Beruflich Dokumente
Kultur Dokumente
East of North.
The resultant speed an direction of the ship are:
a) 20.3 ; 6 30' knots N to E
b) 15.82 ; 8 35' knots N to E
c) 20.06 ; 6 35' knots N to E
d) 20.06 ; 83 24' knots N to E
2. A wheel and axle is carried in horizontal bearings (see sketch). When the load is allowed to
fall from rest, it falls 3 m in 8 seconds. If the diameter of the axle is 50 mm, The linear
acceleration of the load (in m/s
2
) and the angular acceleration of the wheel (in rad/s
2
)are:
a)
2 2
0.09375 ; 3.75 m s rad s
b)
2 2
0.1875 ; 7.5 m s rad s
c)
2 2
0.0468 ; 1.875 m s rad s
d)
2 2
0.1405 ; 5.625 m s rad s
3. A 3 kg hammer head moving at a velocity of 7 m/s strikes the head of a wedge and is brought to
rest in 1/100 s. The average force of the blow is:
a) 21kN b) 2.1kN c) 210 N d) 20.6 kN
4. The stiffness of a spring is 88 N/mm of axial compression. The work to increase the
compression from 50 mm to 80 mm is:
a) 132 J b) 211.2 J c) 171.6 J d) 17.5 J
Bahi r Dar Uni versi ty
Ethiopian Maritime Training Institute
Group 1 Page 5 of 7
5. A tie bar is made of mild steel of tensile strength 462 MN/m
2
is to carry a tensile load of 11.12
kN. The minimum diameter of the bar allowing a factor of safety of 12, is:
a) 17 mm b) 230 mm c) 188 mm d) 19.17 mm
SECTION - D
Thermodynamics (4 x 5 = 20 points)
1. The temperature inside a refrigerated cold chamber is 3 F
when the outside temperature is
60 F
. The temperature difference between inside and outside in degrees Celsius is:
a) 33.3 C
b) 35 C
c) 63 C
d) 36.3 C
2. A casting of mass 5 kg is pulled a distance of 10 m along a horizontal floor, the coefficient of
friction between the surfaces of the casting and floor being 0.4. The heat generated is:
a) 19.62 J b) 200J c) 196.2 J d) 20J
3. 2.5 kg of brass of specific heat 0.39
kJ
kgK
at a temperature of 176 C
is dropped into
1.2 liters of water at 14 C
. The
final volume is:
a)
3
0.5m b)
3
3.75m c)
3
1.08m d)
3
3.75m
SECTION - E
Electrical Engineering (4 x 5 = 20 points)
1. The total current in the following circuit is:
a) 1.14 A b) 6.23 A c) 0.96 A d) 6.0 A
2. The reading on the Voltmeter in the following circuit is:
a) 180V b) 30V c) 60V d) 96V
3. A battery consists of 4 cells in series, each of e.m.f 1.5 V and internal resistance 0.6 . If the
battery is connected to two resistors of 2 and 0.6 which are connected in series. The
circuit current is:
a) 1.2 A b) 13 A c) 2.3 A d) 2.5 A
Bahi r Dar Uni versi ty
Ethiopian Maritime Training Institute
Group 1 Page 7 of 7
4. A 220 V diesel-driven generator is required to supply the following on full load: a) Lighting
one hundred 100 W and two hundred 60 W lamps, b) a heating load of 25 kW, c)
Miscellaneous small loads taking a total current of 30 A. If the generators efficiency is 85%,
the required power output of the diesel engine is:
a) 53.6 kW b) 45 kW c) 53 kW d) 63.1kW
5. An iron-cored coil of 2000 turns produced a magnetic flux of 30 mWb when a current of 10 A
is flowing from the D.C. supply. If the time of opening the supply switch is 0.12 seconds and
the residual flux of the iron is 2 mWb, the average value of the induced e.m.f. is:
a) 500V b) 466.6V c) 46.66V d) 50V