Beruflich Dokumente
Kultur Dokumente
B F
C E
Turn on chiller system switch (A) The number screen (B) will be blinking for few second, and then show the current coolant temperature.
3-
Turn on pump switch (C) Open valve slowly (D) (counter clockwise to open/ clockwise to close)
4-
Turn on refrigerator switch (E), and wait until the temperature decrease to the setting temperature.
5-
The temperature is set at -1OC, and you can stard using vacuum rotary evaporator design when the temperature decrease to about 1OC. To change coolant temperature, used (F). You are not advised to do so! Turn on pump switch (G) and pressure control unit switch (H)(at the back of pressure control unit) and water bath switch (I).
6-
To set up the pressure, refer the table. Set up the pressure according to the boiling temperature you want to use.
7-
(J) button to increase the presure (K) button tu decrease the presure
8-
To install flask, start the operation, and remove flask, please refer autorized person (Azfar, Ruri, Nizam).
9-
To turn off, you have to switch off the refrigerator unit first (E) and wait until temperature rise to 8OC and do other step reversly.
10-