Beruflich Dokumente
Kultur Dokumente
Page 1 of 38
R462 OAM
Content
WORK DONE BY CURRENT OWNER (ALL RECEIPTED) .................................................................................................................. 3
WORK DONE BY LAST OWNER (ALL RECEIPTED) ......................................................................................................................... 4
WORK DONE BY PREVIOUS OWNERS (ALL RECEIPTED) ............................................................................................................... 6
CURRENT OWNERS SERVICE & MOT HISTORY ............................................................................................................................ 8
PREVIOUS OWNERS SERVICE & MOT HISTORY ........................................................................................................................... 9
GARAGES .................................................................................................................................................................................. 11
MOTOR SHOW INFO SHEET - MERCEDES C43 AMG (1998) ........................................................................................................ 13
FRONT PASSENGER DOOR CONTROL UNIT REPLACEMENT (3/10/12) ....................................................................................... 14
DE-CAT (1/6/12) ....................................................................................................................................................................... 14
DRIVERS SIDE WING MIRROR MOTOR REPLACEMENT (19/4/12) .............................................................................................. 14
ALARM SIREN REPLACEMENT (16/4/12) ................................................................................................................................... 15
FRONT & REAR BRAKE DISC/PAD REPLACEMENT (16/4/12) ..................................................................................................... 16
KEY FOB CASE REPLACEMENT (18/10/11) ................................................................................................................................. 18
RUST TREATMENT (12/9/11) .................................................................................................................................................... 19
WORK COMPLETED............................................................................................................................................................................ 19
DURING & AFTER PHOTOS .................................................................................................................................................................. 19
GIVEN TO GARAGE: ON DROP-OFF ...................................................................................................................................................... 24
Question ................................................................................................................................................................................... 24
Quote........................................................................................................................................................................................ 24
GIVEN TO GARAGE: PRE-QUOTE .......................................................................................................................................................... 25
WIPER LUBRICATION (4/8/11) .................................................................................................................................................. 30
BLUETOOTH HANDSFREE KIT REMOVAL (JULY 2011) ................................................................................................................ 30
A PILLAR TRIM REMOVAL (JULY 2011) ...................................................................................................................................... 31
CLIMATE CONTROL PANEL ILLUMINATION (14/7/11) ............................................................................................................... 31
PAINT CODE (6/7/11) ............................................................................................................................................................... 31
RADAR DETECTOR/JAMMER .................................................................................................................................................... 31
WINDOWS/SUNROOF: RE-SYNCING/RE-NORMALISING ........................................................................................................... 32
NOT DONE: BILSTEIN B8 SUSPENSION & H&R SPRINGS ............................................................................................................ 32
NOT DONE: AVANTGARDE GRILL .............................................................................................................................................. 32
NOT DONE: SLK EVOLUTION PEDALS ........................................................................................................................................ 32
FITTED FACTORY OPTIONS........................................................................................................................................................ 33
ANNEX A: C43 FACTORY OPTIONS ............................................................................................................................................ 35
ANNEX B: SPARE PART CODES .................................................................................................................................................. 37
ANNEX C: CLIMATE CONTROL PANEL DIAGNOSTICS ................................................................................................................. 38
Page 2 of 38
R462 OAM
Mileage
Cost
252.00
Description
Labour for fitting compressor/drier and re gas of system
10/11/14
18/10/14
14/10/14
94,055
304.80
68.40
222.92
04/10/14
01/07/14
01/01/14
31/10/13
01/10/13
15/09/13
13/07/13
03/07/13
02/06/13
29/06/13
22/06/13
93,784
93,840
90,929
89,754
89,542
89,421
89,249
45
123.75
123.75
35
45
200
138.78
202.60
123.75
169.45
50
Page 3 of 38
Garage
Parkway Automobile
Engineering
Advanced Auto Cooling Bristol
John Dandy Motors Glos
Parkway Automobile
Engineering - Bristol
ABC Cheltenham
Kwik Fit
MB&B Cheltenham
Kwik Fit Tewkesbury Road
MB Cheltenham
R462 OAM
Mileage
87,958
87,273
86,500
Cost
42.60
286.99
220.80
54
206
01/06/12
04/05/12
350
36
27/04/12
27/04/12
19/04/12
17/04/12
16/04/12
85,476
31.68
11.94
24
54
163.80
07/04/12
07/04/12
31/03/12
08/03/12
22/01/12
26/12/11
0
149.94
0
695.24
0
0
01/12/11
85,121
155.94
30/10/11
16/10/11
08/10/11
12/09/11
11.59
0
0
1,440
Description
Replaced front passenger side door, outer grab handle (damaged during fitting of door control unit)
Replaced drivers side front and rear tyres
Replaced front passenger door control unit (wing mirror and window had stopped working)
MoT
Replaced rear exhaust clamp and 'pilot bush' gearbox seal again (think it was same seal replaced by merc on
11/07/11 but not checked part numbers yet - have photo of the leak though). Rusty clamp and leak both spotted
during de-cat. Also did gearbox oil, filter and gasket change.
