Beruflich Dokumente
Kultur Dokumente
TMI 05 11 05 27
Date
Issue
Page
2011-06-08
1(2)
Products affected
4
Trucks in Series
G
P
R
Bus in Series
K
N
Scania Engines
F
Service solution
Fill the gearbox with specified amount of oil and then add extra 2 litres of oil
Note! If it is a new vehicle start at point 4. Always fill the same oil as in the gearbox.
1. Drain the gearbox of old oil, the vehicle should stand in a flat area. Remove the oil plug
and the level plug. Wait until no more oil is coming out of the gearbox.
2. Remount the oil plug, exchange the oil filter.
3. Fill the gearbox to the right level. Either by amount or by level. See WSM 00:16-15
Note! With cold oil it could take some time to fill up the range and therefore it is important
to wait some time and after fill the gearbox. It is recommended to start the vehicle and let
it stand on idling so the oil filter will be filled, after fill the gearbox to the right level.
4. Fill the gearbox with 2 litres of extra oil. It is recommended to extra fill through plug
812374 or sensor 1771230 depending if it is a OPC gearbox or not.
See Multi 05-01-0402
In mining application it is recommended to use Scania Transmission Oil STO 1:0, SAE 85W140 API GL-5.
STD10053-1
Exchange of oil and filter should be made no later than every 1500 hour
SCANIA CV AB
Global Technical Helpdesk
SE-151 87 SDERTLJE
SWEDEN
Telephone
Nat. 08-553 836 00
Int. +46 8 553 836 00
Telefax
Nat. 08-553 848 88
Int. +46 8 553 848 88
E-mail
teknik.helpdesk@scania.com
TMI
Issued by (department acronym name phone)
TMI 05 11 05 27
Date
Issue
Page
2011-06-08
2(2)
Dengan Hormat
Kami baru saja mendapatkan informasi dari Scania untuk melakukan
STD10053-1
Akan tetapi perlu diperhatikan hal saat mengganti oli dan menambahkan 2 liter adalah sbb :
1. Setelah oli di drain dan oil filter dipasang kemudain diisi olie sampai level tunggu beberapa
saat lamanya sampai oli turun.
2. Sangat direkomendasikan untuk menyalakan engine dan biarkan stationer sehingga filter oil
benar-benar terisi.
Kemudian pastikan olie sudah sampai level atau volumenya adalah 16.5 Liter untuk Type
Gearbox GR/GRS/GRS) 905 dan 16.8 Untuk type GR900 dan GRS920.
3. Tambahkan olie sejumlah 2 liter dari plug ataupun speed sensor.
SCANIA CV AB
Global Technical Helpdesk
SE-151 87 SDERTLJE
SWEDEN
Telephone
Nat. 08-553 836 00
Int. +46 8 553 836 00
Telefax
Nat. 08-553 848 88
Int. +46 8 553 848 88
E-mail
teknik.helpdesk@scania.com