In ancient times (circa 2000), in Ericsson BSS, there were three CDU types: CDU-A, CDU-C and CDU-C+

and there were RBS 200 and RBS 2000 family. After, there were RBS2206 with CDU-G, CDU-F and WCDMA RBS3202 or RBS3206. Difference RBS2202 and RBS2206. RBS2202 - is a small capacity indoor RBS with maximum configuration 2+2+2. In case of adittional cabinet in can be extended up to 4+4+4. There was also RBS2202 with CDU-D which can allow up to 12TRXs per sector (12/12/12 configuration). 2206 is a large capacity RBS with maximum 4+4+4 configuration in standard cabinet. 2202 is quite old version of RBS2000 series. 2206- is newer one. The difference of all CDU types is maximum output power per TRU. The difference between TRU and dTRU, is that dTRU -is duplex TRU. Actually it is 2xTRX in one TRU. CDU - Combining and Distribution Unit The CDU is the interface between the transceivers and the antenna system. All signals are filtered before transmission and after reception by means of bandpass filters. The CDU allows several dTRUs to share antennas. There are a maximum of three CDUs in one RBS 2106. The CDU combines transmitted signals from several transceivers, and distributes the received signal to several transceivers. The CDU is hardware-prepared to support EDGE. Two different CDU types are used in the RBS 2106 to support all configurations: CDU-F is a filter combiner intended for high capacity solutions. (It supports P-GSM band) CDU-G can be configured either for high capacity or for high coverage. It is a combiner that can be used for synthesizer hopping. Number of units: 1 3 (It supports E-GSM band also). CDU-C+ for 2202/2102 - 2 TRUs CDU-G for 2206/2106 - 2 dTRUs (which is 4 TRUs) CDU-J for 2207 - 1 dTRU (2 TRUS) RBS2206 is an indoor macro RBS belonging to the RBS2000 family. Capacity: 6 dTRUs/12TRUs with CDU (G/F) RBS2216 is an indoor compact macro RBS belonging to the RBS2000 family. The size is smaller than that of RBS2206 Capacity: 6DRUs/12TRU built in TRU and CDU into DRU