CTE, linear 250C Average; 68-572F / 20-300C 13.2 in/in-F AA; Typical; Average over 68-212F / 20 - 100C range. Aluminium 5005-O; UNS A95005; AA5005-O; ISO AlMg1 0.33 Modulus of Elasticity 68.9 Gpa 10000 ksi INFORMATION TO BE USED AS A GUIDE ONLY. Copyright 2011 HM Wire International, Inc. AA; Typical at 77F AA; Typical range based on typical composition for wrought products 1390 BTU-in/hr-ft-F 0.215 BTU /lb-F Thermal Conductivity <= 97.0 % <= 0.10 % 23.8 m/m-C 25.6 m/m-C 0.900 J/g-C 14.2 in/in-F Specific Heat Capacity Comments 0.00000332 ohm-cm 0.00000332 ohm-cm AA; Typical at 68F / 20C Aluminum 5005-O Categories: Data points with the AA note have been provided by the Aluminum Association, Inc. and are NOT FOR DESIGN. 5000 Series Aluminum Alloy; Metal; Nonferrous Metal; Aluminum Alloy; Electrical Properties Metric English Comments Material Notes: Same Nominal composition but higher Si and Fe impurity limits than AL-5657 Composition Notes: KeyWords Mechanical Properties Metric English Physical Properties Density English Metric 25% Elongation at Break AA; Typical; Average of tension and compression. Compression Modulus is about 2% greater than tensile modulus Machinability 10% 10% 0 - 100 Scale of Aluminum Alloys Thermal Properties Shear Strength Hardness, Brinell Ultimate Tensile Strength Tensile Yield Strength Poissons Ratio Shear Modulus Electrical Resistivity 11000 psi 75.8 MPa 0.33 25.9 Gpa 3760 ksi 28 124 MPa 41.4 MPa 25% 28 2.70 g/cc 0.0975 lb. / in 18000 psi 6000 psi <= 0.20 % Metric English English 200 W/m-K 654C 1/4 inch thickness or greater. 1170 - 1210F 632 - 654C Melting Point AA; Typical AA; Typical Processing Properties Metric Comments Solidus 632C 1170F Liquidus 1210F Comments 343C 650F Holding at temperature not required Annealing Temperature Material Components Properties Metric & English As Remainder AA; Typical; AA; Typical; Thickness at 1.59mm / 0.0625 in AA; Typical Zinc, Zn Silicon, Si <= 0.25 % Comments AA; Typical Comments AA; Typical; 500 g load; 10 mm ball AA; Typical; Aluminum, Al Chromium, Cr Copper, Cu Iron, Fe Manganese, Mn Other, each Magnesium, Mg <= 0.70 % <= 0.020 % <= 0.050 % <= 0.15 % <= 0.30 % Other, total 0.50 - 1.10 %