Beruflich Dokumente
Kultur Dokumente
Interfaces
The A-interface lies between the MSC and the BSS (Base Station Subsystem). The A-interface consists of both user plane (PCM links) and control plane (signaling). The C/D-interface between the MSC and the HLR is used by the GMSC (Gateway MSC) to interrogate the HLR in order to obtain routing information for a call to a subscriber. Signaling on this interface uses the MAP over TCAP protocols (MAP/C). The D-interface between the VLR and HLR is used to exchange data related to the location of an MS and the management of the subscriber. Signalling on this interface uses the MAP over TCAP protocols (MAP/D). The E-interface between two MSCs is used during inter-MSC handover. Signalling on this interface uses the MAP over TCAP protocols (MAP/E). When the BSS consists of a BSC (Base Station Controller) and one or more BTSs (Base Transceiver Stations), the Abis-interface between the BSC and BTS is used to support the services offered to the GSM users and subscribers. When the BSS consists of a BSC (Base Station Controller) and one or more BTSs (Base Transceiver Stations), the Abis-interface between the BSC and BTS is used to support the services offered to the GSM users and subscribers. The Um-interface is the air interface that is used for exchanges between an MS and a BSS.
Um DTAP (Direct Transfer Application Part ) Abis DTAP A -- BSSAP (Base Station System Application Part) CL3I -- Complete Layer 3 Information
Types of Registration
Normal location updating: used to update the LA (Location Area) of an MS when the MS changes LA. Periodic Updating: used to periodically inform the network that the MS is still available and thus prevents the MS from accidentally becoming detached from the system. IMSI Attach: used to indicate the IMSI as active in the network; it is the counterpart of the IMSI detach procedure. IMSI Detach: An MS may invoke the IMSI detach procedure if the MS is deactivated (e.g. powered down) or if the SIM (Subscriber Identity Module) is detached from the MS.
MT Exchange Property PURGECONTROL MGADP; IMSI -- International Mobile Subscriber Identity TMSI --Temporary Mobile Subscriber Identity
Location Updating
Location Updating
IMSI Attach
IMSI Detach
Call to MS
SCCP Analysis
<anrsp:rc=906; ROUTING CASE DATA OPERATING AREA RC CCH BR ROUTING SP DATA 906 NO TMR-0 &-3 &-4 P01=1 R=MSC96SO MM1 COT EST SI 0 0 1 1 BNT RN SPR OLI OLI2 4 00 0 ISC FCP D 0 <exrop:r=MSC96SO; ROUTE DATA R ROUTE PARAMETERS MSC96SO DETY=UPD1 TTRANS=1 FNC=3 R=MSC96SI ST=6 SI=ISUP4 SP=3-600 <c7gsp:TT=0,NP=1,NA=4,NS=9198203; CCITT7 GLOBAL TITLE SERIES DATA OPERATING TT NP NA NS 0 1 4 9198203 END GTRC 2 contd
ESS ESR
<c7ltp:ls=3-320; CCITT7 LINK SET STATE LS 3-320 SPID HLR2 01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 SLC STATE 00 ACTIVE ACTIVE ACTIVE ACTIVE ACTIVE ACTIVE ACTIVE ACTIVE ACTIVE ACTIVE ACTIVE ACTIVE ACTIVE ACTIVE ACTIVE ACTIVE INHIBST FCODE INFO
END
Routing Analysis
SCCP Analysis
HLR data
<hgsdp:msisdn=919820315708,all; HLR SUBSCRIBER DATA SUBSCRIBER IDENTITY MSISDN IMSI STATE AUTHD 919820315708 404201145038948 CONNECTED NAM 1 PERMANENT SUBSCRIBER DATA SUD CAT-10 DBSG-1 PRBT-1 BS26-1 TS11-1 TS21-1 TS22-1 OFA-1 . AMSISDN BS BC NONE SUPPLEMENTARY SERVICE DATA BSG TS10 SS STATUS FNUM TIME CAW ACTIVE-OP CFU NOT ACTIVE CFNRY NOT ACTIVE .. LOCATION DATA VLR ADDRESS MSRN MSC NUMBER 4-919820906441 919820906441 PACKET DATA PROTOCOL CONTEXT DATA NONE
AVAILABLE
LMSID
CCITT7 GLOBAL TITLE ROUTING CASE DATA OPERATING GTRC PSP PTERM PINTER PSSN SSP 39 3-900 YES NO END < STERM SINTER SSSN LSH NO
Call from MS
<mgslp:imsi=404201145038948,all; MT MOBILE SUBSCRIBER LIST SUBSCRIBER IDENTITY IMSI MSTAT MSISDN CAT 404201145038948 REG 919820315708
10
SUBSCRIBER NON SUPPLEMENTARY SERVICE DATA BASIC SERVICE DATA DCDA9600 SPCH SMS SUBSCRIBER SUPPLEMENTARY SERVICE DATA .. <mgisp:imsis=404201145038948; MT IMSI NUMBER SERIES ANALYSIS DATA OPERATING TABLE IMSIS M NA ANRES 40420114 5-919820 4 OBA-30 BO-33 OWNMS NATMS NRRG-0 PLMN-0 ERIS-0 MAPVER-2 INOPER-1 CBA-19 CBAZ-146
END
MT - SMS
Unsuccessful MT SMS
MO - SMS
MO SMS
SC Service Center Add > Global Title > SCCP translation. Almost 8 SC can be stored in MS The short message is transferred to the MS on a Standalone Dedicated Control CHannel (SDCCH) if the MS is idle, and on the Slow Associated Control CHannel SACCH if the mobile is active during a call.