|
1
LL —
| SERVICE MANUAL
YNTRONIX /
_ L008)
>
vHe1 < 5 .
VHF=3 «| oso R | Teletext
UHE «J E inlerface gy! i fl
iS (optional) 8 I~ sotional) i
7 8 Fone setens)
AV Select «| 22}—> e >) on
QS BL 6 1? bscreen |
S28 > foispe
{ SBE > Fotonk eed
> a
spo TS a a we Wai Coen
28 local keys — Sates t= leae 68 2K2
A elf oletent |S Ssh Bethy
HS 27\k—~vsyne = 19 MHz DOSC
234 19) 151 cabo | B26 /e— Hsyne cee)
2 47 23/e—ioent
v3pooKH 8
254 231 201 16] 1 AFC input
a $ aie e
02[-00+ 5
2, 251 294 ay 17} 134 O77 ey 3 38} system select
f oy ] 37|-— sound effect
sgl als ig! Pott 36|—Sscund output
y¥ yy 42, | —>|20 34/€— Sound input (Ducl/NOT Dual)
|
Diagram of PCA84C640 P/019 in CTV3208.
(> yO SOUND (PICTURE Ok)
Check
SIF Output at AU-OUT.
YES
Check the
1C601,1C602
Signal output=?
YES
‘Check/Replace
Wire and Speaker.
ABNORMAL
‘Check Sound
|. (rama Volume level)
a
L
——
oe
Check/Replace
Vert. Output
Circuit and
Replace R412.
Ls
NO.
NO.
NO VERT.SCAN (ONE HORIZ.LINE RASTER)
SO
Check/Replace
Ic101
Check/Replace
Check Fusible Resister
. com
ABNORMAL ]
Check/Replace
Vert. OSC Circuit
16101, Pin 3,4. |
a
i
Check/Replace
Deflaction Yoke
wire and Connector.
7
_
106011602‘TDA4E601 (IC801)
‘The integrated circuit TDAS601 oF-D Is designed for
requiating controlling and protecting the switching
transistor installed in the flyback converter power *
supplies. it also protects the completa SMPS by
preventing an increase In the secondary vottage In
case of errors. In addition to their uso with TV recelvers
and video recorders, these ICs can be applied in
power supplies of HI-FI sets and active speakers due to
their wide operational ranges and supperior voltage
stability during high load change.
1. Features
- Direct control of switching transistor
~ Low start-up current
Reversing linear overload characteristic
Collector current proportional to base-current input
- Protective circuit in the event of errors.
NON-VOLATILE MEMORY
2. Pin description
Pin No Function
1
2
3
Vref output
Zero-passage identification
Input regulating ampiifier,verload
amplifier
Collector-current simulation
Possible connection for additional
RLDoprotective circuit
Ground (rigidly connected to substrate
ALDOmounting plate)
DC voltage output for charging the
ALDOcoupling capacitor
Pulse output, driving the switching
ALDotransistor
Power supply
The CTV320s tuning and sound system requires 128 bytes non-volatile memory (EEPROM PCF8581A or CMOS
PCF2). With such a memory the system is able to store up 40 “pre-selected” programs, the video and sound
control values (option 9a). The number of programs can be extended to 90 (option 9b) by usit
memory (EEPROM PCF8582A or CMOS PCF8570)..
19 a 256 bytes
+5 von +5 volt
1 8 y 1 8
sho va 10 ved
poraseza 10% | pcrasvo/72 | sk6
at 7 star
ore ;
7 ica
pcreses rage =
Ih = sh, Ly
a |
scue—> scf&—>
4 £C bus 4 vc bus
iss soa vss soae
Application of CMOS and EEPROM non-volatile memory in CTV320S.
20NO RASTER (SOUND OK)
: ¢
|
__tahtng or nee
YES tO
ee cree
Check HV, and Cheek Heater puso |
Screen Volt of CRT. ‘on the CRT Board. |
NORMAL —_ ABNORMAL (as Z
| What's the state of Check Replace apNorMaL |
| ICS01's pin 167 RO10,F.B.T (1444). ‘Check/Replace
— FBT (T4a4)
HIGH “| (
Check
| Check/Repla
eon Bright’Contrast. NORMAL
NORMAL [————— ABNORMAL Z
f Check Replace
| Check/Replace
| IC101,IC201. RICO RICO2.
: f
NO PICTURE (RASTER ON) AND NO SOUND
Tester leads(OHM range *100) to J
PIN IF of Tuner and ground,
momentarity.
J
(Whether noise Is appeared on the screen or not) ¢
oa er noise Is appeared on the screen oF not) No
——- —-
Measure the voltage of Measure the voltage
1C101's pin [ feneael of each pin 1C101,
RF AGC OUTPUT),
eee j Check/Replace
— r 1C101 and
SAW Fiter (Z101 |
NORMAL, [I
————2N0RMAL Norma! v
aa CheckReplace ] Check/Replace
| 7 RICO RICO2. L200 (Sound
each pin of Tuner. Trap titer)
— 201.
CheckRepiace 1 NoMa
| Check/Repi dp
| | ghecwmertaceTROUBLE-SHOOTING CHAK 1
she folowing chats aro devoted 10 the trouble-shooting Locate the Chat applicable and then, progress through
The oir oowes caret, wil assist you in racking the various akernales ‘until a final block indicates the
Gown a fault to the correct stage. defective components or stages.
owrger to uilize the chars (fault trees), frst establish
tho complains, i-No Raster, No Sound
NO RASTER AND NO SOUND
Measure voltage of +125V
at TP-125 the main BOARD.
NO +125V
NORMAL
dt
_ [ Segeten
| Resistor R825.
5 | __ |
|
OPEN. > a
| — seeeeeeeeneereeeea
on [ Check/Replace
’ Horiz circuit,
| IF circuit
| Gnroma circuit, |
| Grone
a | |
cnn |
Seance | corm
Sues Chea | a
Ge eectescmeny ea NO [ oheck
| Hecz Great," | [chase sno | Beghe |
: |) Horarra Colour, |
eee | —, | Volume Level
|
|
— ct
[ Peseta. | [ Sasa |
— J .
18SCHEMATIC DIAGRA
PSBSCIC4)
PAL-B/G RMIO9 REMOTE SYSTEM
(38104-182-8101
Q
=