Beruflich Dokumente
Kultur Dokumente
Figure 1
Congratulations on your on your registration for Autodesk tinker cad and thank you for
downloading these instructions. Here you will be shown the process for creating a ducted
mount for a fan. Note the time required create this May very per person.
Materials
A functional computer that has internet access
Note a mouse is suggested however not required
BACKGROUND INFORMATION
all the dimensions are typically given in millimeters (MM)
in order to duplicate an object highlight or select it then
go to edit and select duplicate
all dimensions will be given in a length (l) by width(w)
height(h) or by LxWxH
Figure 4
Step 1
First from the dashboard open up a new project by
pressing the "Create new design" button
Step 2
Figure 2
Step 3
Step 4
go into the geometry tab and drag the shape "Round
Roof and drag it onto the work plane
change the dimensions to where it's length is 15mm,
the width is 10mm, and the curve is 1mm away from
the base
Now orient the shape to where it is standing up, and
aligned with the t shape from step 3 shown in figure
Step 5
duplicate the round roof made in step 4 be clicking on
it selecting duplicate
grab the duplicate shape and orient it onto the other
sides remaining 3 sides
repeat this till the bottom of the t shape has a curved
look and apply underneath the bottom of the t as
shown in figure 5.1 and 5.2
Figure 3
Figure 5.1
Figure 5.2
Step 6
go back into the geometry tab, select and drag shape
"Tube thin on to the work plane
change the dimensions to 20x20x20
go to the geometry tab and drag the shape "Torus thin
on to the work plane place it on top of top and
bottom to round the edges of the cylinder as shown in
Figure 6
Figure 6
Step 7
Go back into the geometry tab, select and drag shape
"box" onto the work plane
Change the dimensions of the box to 4x18x4 mm
note: it should look similar to Figure 7
Figure 7
Step 8
Grab another cylinder but instead click on hole in the
inspector tab on the right corner
Change the dimensions of the hole to 2x2x6 mm
Now position the cylinder's edge 2 mm away from the
boxes edge in the center
Duplicate onto the other side of the box
note: it should look similar to Figure 8
Figure 8
Step 9
Highlight the box and duplicate it
Grab the duplication and position it perpendicular to the first
box
Now highlight everything and move it 1 mm up and center it to
the cylinder in step 6 as shown in figure
Figure 9
Step 10
Duplicate the shape made in step 9 be highlighting it selecting
duplicate
Grab the shape to grab the duplicate shape and move it 40 mm
to the right
Now highlight the 2 cylinders and center them to the shape
made in step 5 as shown in figure 10
Figure 10
Step 11
Grab the round roof and drag it onto the work plane
Change the orientation by 90 degrees
Change the dimensions to 20x10x14 mm
Add this in between the two cylinders
itshould look like figure 11
Figure 11