Beruflich Dokumente
Kultur Dokumente
Taper Blank
Solid Mesh
Date: 2014,05,04
Out Lines
Outlines of Taper Blank with Solid :
Sample 1
1. Start DF 5.9.2 to open the database file. See Figure 1.
Figure 1
Sample 1
2. User Setup->Blank Generator>Taper solid mesh. Select the top
surface and then select the bottom flat surface as the plane.
Top surface
Bottom surface
Figure 2
Sample 1
3. Use the default parameters and click on the Apply button. The result
is illustrated in Figure 3. A new part named SOLID000 is created for
the generated solid mesh.
Figure 3
Sample 2
4. The same operation can be done as in Sample 1 in the previous
slide. Sample 2 and the generated result are illustrated as follows.
Top surface
Figure 4
Bottom surface
Sample 2
5. The generated result in Sample 2 is illustrated as follows.
Figure 5
Sample 3
6. The same operation can be done as in Sample 1 in previous slides.
Sample 3 and generated result are illustrated as follows.
Top surface
Figure 6
Bottom surface
Sample 3
7. The generated result in Sample 3 is illustrated in the following.
Figure 7