Exhaust de-cat and resonator delete (retains 2 of original 4 cats for MoT, and OEM rear silencer). Stainless.
Fitted supplied seal around passenger side wheel arch liner.
Fitted supplied section of wheel arch liner, between passenger side arch and front bumper.
Bought replacement for cracked section of wheel arch liner, between passenger side arch and front bumper.
Bought replacement for missing seal around passenger side wheel arch liner.
Replaced motor in drivers side wing mirror with 2nd hand unit (was working but central location lug broken)
4-wheel alignment
Fitted supplied front brake discs and pads
Fitted supplied alarm siren
Replaced front, passenger (nearside) lower ball joint
Replaced 2 sheared retainers in front, passenger side wheel arch liner
Treated/repainted small area of rust near grommet in front passenger side wheel arch
Reconditioned rear, passenger side, brake caliper (piston seals split on old one)
Fitted rear brake discs and pads
Bought front brake discs, pads & wear sensor, rear discs & pads, alarm siren
Replaced rear indicator bulbs (orange film had peeled off one)
Replaced battery
Fitted trickle charger lead
Gearbox oil + filter change
Checked diff oil already full
Replaced both rubber mounts for rear exhaust silencer (one split)
Removed/cleaned sunroof visor (grit from shotblasting was graunching)
Treated interior leather (leather food)
Full body restoration (bare metal/ALL rust) took a month (see photos)
Page 4 of 38
Garage
Kwik Fit, Cheltenham
MB&B, Cheltenham
MB&B, Cheltenham
PCS, Portsmouth
PCS, Portsmouth
MB&B, Cheltenham
Malvern Tyres, Cheltenham
MB&B, Cheltenham
MB&B, Cheltenham
BP Motors, Cheltenham
R462 OAM
Date
02/09/11
Mileage
-
Cost
54
04/08/11
04/08/11
0
8.74
31/07/11
30/07/11
30/07/11
30/07/11
27/07/11
27/07/11
0
0
0
7.81
0
8.61
22/07/11
21/07/11
16/07/11
14/07/11
12/07/11
12/07/11
11/07/11
83,880
83,512
0
778.80
5.29
0
0
0
800.50
10/07/11
07/07/11
06/07/11
05/07/11
05/07/11
Total
25.99
4.15
0
33.24
5,661.65
Description
Got quote on rust treatment
MoT (they used Berkeley Garage)
Checked wiper mechanism already well greased
Replaced (non original) fixing screw for passenger side footwell vent
Replaced missing bonnet catch deflector on slam panel
Modified stereo faceplate to blank out bright white button (horrible at night). Reversible.
