0 Bewertungen0% fanden dieses Dokument nützlich (0 Abstimmungen)
16 Ansichten1 Seite
CALIBRATION AND ELECTRONIC MEASUREMENTS (Instrumentation and Control Engineering) Time: 3 hours Max Marks: 80 Answer any FIVE Questions All Questions carry equal marks.
CALIBRATION AND ELECTRONIC MEASUREMENTS (Instrumentation and Control Engineering) Time: 3 hours Max Marks: 80 Answer any FIVE Questions All Questions carry equal marks.
Copyright:
Attribution Non-Commercial (BY-NC)
Verfügbare Formate
Als PDF, TXT herunterladen oder online auf Scribd lesen
CALIBRATION AND ELECTRONIC MEASUREMENTS (Instrumentation and Control Engineering) Time: 3 hours Max Marks: 80 Answer any FIVE Questions All Questions carry equal marks.
Copyright:
Attribution Non-Commercial (BY-NC)
Verfügbare Formate
Als PDF, TXT herunterladen oder online auf Scribd lesen
II B.Tech I Semester(R05) Supplementary Examinations, November 2010
CALIBRATION AND ELECTRONIC MEASUREMENTS (Instrumentation & Control Engineering) Time: 3 hours Max Marks: 80 Answer any FIVE Questions All Questions carry equal marks ?????
1. Write short notes on any of the F OU R:
(a) Arithmetic mean (b) Deviation from the mean (c) Average deviation (d) Standard deviation (e) Variance. [16] 2. Write short notes on any THREE standards: (a) Resistance (b) Voltage (c) Current (d) Capacitance [16] 3. Write short notes on any of the T HREE : (a) Primary calibration (b) Secondary calibration (c) Direct calibration (d) Indirect calibration [16] 4. (a) Write short notes on the principle of peak reading voltmeter? (b) Illustrate the principle and working of ramp type DVM? Compare its performance with other types of DVM’s? [8+8] 5. (a) Draw the circuit of a schering bridge and discuss its principle with the help of suitable derivations and phasor diagram at balance. (b) Write a note on the dissipation factor of a capacitor. [10+6] 6. (a) With the help of a block diagram explain the multiplexed display technique used in a frequency counter. (b) Explain in detail about frequency mode errors and period mode errors. [4+6+6] 7. (a) With a block diagram explain the operation of digital storage oscilloscope. (b) Why is a delay line used in the vertical section of the oscilloscope? Explain different types of delay lines. [8+2+6] 8. (a) List the important functions of galvanometer recorders. (b) Explain common anode seven segment display. [8+8]