Beruflich Dokumente
Kultur Dokumente
SOLUTIONS
Student name:
Question
Points
earned
Max points
10
10
10
Total
42
Very important:
Answers must be clearly written in the tables or on the lines
provided for this purpose. If an answer is not in the appropriate
table or on appropriate line, it will not be taken into account. In
solving the problems, you can use graphical or numerical procedure,
or a mix of the two.
1
Problem 1:
For the system below find the reactions (magnitude and direction) at points 1 and 2. Present
graphically on the plot the direction and sense of the reactions.
Solution
Reaction
At point 1
At point 2
Magnitude
Engineering unit
100
kN
141
kN
Problem 2:
Determine forces in rods A, B and C that are connected by hinges to a rigid body..
Solution
Force
in rod
A
B
C
Magnitude
110
72
102
kN
Compression or
extension
Compression
kN
Compression
kN
Compression
Engineering unit
Problem 3:
Determine the internal normal force, Nc, internal shear force, Vc, and the internal bending
moment, Mc, at the cross-section c-c of the system shown below. Sketch a plot showing the
direction and sense of the forces.
Solution
Force
Nc
Vc
Mc
Magnitude
Engineering unit
31
kN
27
kN
2.25
kNm
5
Problem 4:
For the system shown below determine the internal normal force, Nc, internal shear force, Vc,
and the internal bending moment, Mc, at the cross-section through point c. Sketch a plot showing
the direction and sense of the forces.
Solution
Force
Nc
Vc
Mc
Magnitude
Engineering unit
400
Compression
kN
200
kN
400
kNm
8
Problem 5:
The two bars are made of polystyrene, which has the stress-strain diagram shown. Determine the
cross-sectional area of each bar so that the bars rupture simultaneously when the load P=3 kip.
(Assume that buckling does nor occur.)
Solution
Cross-sectional
area of bar
A-B
C-B
Magnitude
Engineering unit
0.2
in2
0.8
in2
10
11