Beruflich Dokumente
Kultur Dokumente
AD08B
For bus section (Q11, Q12, CB, Q21, Q22, CT3, CT4) there are 2 bay units
(BU@8, BU@9).
I assign Q11, Q12, CB, CT3 for one bay unit & Q21, Q22, CT4 for the other bay unit
but this message appears. Is this assignment not correct?
For bus section: which one is coorect: to insert 2 bay names (AD7A , AD7B &
assign components connected in BU@8 to AD7A & assign components
connected in BU@9 to AD7B as in figure 1 below) or to insert one bay name
(AD7) & assign all components in both BU@8 & BU@9 to AD7 as in figure
2 ???
Figure 1
Figure 2
If CB is closed & 2 busbar isolators are open, does end fault protection operate or
no?