Replaced stereo (Becker BE3100 with Sony MEX-BT3900U)
Removed handsfree kit (2 mics, 1 broken), and re-seated wonky A pillar cover
Replaced missing boot lid rubber stop
Repainted rust patches on edge of bonnet slam panel (ground to clean metal first)
Replaced missing clips/covers on bonnet slam panel (bleed hose bracket, 1 fan shroud clip, 2 oblong clip covers)
and washer bottle plastic nut
Replaced broken warning triangle in boot lid
Replaced aircon condenser & fill valve
Replaced blown backlight bulb in climate control panel
Air con sensor reset by dealer again. Said no leak, theyd replace sensor if trips again.
Repainted small rust patch in offside boot lid shut (ground to clean metal first)
Replaced missing clip on boot trim panel
Service:
A Service
Spark plugs
Brake fluid
Air cleaner
Replaced gearbox seal (the one that allows oil to travel up the wiring harness into the footwell/gearbox ECU,
lunching the gearbox). No problem beforehand, but leak spotted during service.
Air con fault diagnosis & recharge (low pressure sensor tripped again by time I picked up)
Got quote on rust treatment in arches
Refitted nearside boot trim panel (not sitting properly)
Re-fastened PSE pump (loosely wedged behind panel). Suspect PSE pump previously replaced.
Repainted rear seat bases (scratched by dog)
Replaced brake pedal rubber (worn through on corner)
Replaced 2 missing passenger side, rear, interior door panel lugs
Replaced both rear door speakers (blown/cracked)
Page 5 of 38
Garage
BP Motors, Cheltenham
Berkeley Garage, Cheltenham
Mercedes, Cheltenham
Mercedes, Cheltenham
Mercedes, Cheltenham
R462 OAM
Mileage
-
Cost
337.80
-
19/11/10
15/09/10
16/02/10
23/09/09
73,972
70,021
535.80
296.10
638.26
29/08/08
27/03/08
65,418
63,965
17/07/07
17/07/07
60,751
60,749
30/06/06
54,583
23/06/06
14/06/05
02/06/05
54,079
42,725
42,700
Description
Refurbished all 4 wheels/polished rims
Reinstalled a Mercedes stereo (not compatible with CD changer unfortunately head unit required fibre optic link)
(Known from speaking to Mark Ebbon)
Replaced internals of both wing mirrors - motors/mechanisms, but not casing
MoT
Replaced boot lid
Service:
'A' & 'B' Service
Brake fluid
Air cleaner
Replaced front drivers (offside) lower balljoint
Replaced front brake pads and skimmed front discs
Replaced offside stop lamp bulb
Replaced bonnet star badge
MoT (using Brookfield Garage, Bristol)
MoT
Service:
'A' & 'B' Service
Brake fluid
Coolant
Fuel filter
Replaced air mass meter
Replaced rear discs & pads
MoT
Service:
Unknown type
Pollen filter
Service:
'A' Service
Spark plugs
Air filter
Pollen filter
MoT
MoT
Service: 'B' Service
Page 6 of 38
Garage
Mercedes, Worcester
Brookfield Garage, Bristol
Mercedes, Cardiff & Newport
Graham Lucas, Bristol
Brookfield Garage, Bristol
R462 OAM
Date
13/05/04
11/02/04
17/11/03
30/10/03
Mileage
34,725
33,071
30,776
30,293
Cost
146.80
547.39
27/08/02
20/12/01
21,047
16,594
800.76
12/04/00
6,222
Description
Service: 'A' Service
MoT
Replaced OSF Window Drop Glass
Service: 'A' Service
Replaced front brake pads & wear sensor
Replaced window regulator
MoT
Service:
'B' Service
Pollen filter
Replaced bonnet badge
Repaired & painted passenger (nearside) front wing & bumper
Service:
'A' service
Brake fluid change
Page 7 of 38
Garage
George Fraser, London
Kensington Autocare, London
George Fraser, London
George Fraser, London
Fosters, Mitcham
Link Vehicle Solutions, London
R462 OAM
Mileage
22/06/13 - Current
89,200 at
purchase
27/06/11 - 22/06/13
83.2K - 89.2k
Regd
Keeper
No.
