Beruflich Dokumente
Kultur Dokumente
1, 5/8
1/8” 13/16’
4
++
3/16’’
9”
Objective: Student will demonstrate proper use and safety in a woodworking lab
by successfully building a Utility Clip.
1. Draw all lines on block as follows: (Do not cut, drill or sand until you are checked off)
locate center line (Lengthwise) and draw it on with a Combination Square or
ruler.
Lay out the two holes using the Compass. (3/4” 3/8” Dia)
Lay out the notches using the Tn-SQuare.
Lay out the front radius using the Compass. (1” Dia)
Lay out the rear taper using a Combination Square or Ruler.
STOP!!! Check your block for accuracy with the instructor.
2. Drill the largest hole with the 3/4” Forsner Bit as demonstrated.
3. Drill the smaller hole with Straight Shanked Drill Bit. (3/8”)
4. Obtain permission to use the Band Saw. Cut out the dado as demonstrated.
5. Obtain permission to use the Jig Saw or Band Saw. Cut out the diagonal sides as
demonstrated (LEAVE THE LINE). Then cut down the center to separate the
sides.
6. Obtain permission to use the Disc Sander. Sand the front radius as demonstrated
(LEAVE THE LINE).