Beruflich Dokumente
Kultur Dokumente
Rev.5.Mar.13.2002
When theres a board that can be populated as two very famous effects, the question always is which
effect should I build on this board? To help with this issue, heres a mod that involves adding a 4 pole
double throw toggle switch so that you dont have to make that decision. Populate the board with the
resistors for the Rosscomp, but leave the capacitors out. Instead, solder wire leads to the pads
marked on the layout below. Take the switch and solder the caps to it, all the negative leads of the
electrolytics go to ground, and the positives go to the respective poles. Switch ON: you get Ross,
Switch OFF: Dyna. MXR and Dynacomp are registered trademarks owned by Dunlop.
500k
50k
+9V
0.05
0.01
27k
1M
10k
IC 1
Q2
10uF
+
Rd
Rb
10k
Re
Cc
+
Ra
Rc
1uF
+
Ca
+
0.01
10k
Q3
D1
1M
0.01
GND
Cd
IN
0.01
4M7
0.001
27k
150k
56k
2k
trim
+
10uF
OUT
1uF
+
0.01
15k
1M
1M
10k
Q1
Cd
NC
Cc
NC
Ca
NC
Cb
NC
4PDT
SW
Q5
LEVEL
D3
1uF
+
D2
Cb
+
Q4
10k
150k
SUSTAIN