Beruflich Dokumente
Kultur Dokumente
.XXX THRU
.XXX
.XXX
.XXX
.XXX
.YYY .YYY
.XXX THRU
.XXX
.ZZZ
.ZZZ
(or by dimensions)
.ZZZ
(or by dimensions)
.YYY
.XXX
.XXX
( .ZZZ )
( .YYY )
( .XXX )
.XXX
.XXX
.XXX
.XXX
(a)
This view not required
(b)
Both views required
.XXX
(c)
This view not required
COUNTERBORED DIMENSIONING
FIGURE 5-49
= SPOTFACE;
= DEEP
5.6.2.5 Spotface Symbol. Spotfacing is the operation of cleaning up the surface around a feature. The diameter
of the spotface is specified. The depth or the remaining thickness may be specified, otherwise, minimum depth
necessary to clean up the surface is understood. See FIGURE 5-50.
4X
.XXX
.XXX
4X
(Clean up)
.XXX
.XXX
or
4X
.XXX
.XXX
.XXX MAX
(Controlled)
(a)
.XXX
(b)
SPOT FACE DIMENSIONING
FIGURE 5-50
SECTION 5
TENTH EDITION 2000
DIMENSIONS & TOLERANCES
5.6.2.6 Countersunk And Counter Drilled Hole Symbols. The diameter and included angle for the
countersink are specified for countersunk holes. See FIGURE 5-51a. For counter drilled holes, the diameter and
depth of the counter drill are specified. See FIGURE 5-51b. Specifying the included angle of the counter drill is
optional. The depth of the drill and counter drill is measured from the outer surface of the part to the depth of the
full diameter.
.XXX
.XXX
.XXX
.YYY
.ZZZ X 82
(or by dimensions)
82
YYY
.YYY X 120
(or by dimensions)
120 (optional)
.XXX
.ZZZ
.YYY
.YYY
.YYY
.XXX
.XXX
(b)
This view not required
(a)
This view not required
.XXX
CONVEX
Curved
surface
CONCAVE