7
Owner
Philip Fletcher
Mark Probert
18/04/11 27/06/11
09/10/10 18/04/11
05/01/10 09/10/10
79.6K - 83.2K
TBC - 79.6K
Mark Ebbon
The Willows
Oldfield
Ombersley
Droitwich
WR9 0JL
Tel: 07976 351844
James Dennison
64 Orchard Street
Worcester
WR5 3DY
Tel: 07970 309907
Fraser Besant
11 Westover Rise
Bristol
Page 8 of 38
R462 OAM
Date
Mileage
Regd
Keeper
No.
Owner
BS9 3LU
01/11/05 05/01/10
12/05/98 08/06/99
0 - TBC
Unknown
(Demo car?)
Page 9 of 38
R462 OAM
Date
Mileage
Regd
Keeper
No.
Owner
Page 10 of 38
R462 OAM
Garages
Mercedes-Benz of Cheltenham & Gloucester
Cheltenham Road East
Ashville Business Park
Staverton
GL2 9QJ Gloucester
Tel: +44 1452 854700
Did 1st service
BP Motors
The Runnings
Runnings Road
Cheltenham
Gloucestershire
GL51 9NJ
Tel: 01242 245698
Did body restoration
MB&B Mercedes Benz Specialists
9 Collets Drive
Cheltenham
GL51 8JQ
Tel: 01242 530222
Did gearbox oil & filter change, checked diff oil (OK).
Fitted new front brake discs & pads, passenger front lower ball joint, wheel arch liner retaining bolts
C43 80K service quoted as 160
Recommended Malvern Tyres for tracking (they dont do alignment jobs)
Page 11 of 38
R462 OAM
Malvern Tyres
Kingsditch Lane,
Cheltenham,
Gloucestershire,
GL51 9PB
Telephone: 01242 581872 / 587751
OPEN TIMES:
Mon-Fri: 8:30 - 5:30 Sat: 8:00 - 4:00 Sun: closed
Page 12 of 38
R462 OAM
First car assembled entirely by AMG (C36 predecessor left production line as a C280)
267 registered in UK (down from 387 in 2001, according to www.howmanyleft.co.uk)
4.3 Litre V8, 302 BHP, 302 lb-ft
0-60 MPH in 5.8 sec, limited to 155MPH (168MPH without limiter)
AMG-bits: Engine, gearbox, brakes, exhaust, suspension, front seats, wheels, bodykit (rest is standard C-class)
Good Stuff: Reliable engines, stainless exhaust from factory, easy to work on, most parts common to standard C class
(so fairly cheap and readily available 2nd hand)
Bad Stuff: Prone to rust (restored in 2011), propensity for gearbox leaks leading to total failure if not caught. AMG
parts can be tricky to source (front discs took 3 months to arrive).
Interesting Stuff: 16 spark plugs, CANBus Electrics, Orthopedic seats (inflatable lumber/bolsters), asymmetric front
brake discs (vents angled forwards on both sides).
Costs: Cheap to buy (4k for sound/low mileage, 6.5k restored). 25MPG (better than most expect). Cheap classic
insurance.
Driving Experience: Handling entirely average by modern standards, and auto gearbox likes to change up
frustratingly early. Brakes and engine still strong though.
Page 13 of 38
R462 OAM
De-Cat (1/6/12)
Did a lot of research, but decided to go for the de-cat from Olly at PCS - who runs a C43 himself, and had already sold
30 pipes to very happy customers. This removes the rear 2 cats and middle resonator box, but leaves the from 2 cats
and rear silencer as standard. The system is full stainless with lovely welding.
Whilst fitting, he advised a return trip for the following (returned later - all work now done):
Replace exhaust bolts to the front exhaust (requires heat/time)
Replace one of the front claps - Olly snapped the stainless clamp and so fitted a temporary one
Think the rear clamp was also temporary (my original was knacked, he showed it me)
Gearbox weep (circa 200). Has never actually dripped onto the garage floor.
