Beruflich Dokumente
Kultur Dokumente
Service
Category Vehicle Interior
Applicability
Introduction
Some 2005 – 2009 model year Tacoma vehicles may exhibit an instrument panel rattle or tick noise
below the glove box area. The faint noise is most evident when accelerating slowly between the
1000 – 1600 RPM range. The rattle has been found to be coming from a wire harness cover coming
into contact with the HVAC bracket. Use the following repair information to correct this condition.
This TSB applies to all 2005 – 2009 model year vehicles produced BEFORE the Production Change
Effective VINs shown below.
MODEL PLANT CAB TYPE PRODUCTION CHANGE EFFECTIVE VIN
Standard
NUMMI Access 5TE####N#9Z667583
Tacoma
Double
TMMBC Double 3TM##4#N#9M035912
Warranty Information
APPLICABLE WARRANTY
• This repair is covered under the Toyota Comprehensive Warranty. This warranty is in effect for
36 months or 36,000 miles, whichever occurs first, from the vehicle’s in-service date.
Repair Procedure
1. Locate the point of contact at the wire harness cover to the HVAC bracket shown in Figure 1.
Figure 1.
NOTICE
Be careful NOT to damage the wire harness
grommet (clip) when removing since this clip
will be reused.