3-IN-ONE. MATERIAL SAFETY DATA SHEET
1, PRODUCT IDENTIFICATION
Manufacturer: 'WO-40 Company [Teiephone:
Emergency only: 1-888-324-7596
Address: 4061 Cudahy Place (92110) (PROZAR)
P.O, Box 80807 Information: ++1-619-275-1400
San Diego, California, USA Trade Name: 34N-ONE White Lithium Grease
82138-0607 tem Number: 85042, 86042
I HAZARDOUS INGREDIENTS
‘Chemical Name CAS Number % Exposure Limit
‘ACGIHIOSHA
Aliphatic Petroleum Distilates 8052-41-3 28-30 100 PPM (TLV)
Lithium Grease NDA 20-25 NOA
Hiydrocarton Propellant 68-476-86-8 40-50 600 PPM (TLV)
til, PHYSICAL DATA
Pour Point. NDA Evaporation Rate: NDA
Vapor Denstiy (air= 1): NDA Vapor Pressure: 35-60 PSI @ 70°F
Sotubitty in Water: insoluble ‘Appearance: off white
Specific Gravity (HzO) 084 Odor: petroleum
[Percent Volatile (volume) 78.6%
IV. FIRE AND EXPLOSION
Flash Point: “20F
Fiammable Limits (Le) 1.8 (Leh 95
Extinguishing Media: 0%, dry chemical, foam
Special Fire Fighting Procedures: EXTREMELY FLAMMABLE. UFC level 3 aerosol
[Unusual Fire and Explosion Hazards: Keep away from ignition source and open flame. Contents under pressure.
V. HEALTH HAZARD / ROUTE(S) OF ENTRY
[Threshold Limit Value:
Distiliates (Petroleum) lowest TLV (ACGIH 300 ppm)
[Symptoms of Overexposure:
Inhalation (Breathing): May cause anesthesia, headache, dizziness, nausea and upper respiratory tration.
Skin contact: May cause drying of skin andlor iritation
Eye contact: May cause irtation, tearing and redness.
Ingestion (Swallowed): May cause irtation, nausea, vomiting and diarrhea.
First Aid Emergency Procedures:
Ingestion (Swallowed): Do not induce vomiting, seek medical attention.
Eye Contact: Immediately fish eyes with large amounts of water for 15 minutes.
Skin Contact: ‘Wash with soap and water.
Inhalation (Breathing): Remove to fresh air. Give artificial respiration if necessary. If breathing is dict, give oxygen.
Pre-existing medical conditions such as eye, skin and respiratory disorders may be
aggravated by exposure,
DANGER!
‘Aspiration Hazard: I swallowed, can enter lungs and may cause chemical pneumonitis. Do not induce vomiting.
Call physician immediately
[Suspected Cancer Agent The components in this mixture have been found to be noncarcinogenic by NTP, IARC and
lves__No X OSHA,VI.REACTIVITY DATA
fStabinty: Stabie_X_ Unstable:
[Conditions to avoid Heat and open flame
Incompatibility. Strong oxidizing agents
Hazardous decomposition products: Carbon monoxide andior carbon dioxide
Hazardous polymerization: May occur Will not ocour_X,
Vil. SPILL OR LEAK PROCEDURES
[Spill Response Procedures
Spill unikely from aerosol cans. Leaking cans should be placed in plastic bag or open pall unti pressure has dissipated.
Waste Disposal Method
Empty aerosol cans should not be punctured or incinerated: bury in land fil. Liquid should be incinerated or buried in land fl
Dispose of in accordance with local, state and federal regulations.
Vill. SPECIAL HANDLING INFORMATION
[Ventiiation: ‘Sufficient fo Keep solvent vapor less than TLV.
[Respiratory Protection: ‘Advised when concentrations exceed TLV.
|Protective Gloves: ‘Advised to prevent possible skin irritation.
|Eye Protection: Approved eye protections to safeguard against potential eye contact, irtation or injury,
lOther Protective Equipment: ___None required.
1X, SPECIAL PRECAUTIONS.
[Keep from sources of ignition. Avoid excessive Inhalation of spray particles, do not take fatemally, 06 not puncture, incinerate or
[store container above 120°F. Exposure to heat may cause bursting. Keep can away from electrical currrent or battery terminals.
[Electrical arcing can cause bum-through (puncture) which may resutt in flash fire, causing serious injury. Keep from children.
X. REGULATORY INFORMATION
[Allingredients for this product are listed on the TSCA inventory.
|SARA Title Il chemicals: None
[Caltoria Prop 68 chemicals: None
ICERCLA reportable quantty None
RCRA hazardous waste no: oot
.
SIGNATURE: R. Miles TITLE:
REVISIONS DATE: October 2002 (New) SUPERSEDES:
NA: Not applicable NDA: No data available <= Less than >= More than
We belive the statoments, technical rformation and recommendations contained herein are refsbo, However, the data Is provided without warranty,
‘expressed or imped. Its he user's responsibly both o detormine safe condons for use ofthis product and assume loss, damage oF expense, director
‘consequential arising om ts vse. Before using produc, red abel