Beruflich Dokumente
Kultur Dokumente
Sr. No. 4
EXAMINATION OF MARINE ENGINEER OFFICER
Function: Marine Engineering at Operational Level
MARINE ENGINEERING KNOWLEDGE (GENERAL)
M.E.O. Class IV
(Time allowed - 3hours)
India (2003) Morning Paper Total Marks 100
1. Expand the abbreviation COW and write a note (in about 250 words), to the
superintending engineer of your company on the benefits of having a COW system on
your crude carrier
2. An inverted gate valve (stem pointing downward) may be subject to wear sooner than
a similar valve installed in the upright position because ______________.
A. the gate's full weight is upon the stem
B. the gland stud nuts are under more pressure
C. sediment collects in the bonnet
D. the packing will not properly adhere to the stem
Briefly Justify Your Answer
3. After installing a new centrifugal pump in a cooling water system, what special
attention should be given to the system?
A. System
B. Pump
C. Relief Valves
D. Power Supply
Briefly Justify Your Answer
7. Discuss the effects of EACH of the following conditions on the maintenance schedule
of multi-tubular heat exchangers using sea water as the cooling medium:
A. Low water velocity in the tubes;
B. Wasted sacrificial anodes;
C. Fluid medium of varying viscosity;
D. Structural vibration of cooler fasteners and support
8. With reference to rotary vane steering gears, explain the principle of operation, by
illustrations and sketches
10. Sketch a simple auxiliary air (7 kg / cm2) system used for supplying
service air.
Explain the importance and purpose of each fitting
--------------------------X------------------------