Page 14 of 38
R462 OAM
Page 15 of 38
R462 OAM
Inchcape
(OEM - 20% off)
190.94
190.94
114.75
36.54
36.54
38.37
5.56
613.64
Notes
R462 OAM
Update (18/10/12): Horgantrevor tried the E430 discs - had to add 2 x 1.5 washers between the carrier and
calipers but sounds OK. See http://www.mbclub.co.uk/forums/wheels-tyres/133343-c43-discs-question2.html#post1573267
In terms of aftermarket pads, EBC Redstuff are recommended by Olly and a few others (better than green or yellow).
Some say grabby at low speed, some say ceramic wears discs more, all say much better for brake dust. Not much
cheaper than OEM pads though.
Emails To/from Inchcape to work out brake part numbers/cost:
Me (3/1/12): My car is a 1998 C43, chassis WDB2020332F730902...I need new discs/pads all round - the garage has
told me a judder is due to warping but are unable to tell which disc is the culprit. The C43 front discs cost a fortune
(233 EACH on your site), and I dont think I need AMG levels of braking with the way I use the car. Internet research
indicates that the E430 4matic discs, though not asymmetric like the AMG discs, are identical in size (330 x 32 x 47),
and are way cheaper. I would not ask you to underwrite their performance/safety, but do they appear to be
interchangeable?
Inchcape (andrew.loft@ir.inchcape.co.uk): Unfortunately we have no way of advising if you can use discs & pads
from a different model. However we can offer an additional discount of20% on top of the following prices (which
include VAT):
FrontDiscs A2104211812 & A2104211912 224.64 each
Pads A0034202120 135
Wear sensor A2105401117 5.59
RearDiscs A2104230812 42.98 each
Pads A0044209320 45.14
Me (5/1/12): Thanks very much. I'd go for it with that discount, but have another follow-up query on the part
numbers you quoted - sorry! I subscribe to the EPC, and was also given part numbers by the garage who diagnosed
the warped discs. We all agree on the front/back disc and wear sensor part numbers, but you've quoted different
part numbers for the front/back pads. Could I just double check?
Front Pads - EPC/Garage reckon H WA 2104200120, you quoted A0034202120 (the inchcape website says
this is for E430 pads)
Rear Pads - EPC/Garage reckon A 0034204820, you quoted A0044209320 (the inchcape website says this is
for brake SHOES rather than pads, and for an E-class)
Inchcape: The part numbers you quote for the pads change part number to those we gave which are the latest
version of them. Hopefully of some help.
Page 17 of 38
R462 OAM
However, then noticed that fob had a picture of a van, rather than a car boot, on boot release button. So swapped
innards back to original key. Subsequently bought new fob case, which turned out to be an non-OEM copy. Finally
got new proper key months later.
From: http://forums.mercedesclub.org.uk/showthread.php?t=43399
Q: If I bought a new key fob is it possible i can change all the inners to the new fob?
A: Yes it comes out of the case by putting a thin knife inbetween the case and the nylon strip, and release the catch
as in the picture, and it all slides out.
Page 18 of 38
R462 OAM
Page 19 of 38
R462 OAM
Page 20 of 38
R462 OAM
Page 21 of 38
R462 OAM
Page 22 of 38
R462 OAM
Page 23 of 38
R462 OAM
Quote
Verbal quote (and MoT) from BP motors on 2/9/11 (from Father - David?):
The Runnings
Runnings Road
Cheltenham
Gloucestershire
GL51 9NJ
Tel: 01242 245698
As well as the 13 patches Id picked up (see overleaf), they also picked up:
Rust behind both front arches where they meet bumper
Small patch on outside of roof rail near drivers door
2 dents on drivers side rear quarter panel, near spot of rust Id seen (can prob be tapped out at same time)
Quote for doing the lot was 1190+VAT.
