Simulate the given diagram using the following requirements:
TWO
THREE ONE
SWServer
PC1
` PC3
SWClient
` PC2
1. Use PPP WAN encapsulation on all serial interfaces.
2. Use 172.16.0.0 IP Block 3. PC3 and PC2 will automatically receive ip addresses on Router THREE. 4. These are the following IP addresses requirements LAN on PC1 300 Host LAN on PC2 150 Host LAN on PC3 200 Host 5. Use PAP as an authentication on your PPP. Router ONE - Username ONE password cisco Router TWO - Username TWO password class Router THREE - Username THREE password cisco 6. SWServer must be configured as a VTP Server. 7. SWClient must be configured as a VTP Client. 8. Switches port assignments Port 1 on SWServer Trunk port going to Router THREE Port 24 on SWServer Trunk port going to SWClient Port 3 on SWServer VLAN 10 Port 3 on SWClient VLAN 20 Port 24 on SWClient Trunk port going to SWServer 9. Configure all necessary passwords use class as the secret password 10. Configure console and telnet connections use cisco as the password 11. Use OSPF as the routing protocol. 12 Serial Connections are as follows: Router TWO is the DCE going to Rotuer ONE Router THREE is the DCE goint to Router TWO Use 64000 as your clockrate