9. SIMPLIFIED
FIRE-SELECTOR MECHANISM
For those who wish to we 2 much simpler fteselctor
mechanism for selective fting than the one previ pie:
"ured, the author hae desianed ore Wat f equally relate
And yequizs only one mong pat.
“The simplified fie selector rachsnisn coneis ofa sal,
fat spring, a vet that doubles asthe selector pi block ad
4 pull neh which i ko ivted to tne iat spring. The knob
Is used to tthe selector (at spring) to clear the receiver
hole so that it canbe sid fom one index tothe othe forthe
‘ype of fie requifed. Though this simplified ssletor device
functions the same atthe one previously Featured i ismuch
catler and les time-consuming to bul
‘Another advantage of Che simplified varson & that it
requires only two 1/8 diameter hele in ine. Te rear hoe is
riled rough in the same postion axon the more com
plex selector for the pia block asebly hole controling the
lontWard ation of the tiger lever. The second hole i ine
In Hont off nor deilled through the reefer wall wil
‘be sed as un index for smiautopasition
“The siall diameter snd_portion of the dide hold open
‘tevin pin wil be natehed Novirontally om the top and bot
{om section to secure the assembly of the seeetor (at
spring) in pice The oct end ofthe Mat spring an elong-
Sted woteh whieh ports he aiding mation ofthe eestor
‘when moved frm one ile to the ot, On the front end
of che ot, aIggersrcuar slot is alo ut to clear the diame
‘erof the pinto peamit the asembly of te selector on ik,
"To mete the talon from one Postion tothe other, the
somal nob (ao riveted fo the selector) met be pulled up
luni the selestor pin Bock (voted pin under the selector oF
its reat end) clears the suface of the sealer ame. The
Selector ea then be moved to the other index by placing the
in block tothe oxt index hoe
Note: A small Nat needle file or a mini hacksaw can be
sad to out tho two herizontl notches onthe side stop pin
for selector assembly clemance. These notches musi tate
with a flat spring not exceeding 025 i thickness.
Flat spungs normally come in a tempered (hardened)
State and must be annealed prior to cutting the long sot
‘wel athe ring ofthe noe for sveting the pin and knob.
‘Annealing can be zesomplshe! by uslng a propane torch at
Tew volume to heet the pa unti it turns bluish gray. Then
Tet It ooo}, and test the Rardress ater cooling by ng. Re
temper tha pat alter slotting ond dein the hae for rvet-
{ng The pin ond knob car now be riveted to the par os spt
fed
‘To make the slonented slot ln the spine, cel ¢ sons of
Toles the width of the slot required ajo them to Fors
Slot using 2 round nedle file. Ealerge the hols if requned
For asembly.g
~ AO |
SIMPLIFIED SELEC
SEMIAUTO POSITION
DESIGN INDEX SETTINGTRECEWER MonIEteaTION, FOR SiMpLIbIED.
os
e7——Ss