Beruflich Dokumente
Kultur Dokumente
324319 kg 715,000 lb
GROSS HORSEPOWER
1491 kW 2,000 HP
730E
730E
SPECIFICATIONS
ENGINE FRAME
BODY
SUSPENSION
All-welded steel flat floor body with horizontal bolsters and full canopy.
HYDRAIR® II
Eyebrow, rear wheel rock ejectors, body up cable and rubber mounts
Variable rate hydro-pneumatic with integral rebound control.
on frame are standard. Pivot exhaust heating optional.
Maximum front stroke . . . . . . . . . . . . . . . . . . . . . . . 335 mm 13.2''
Bottom plate . . . . . . . . . . . . . 19 mm 0.75'' 1034 mPa 150,000 psi
Maximum rear stroke . . . . . . . . . . . . . . . . . . . . . . . 279 mm 11.0''
tensile strength steel (two-piece)
Maximum rear axle oscillation . . . . . . . . . . . . . . . . . . . . . . . ±9.75º
Front sheet . . . . . . . . . . . . . . . 12 mm 0.47'' 690 mPa 100,000 psi
tensile strength steel
Side sheet . . . . . . . . . . . . . . . . 9 mm 0.35'' 690 mPa 100,000 psi
tensile strength steel COOLING SYSTEM
Struck . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77 m3 101 yd3
L&M radiator assembly with sight gauge. Deaeration-type
Standard SAE heaped 2:1 . . . . . . . . . . . . . . . . . . . 111 m3 145 yd3
top tank. Dual pass cooling.
Radiator frontal area . . . . . . . . . . . . . . . . . . . . . . . . 4.33 m2 46.6 ft2
CAB
DIMENSIONS
7.54 m 24'9"
3.43 m 11'3" 7.25 m 23'9"
8.43 m 27'8"
730E
12.51 m
41'1" 730 E
RAISED 6.25 m
2.08 m 20'6"
6'10'' EMPTY
5.61 m 2.90 m
9'6"
18'5''
EMPTY
45°
1.76 m
5'9"
1.14 m 3'9"
HYDRAULIC SYSTEM
2.32 m
7'7"
Steering. . . . . . . . . Accumulator-assisted with twin cylinders provide
constant rate steering. Emergency power steering 4.68 m 15'4"
automatically supplied by accumulator (meets SAEJ1511) 7.03 m 23'1"
Turning circle diameter (SAE). . . . . . . . . . . . . . . . . . . . . 28.0 m 92 ft
Reservoir . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 731 L 193 U.S. gal
Filtration. . . . . . . . . . . . . . . . . . . . . . . . . In-line replaceable elements
Suction . . . . . . . . . . . . . . . . . . . . . . . . . Single, full-flow, 100 mesh
Hoist and steering . . . . . . . . . Dual, full-flow, in-line, high-pressure
Brake component cabinet. . . . . . . . . . Above-deck, easily accessible ELECTRICAL SYSTEM
with diagnostic test connector.
Hoist . . . . . . . . . . . . . . . Two 3-stage dual-acting outboard cylinders, 4 x 8D 1450 CCA, 12 volt batteries, in series/parallel, bumper-
internal cushion valve. mounted with disconnect switch.
Hoist times Alternator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-volt, 140 amp
Power-up loaded . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 sec Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-volt
Power-down . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 sec
Cranking motors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . two/24-volt
Float-down empty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 sec
Pumps
Hoist . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Gear-type pump
with output of 513 lpm 135.6 gpm
WEIGHT DISTRIBUTION
@1900 rpm and 17240 kPa 2500 psi
Steering and brake. . . . . . . . . . . . . . . . . . . . . . . . Vane-type pump Empty vehicle weight (wet, 100% fuel, no options, std Komatsu body, std tires)
with output of 235 lpm 62.0 gpm Front axle . . . . . . . . . . . . . . . . . . . . . . 67484 kg 148,776 lb
@1900 rpm and 18960 kPa 2,750 psi Rear axle . . . . . . . . . . . . . . . . . . . . . . 73108 kg 161,174 lb
System relief pressures Total EVW . . . . . . . . . . . . . . . . . . . . . 140592 kg 309,950 lb
Hoist . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17240 kPa 2,500 psi Standard Komatsu body . . . . . . . . . . . 25612 kg 56,464 lb
Steering and brake . . . . . . . . . . . . . . . . . . . . 27580 kPa 4,000 psi Standard tire weight . . . . . . . . . . . . . . 18371 kg 40,500 lb
Quick disconnects standard for powering disabled truck
and for system diagnostics. Gross vehicle weight (Nominal)
Front axle . . . . . . . . . . . . . . . . . . . . . . 98941 kg 218,129 lb
Rear axle . . . . . . . . . . . . . . . . . . . . . 225377 kg 496,871 lb
Total . . . . . . . . . . . . . . . . . . . . . . . . . 324319 kg 715,000 lb
Nominal payload* . . . . . . . . . . . . . . . 183729 kg 405,050 lb
203 U.S. ton
*Nominal payload is as defined within Komatsu America Corporation’s payload policy
documentation. Nominal payload must be adjusted should the weight of any customized body or tires
fitted vary from that of the standard Komatsu body and tires as shown above. Nominal payload must
also be adjusted to take into account the additional weight of any customized/optional extras fitted to
the tr uck
uck which are not stated within the Standard Features
Features list of this specification sheet.