The quote includes:
Remove both side skirts, front bumper, roof moulding strips and windscreen (latter may not be necessary if
top seal comes out without windscreen, but this is unlikely).
Both rear arches/rear door shut areas: Shot blast, treat, prime all rusty areas. Repaint and re-lacquer whole
panel.
Passenger side rear door: Shot blast, treat, prime all rusty areas. Repaint and re-lacquer whole panel.
Both front wings: Shot blast, treat, paint all rusty areas. Re-lacquer whole panel.
Roof: Shot blast, treat, paint all rusty areas. Sort crazed lacquer in front of sunroof. Re-lacquer whole panel.
Drivers side rear quarter panel: Shot blast, treat, paint all rusty areas. Re-lacquer whole rear quarter panel.
Windscreen re-fitting costs not included in quote, but will work with my insurer if it breaks (Admiral confirmed that
my insurance will cover accidental breakage by garage, as long as I use their preferred windscreen company, and pay
75 XS).
Booked in for 12/9/11, when David gets back off holiday (so he can oversee work).
Section overleaf was given to David prior to quote, and kept by him.
Page 24 of 38
R462 OAM
Specific Areas
1. Passenger side rear arch - Leading edge
Page 25 of 38
R462 OAM
3. Passenger side rear door Leading lower edge
Page 26 of 38
R462 OAM
6. Drivers side front arch Trailing edge
Page 27 of 38
R462 OAM
8. Drivers side rear arch Leading edge
Page 28 of 38
R462 OAM
11. Roof Drivers side Just back from
windscreen
Page 29 of 38
R462 OAM
Page 30 of 38
R462 OAM
If this is illumination for the digital climate control unit, the bulb pt. no. is A 002 544 0294.
Radar Detector/Jammer
Or at least thats what Im guessing the unit in the front bumper, LED on the nearside dash top, and switch under the
nearside side are all for. Find out what it is (obviously still powered as it beeps, but not sure if complete).
Closest so far (combined jammer/sensor module):
http://radar-jammers-detectors.net/rmr_8rds.htm
http://www.bestradardetectors.net/Cincinnati-Microwave-Shifter-ZR4-Laser-Jammer.html
Page 31 of 38
R462 OAM
Windows/Sunroof: Re-Syncing/Re-Normalising
Whenever the battery is disconnected, the windows/sunroof reputedly need re-syncing/re-setting/re-normalising.
The owners manual mentions it for the windows, but not the sunroof. However, when you tilt the sunroof up, let go
of the button, then push to tilt it up again and hold it there is a click.
Now, I cant be sure if this did anything. But...
When I picked up car after condenser replacement, they reported that I probably already knew but my sunroof
wont shut properly, and that the switch probably needs replacing.
It seemed to tilt up OK, so I tried the trick, and then untilted, opened and closed it again, and all seemed fine. Dont
know if that has anything to do with normalising, but there are lots of google reports about the sunroof needing to
be normalised (via various different means, and sometimes repeatedly to make it stick).
e.g. http://forums.mercedesclub.org.uk/showthread.php?t=27034
Page 32 of 38
R462 OAM
292, 414, 461, 511, 551, 613, 808, 819, 833, 882, 984, N97, Z98
Page 33 of 38
R462 OAM
From EPC Help:
Production order
Indicates whether a production order exists for the vehicle.
If a passenger car has been equipped according to customer special request, it is assigned a production order.
A distinction is made between the following cases for a production order:
Vehicles from 08/2002
The production orders can be called up from approx. 08/2002 in "Info texts".
The "Info texts" can be displayed with the tree structure and describe the individual changes to the vehicle.
In Setup an automatic display of the "Info texts" can be set after entering the Identification number.
Vehicles up to 08/2002
The information of the production order can only be read in VeDoc.
Some code advice available at:
http://www.ajseven.net/CODE.htm & http://www.bekkoame.ne.jp/~mtor/mbcodedsc.html
For comparison against the factory C43 options list, and another chaps car, see Annex A.
