100%(1)100% fanden dieses Dokument nützlich (1 Abstimmung)
466 Ansichten1 Seite
The document provides instructions for configuring diagnostic tools to communicate with different vehicle modules. It specifies setting configuration files to define the module type and IP addresses. Files like Cal.ini, CAL, and HHTWin.ini need to be edited to set the platform parameter and slave address based on whether connecting to a PartD or SDconnect module. It also lists the typical IP addresses for connecting to the SDconnect module over LAN or wireless connections.
The document provides instructions for configuring diagnostic tools to communicate with different vehicle modules. It specifies setting configuration files to define the module type and IP addresses. Files like Cal.ini, CAL, and HHTWin.ini need to be edited to set the platform parameter and slave address based on whether connecting to a PartD or SDconnect module. It also lists the typical IP addresses for connecting to the SDconnect module over LAN or wireless connections.
The document provides instructions for configuring diagnostic tools to communicate with different vehicle modules. It specifies setting configuration files to define the module type and IP addresses. Files like Cal.ini, CAL, and HHTWin.ini need to be edited to set the platform parameter and slave address based on whether connecting to a PartD or SDconnect module. It also lists the typical IP addresses for connecting to the SDconnect module over LAN or wireless connections.
1. In your F:\Programme\DAS\bin folder set your Cal.ini file this:
For PartD (C3) Mux: [SERVER] REPORT=0 PLATFORM=PART_D2 For SD connect (C4) Mux: [SERVER] REPORT=0 PLATFORM=PART_T (or optional _W for Wi-Fi ONLY communication) 2. In your F:\Programme\Xentry\bin folder set your CAL file this: For PartD (C3) Mux: [SERVER] ; PLATFORM: PART_D, PART_J, PART_V, ... PLATFORM=PART_D For SD connect (C4) Mux: [SERVER] ; PLATFORM: PART_D, PART_J, PART_V, ... PLATFORM=PART_T 3. In your F:\userdata\config folder set your HHTWin.ini For PartD (Star C3) Mux: [STARTUP] SLAVE=PARTD2 For SDconnect (C4) Mux: [STARTUP] SLAVE=PARTT2 4. Also copy the HHTWin.ini in your Windows MAIN folder. 5. C4\Sdconnect IP: LAN IP : 172.29.127.119/255.255.0.0 WIRELESS IP: 192.168.2.221/255.255.255.0
When Using An OBD II Scan Tool Other Than TOYOTA Hand-Held Tester, Check All The Steps. - When Using TOYOTA Hand-Held Tester, Confirm The Information Code and Check It.