulator use only. Not for use in real aviation.
51
52
For Microsoft Flight Simulator use only. Not for use in real aviation.
53
54
For Microsoft Flight Simulator use only. Not for use in real aviation.
55
56
For Microsoft Flight Simulator use only. Not for use in real aviation.
57
For Microsoft Flight Simulator use only. Not for use in real aviation.
59
60
For Microsoft Flight Simulator use only. Not for use in real aviation.
61
62
For Microsoft Flight Simulator use only. Not for use in real aviation.
63
64
For Microsoft Flight Simulator use only. Not for use in real aviation.
65
66
For Microsoft Flight Simulator use only. Not for use in real aviation.
67
Airbus A318-A319-A320-A321, Corporate Jetliner, A330, A340. Highly advanced Weather Radar. Head-Up Display to y low-visibility approaches. Fully updated FMS Database. Numerous Navigation and Systems improvements.
Airbus Series Evolution Vol.1 & Vol.2 Full and Upgrade versions available for FSX/2004.
A380 v2
E-Jets Series
Boeing 777
Tilt Rotor
Citation X