Beruflich Dokumente
Kultur Dokumente
Command: COMMANDLINE
Command:
Command: l
LINE Specify first point:
Specify next point or [Undo]: @130<0
Command: zomm
Unknown command "ZOMM". Press F1 for help.
Command: zoom
Command:
Command:
Command: _offset
Current settings: Erase source=No Layer=Source OFFSETGAPTYPE=0
Specify offset distance or [Through/Erase/Layer] <10.0000>: r
Command: zoom
Command:
Command: _circle Specify center point for circle or [3P/2P/Ttr (tan tan
radius)]: <Osnap on>
Specify radius of circle or [Diameter]: 24
Command:
Command:
Command: _circle Specify center point for circle or [3P/2P/Ttr (tan tan
radius)]:
Specify radius of circle or [Diameter] <24.0000>: 24
Command:
Command:
Command: _circle Specify center point for circle or [3P/2P/Ttr (tan tan
radius)]:
Specify radius of circle or [Diameter] <24.0000>: 24
Command:
Command:
Command: _circle Specify center point for circle or [3P/2P/Ttr (tan tan
radius)]:
Specify radius of circle or [Diameter] <24.0000>: 24
Command:
Command:
Command: _circle Specify center point for circle or [3P/2P/Ttr (tan tan
radius)]:
Specify radius of circle or [Diameter] <24.0000>: 14
Command:
Command:
Command: _circle Specify center point for circle or [3P/2P/Ttr (tan tan
radius)]:
Specify radius of circle or [Diameter] <14.0000>: 14
Command:
Command:
Command: _circle Specify center point for circle or [3P/2P/Ttr (tan tan
radius)]:
Specify radius of circle or [Diameter] <14.0000>: 14
Command:
Command:
Command: _circle Specify center point for circle or [3P/2P/Ttr (tan tan
radius)]:
Specify radius of circle or [Diameter] <14.0000>: 14
Command:
Command:
Command: _circle Specify center point for circle or [3P/2P/Ttr (tan tan
radius)]:
Specify radius of circle or [Diameter] <14.0000>:
Command:
Command:
Command: _circle Specify center point for circle or [3P/2P/Ttr (tan tan
radius)]:
Specify radius of circle or [Diameter] <27.0000>: 37
Command:
Command:
Command: _trim
Current settings: Projection=UCS, Edge=None
Select cutting edges ...
Select objects or <select all>: Specify opposite corner: 23 found
Select objects:
[Fence/Crossing/Project/Edge/eRase/Undo]:
[Fence/Crossing/Project/Edge/eRase/Undo]:
Command:
Command:
Command: _trim
Current settings: Projection=UCS, Edge=None
Select cutting edges ...
Select objects or <select all>: Specify opposite corner: 33 found
Select objects:
Command:
Command: _.erase 1 found
Command:
Command:
Command: _SAVEAS
Command: Specify opposite corner:
Command: Specify opposite corner:
Command: Specify opposite corner:
Command: *Cancel*
Command: *Cancel*
Command: *Cancel*
Command: *Cancel*