Units Activities Introduction Motivation Streaming Video 3 Step Method PPT Presentation Assessment Hands-On Activity
2
Instructor Guide
Table of Contents Introduction 3 Lesson Design 3 Importance 3 Prerequisites 3 Learning Objective 3 Motivational Activity 4 Flash Video 4 Group Discussion 4 Thirteen Step Model 5 Lesson 1 5 Lesson 2 10 Lesson 3 16 Rubric 22
Practice 23 PowerPoint Presentation 23 Assessments 24 Written Assessment 24 Hands on Assessment 26
3
Instructor Guide
Introduction Lesson Design This lesson is designed to teach learners how to shampoo hair. Importance Students attending beauty school are required to master hair shampooing skill in order to successfully pass state cosmetology certification exam. Prerequisites Students are expected to have completed health, safety, hair manipulation theory before utilizing this training module. Lesson Objectives By the end of this lesson the learner will be able to demonstration critical strategies used in hair shampooing. The PowerPoint Presentation will prepare him/her for the final hands on activity.
Material Required Computer Projector Mannequin Shampoo Sink Brush Towel Cape
4
Instructor Guide
Motivational Activity
Flash Video Instructor will display flash video on shampooing hair. This video will showcase a well executed hair shampooing and highlight strategies that instructor will watch for during student assessment. http://komodo.utsystem.edu/med/lbanuelos/EDTC6323/capstone/video.html
Narration: The following video is an example of proper shampoo service. Shampooing hair requires 13 steps. Notice that every step is labeled in the video. I will answer any question at the end of the streaming video.
Group Discussion Instructor will answer questions about video and briefly describe each of the three primary activities (workstation preparation, pre-wash, and wash). Instructor will direct student to examine the list of strategies to learn located on page 5 of their student guide.
Time Frame This activity will require 30 minutes.
5
Instructor Guide
13 Step Model Task Analysis Outline I. Prepare workstation a. Disinfect Workstation. b. Assemble Shampoo Products and Supplies. c. Position Chair. II. Perform Pre-wash Activities a. Disinfect Hands. b. Remove Jewelry. c. Position Towel and Cape. d. Examine Scalp for Parasites and Abrasions. e. Brush out Tangles. III. Wash Hair a. Disinfect Sink. b. Test Water Temperature. c. Rinse Clients Hair and Apply Shampoo. d. Perform Scalp Manipulations. e. Rinse Hair.
Narration: This is the 13 step model used to shampoo hair. This activity is divided into three major sections. The three sections are workstation preparation, pre-wash activities, and washing hair. Each section has several steps that must be accomplished before you can move on to the next section. The following pictures illustrate the process step by step. Lets review each step.
6
Instructor Guide
Thirteen Step Model Lesson 1 Prepare Workstation Step 1-3
7
Instructor Guide
Step 1
Instructions: Using your disinfectant solutions clean the workstation area thoroughly.
8
Instructor Guide
Step 2
Instructions: Organize your workstation by assembling shampoos products and supplies.
9
Instructor Guide
Step 3
Instructions: Adjust chair to proper position and height as to allow free 360 degree movement.
10
Instructor Guide
Thirteen Step Model Lesson 2 Pre-Wash Steps 4-8 11
Instructor Guide
Step 4
Instructions: Using disinfectant solution, wash hands thoroughly.
12
Instructor Guide
Step 5
Instructions: Ask customer to remove all jewelry and place it in a safe place.
13
Instructor Guide
Step 6 Instructions: Position the salon cape and towel around the customers neck.
14
Instructor Guide
Step 7 Instructions: Examine Scalp for parasites and abrasions.
15
Instructor Guide
Step 8 Instructions: Brush out tangles in clients hair.
16
Instructor Guide
Thirteen Step Model Lesson 3 The Wash Steps 9-13 17
Instructor Guide
Step 9 Instructions: Using provided cleaning solution, disinfect the sink.
18
Instructor Guide
Step 10 Instructions: Test the water temperature on the back of your wrist.
19
Instructor Guide
Step 11 Instructions: Rinse clients hair thoroughly and apply shampoo.
20
Instructor Guide
Step 12 Instructions: Perform Scalp Manipulations
21
Instructor Guide
Step 13 Instructions: Rinse the clients hair.
22
Instructor Guide
Rubric Not Performed Successfully Performed No Points Full Points Disinfected Workstation 0 7.5 Assembled Products and Supplies 0 7.5 Adjusted Chair Position 0 7.5 Disinfected Hands 0 7.5 Removed Jewelry 0 7.5 Positioned Towel and Cape 0 7.5 Examined Scalp for Parasites and Abrasions 0 10 Brushed out Tangles 0 7.5 Disinfected the Sink 0 7.5 Tested Water Temperature 0 7.5 Rinse Hair and Apply Shampoo 0 7.5 Performed Scalp Manipulations 0 7.5 Rinse Client Hair 0 7.5
23
Instructor Guide
Practice PowerPoint Presentation Learners will watch an instructor led PowerPoint presentation. During the presentation student will perform each of the 13 steps in sequence using a mannequin and student guide. Each learner will be given access to all required tool, supplies, and equipment. Students will be graded using the previous rubric. PowerPoint - Narration Students, today we will demonstrate the 13 steps in shampooing hair on a mannequin. The mannequin will represent the client in this activity. Prepare Workstation The first part of shampooing hair is called workstation preparation. There are three step required in this section. First, disinfect the workstation. Second, assemble the products and supplies. Third, adjust the chair position. Pre-wash - Narration The next phase is the pre-wash. There are five steps in this section. First, disinfect your hands. Second, ask the client to remove jewelry. Third, position the towel and cape around the clients neck. Fourth, examine the clients scalp for parasites and abrasions. Finally, brush out all tangles in hair. The Wash - Narration The final phase is called the wash. Three are five steps in this part. First, disinfect the sink. Second, test the water temperature and rinse the hair. Third, apply shampoo to the hair. Fourth, apply shampoo. Finally, rinse the hair. 24
Instructor Guide
Assessments Assessment #1 Written Learners will list all thirteen steps in correct sequence. Learners will be graded according to previous rubric. Learners will not be allowed to use any use assistance from any source. Learners will complete activity is 10 minutes. Step 1 ______________________________ Step 2 ______________________________ Step 3 ______________________________ Step 4 ______________________________ Step 5 ______________________________ Step 6 ______________________________ Step 7 ______________________________ Step 8 ______________________________ Step 9 ______________________________ Step 10 ______________________________ Step 11 ______________________________ Step 12 ______________________________ Step 13 ______________________________
25
Instructor Guide
Answer Key: Step 1 Disinfect Workstation Step 2 Assemble Products and Supplies Step 3 Adjust Chair Position Step 4 Disinfect Hands Step 5 Remove Jewelry Step 6 Position Towel and Cape Step 7 Examine Scalp for Parasites and Abrasions Step 8 Brush out Tangles Step 9 Disinfect the Sink Step 10 Test Water Temperature Step 11 Apply Shampoo Step 12 Perform Scalp Manipulations Step 13 Rinse Hair
26
Instructor Guide
Assessment 2 Hands On Activity Individual students will be provided access to shampoo supplies, tools, sink, cape and towel in order to shampoo the hair of a beauty college customer. Students will perform all 13 steps on customer in proper order while under the supervision of instructor. Their goal will be to complete the project in less than 45 minutes. Instructor will grade student based on previous rubric.