STANDARD EQUIPMENT
• Air cleaners, Donaldson SRG • Engine shutdown at ground level • High beam selector and indicator
• Alternator (24 volt/140A) • Exhaust blankets • Indicator lights (amber):
• Auto lubrication system • Hoist propulsion interlock - 5-minute idler timer
• Batteries (4 x 8D, 1450 CCA 12 volt) • Horns (back-up, front - electric) - Auto lube alarm
• Battery charging cable and socket • Integral roll-over protection (ROPS) - Check engine w/alarm
• Body left-side canopy protector • Maintenance and power lockout - Circuit breaker tripped
• Body over center device • Parking brakes with warning light and - Dynamic retarding
• Brakes: Front wheel speed disc; rear - speed application protection - Dump body up
dual disc armature speed • Power steering w/auto emergency steering - Hydraulic oil filter
• Electric start • Protective deck handrails - Low fuel level
• Fast-Fill Fuel System (in tank, right side) • Pump driveline protector - Manual back-up lights
• FLOC - fast lube oil change • Radiator fan guard - Park brakes applied
• Filters, high pressure hydraulic • Seat belts 76 mm 3" retractable - Retard speed control
• Gate valves on hydraulic tank • Skid-resistant coating on walkways - Service brakes
• Komatsu control cabinet STANDARD HIGH VISIBILITY DELUXE - Starter circuit
• Komatsu Payload Weighing System–PLM III CAB: • Horn (center of steering wheel)
• Mirrors, LH flat and RH rectangular convex • Independent brake/retarder pedals
• Air cleaner vacuum gauges
• Mud flaps • RS232 port - Statex III-PLM III
• Air conditioner HFC 134A
• Muffled exhaust, deck-mounted • Insulation (Max R-Valve)
• Alarm System warning lights (red)
• On board load box • Oil pressure gauge
- Accumulator pre-charge
• Power supply, 24 volt and 12 volt DC • Operator seat, adjustable w/air
- Coolant low level w/alarm
• Quick disconnects (hoist, steering) suspension, lumbar support and arm
- Coolant high temperature w/alarm
• Removable power module unit (radiator, rests
- Electric drive system cooling blower
engine, alternator, blower) • Panel lighting (adjustable)
w/alarm
• Rock ejectors • Passenger seat
- Electric system fault w/alarm
• Radiator sight gauge • Power windows
- Hydraulic oil level w/alarm
• Retard speed control • Pressurized cab air system
- Hydraulic oil temperature w/alarm
• Retard grids, continuous rated, 14 • Starter key switch
- Low engine oil pressure w/alarm
element • Sunvisor (adjustable)
- Low brake pressure w/alarm
• Reverse retarding • Tilt and telescoping steering wheel
- Motorized wheel temperature stop
• Thermostatic fan clutch • Voltmeter (battery output)
engine w/alarm
• Two-speed overspeed retarding • Wheel brake lock w/drive system
- Steering pressure w/alarm
• Vari-volt alternator control interlock
• AM/FM cassette radio, XM capable
• Vertical ladders • Windshield wipers, dual, washer (electric)
• Engine monitoring system
• Windshield (tinted)
• Digital tachometer and speedometer
OPERATION ENVIRONMENT AND • Dome light LIGHTING:
CONTROL: • Double door seals • Back-up lights-rear mount (2)
• All hydraulic service brakes with • Engine hourmeter, oil pressure gauge, • Brake and retard lights on top of cab
emergency auto apply water temperature gauge • Clearance lights (amber–front; red–rear)
• Battery disconnect switch • Engine shutdown w/5 minute delay timer • Control cabinet service light
• Body up cable • Floor mat • Dynamic retarding, rear (2)
• Brake lock and drive system interlock • Fuel gauge in cab and on tank • Headlights - (4) halogen
• Circuit breakers, 24 volt • Gauges (w/back light) • Ladder lights
• Dynamic retarding with continuous rated • Headlight switch • Manual back-up light, switch and indicator
grids • Heater and defroster (heavy-duty) • Service light in rear axle
• Heater switch • Stop and tail lights (2)
• Turn signals
• Under-hood service lights
OPTIONAL EQUIPMENT