WM-18 Variable Speed Mill New longer table Innitely variable from 50-2250 rpm Dovetail column slide for positive head location during elevation and descent Tapered gibs to all slideways Digital depth gauge to quill. Met./Imp./Zero Back gear ensures maximum torque in low speed range Locks to head, column and slideways Precision spindle supported on taper roller bearings Head tilting + 90 Rack and pinion drilling action Reversible motor Interlock chuck guard Individual accuracy test report with each machine Standard equipment includes: 13mm drill chuck and arbor Drawbar 3 8 Whitworth Item No. 3261YZ Imperial Item No. 3260YZ Metric Guard has been removed for clarity Digital depth gauge Digital rev counter Spring loaded plunger re-aligns head to vertical Back gear Note: The general dimensions on these pages may be subject to minor variations and should be used for guidance only We can supply and t DRO. Swarf tray for bench mounting Stand with tray Stand price includes delivery with machine. If stand is ordered separately please add 40 carriage ITEM NO. 3260YZ/3261YZ WM18 Variable speed mill SPECIFICATION Maximum drilling capacity 16mm Maximum end milling capacity 20mm Table size 840 x 180mm Tee slot dimensions Slot width 14mm Tee width 25mm Tee height 12mm No. of tee slots 3 Cross traverse 220mm Longitudinal traverse 565mm Vertical traverse 370mm Distance spindle to table 470mm Throat 180mm Spindle taper 3MT Spindle stroke 75mm Number of speeds Variable Speed range rpm 50-2250 Head tilt left and right 90-0-90 Motor 1100w Power supply 240v Dimensions W x D x H 1118 x 711 x 1042mm Weight 220kg Measurements taken to end of handle grips and with head at maximum elevation 14mm 25mm 12mm Fine Feed ITEM NO. 3262 DIMENSIONS STAND Width 390mm Depth 390mm Height 720mm ITEM NO. 3263 DIMENSIONS TRAY Width 610mm Depth 620mm Item No. 4218 Independent coolant system Fully combined unit consisting of: Single phase 94w pump Flexible feed pipe Coolant pipe mounted on magnetic base Feed rate 12l/min. Tank capacity 16l. Dimensions: 285 x 265 x 225mm Following workshop trials, David Fenner said, I rate this as a very competent machine. I was pleasantly surprised at the lack of mechanical spline noise ....also the near absence of gear noise Reviewed by Model Engineer Workshop issue no. 153.
Turning and Boring
A specialized treatise for machinists, students in the industrial and engineering schools, and apprentices, on turning and boring methods, etc.