Page 34 of 38
R462 OAM
650
Seating
Illuminated Vanity Mirrors
Ski Bag Option (Saloon)
80
100
95
220
220
360
70
100
310
780
110
120
710
Ventilation
Sunroof
1250
Page 35 of 38
R462 OAM
From advert on: http://www.mbworld.org/forums/c36-amg-c43-amg-w202/264578-c43-c36-vinoption.html
Interior leather: black and blue designo (581)
Paint: 366 azurite blue metallic ( 01.01.1994)
Options:
021 designo - leather ( 05.02.1997)
022 designo - decorative trim ( 05.02.1997)
058 aej. 97/2 ( 09.12.1995)
220 parking aid ( 01.10.1993)
221 left front seat, electrically adjustable ( 01.11.1978)
222 right front seat, electrically adjustable ( 01.11.1978)
240 outside temperature indicator ( 01.03.1982)
249 automatically dipping inside rear view mirror ( 01.06.1990)
260 elimination of model designation on rear lid ( 01.05.1968)
282 ski bag (inboard loading facility) ( 01.07.1989)
314 D-net standard telephone on middle console, right ( 01.06.1995)
345 rains sensor for windshield wipers ( 01.10.1993)
354 antenna on roof centre rear for mobile D-net telephone/antenna on roof centre rear for standard
D-net telephone ( 01.10.1994)
363
412 electric sliding roof with tilting device ( 01.07.1983)
441 steering column, electrically adjustable, W202 manually adjustable ( 01.07.1984)
472 electronic stability program (esp) ( 01.10.1993)/dynamic handling control system
500 outside rear view mirror left and right, folding ( 01.10.1993)
511 Becker radio Mexico cassette full stereo
Becker radio Monza cassette stereo LW/MW/SW/USW
radio MB Exquisit with traffic news decoder (VK), with RDS (Panasonic) ( 01.07.1992) Alpine Package
with GPS
540 roller blind, electric, for rear window ( 01.05.1985)
543 sun visor with vanity mirror, illuminated, left and right ( 01.11.1978)
551 anti-theft/anti-break-in warning system with anti-towing system ( 01.04.1998)
570 folding armrest front w202/210 stowage box front with armrest ( 01.04.1970)/front folding
armrest w202 - housing at front with armrest
581 automatic climate control ( 01.01.1977)
584 electric window lifters (front and rear doors) ( 01.04.1970)/ electric window lifters, fourfold or
sixfold
600 headlamp wiper/washer ( 01.08.1971)
611 courtesy lamps for front and rear doors, with W124 also for central doors/W202 front doors only (
01.11.1978)
612 lamp unit: gas discharge lamp (ael)/xenon headlight ( 01.10.1993)
673 high-capacity battery ( 01.01.1964)
772 amg styling package - front spoiler, side skirts and rear apron ( 02.01.1992)
774 Shell modification for AMG-wheels
808 Change of year of model, last figure shows new model year
810 loudspeaker, sound package/sound package (bose) ( 01.12.1986)
819 CD changer - alpine - in trunk ( 31.07.1992)
873 seat heater for left and right front seats ( 01.02.1984)
875 heated screen wash system ( 01.02.1988)/windshield washer heated (W201)
882 passenger compartment protection/towing-off protection (with anti-theft warning system only) (
01.07.1993)
956 equipment package sport ( 01.11.1991)
Page 36 of 38
R462 OAM
http://www.auto-parts.spb.ru/cat/cats/m.mycat?cat=mb&client=dr2000
http://partscatalog.ru/mercedes/F/car/201/122/452/201.122/452/30/015
But then got hacked off, and bought 1 years access to the official EPC: http://service-parts.mercedes-benz.com/
Then ordered from: http://www.mercedes-benz-parts.co.uk/index.php
Page 37 of 38
R462 OAM
Page 38 of 38