Tech Note
For inside Neutral position springs for
@ information only Danfoss steering units OSP
HN.21.1A.02 is new
The torque curve drawn below has been based on
torque measurements taken from a steering unit
connected to a steering system in operation.
e The curve shows the torque sequence for loading
and unloading.
The curve represents the average values measured on
steering units from current production.
‘
Spring set The spring sets are composed as follows:
Standard springs
Spring set, grey colour, consists of:
e 2 off 150-0720
and 4 off 150-0721
Grey spring set,
code number: 150-4209
Soft springs
Spring set, blue colour, consists of:
2 off 150-0748
and 2 off 150-0749
Blue spring set,
code number: 150-4265
7-1989 HN.21.1A.02 . 1characteristics
for the
individual
spring type:
@= angular
motion be-
tween spool
and sleeve
The spring characteristics show that the torque in
the load phase (arrow towards right) is the torque
which is felt at the steering wheel when steering.
The torque in the unloading phase (arrow towards
left), is the torque available for the neutral
position of the spools.
standard springs
Tow
UdtNend
30.
20
o 1 2 3 #4 5 6 7 8 8 10alt)
‘Ac 15000034.10.02 $
a
soft spring
To
fet inked
30.
o 1 2 3 4 8 6 7 & 8 10atr)
AC 150¢0030.10.02 §
The Danfoss steering units are installed with
standard springs.
Please contact the Danfoss Hydraulic Sales
Organisation if neutral position springs are required
with other characteristics than that of the standard
springs.
HN.21.1A.02