Beruflich Dokumente
Kultur Dokumente
3, August 1991
975
Load Models
Loads can be connected at a bus (spot load)
or assumed to be uniformly distributed along
a line section (distributed load). Loads can
be three-phase (balanced and unbalanced) or
single-phase.
Three-phase loads can
be
connected in wye or delta while single phase
loads can be connected line-to-neutral or
line-to-line.
All loads can be modeled as
constant kW and kVAr, constant impedance (Z)
or constant current (I).
Table 1 lists the numeric codes that will
used to describe the various loads.
be
INTRODUCTION
Table 1
In
recent years many
digital
computer
programs have been developed for the analysis
of unbalanced three-phase radial distribution
feeders. The programs use a wide variety of
iterative techniques and range from very
simple with many simplifying assumptions made
for
line
and
load
models
to
very
sophisticated with little if any simplifying
assumptions. With so many different programs
available there is a need for benchmark test
various
feeders so that the results of
programs can be compared.
This paper presents the complete data for
three four-wire wye and one three-wire delta
radial distribution feeders. No results will
be given for any of the feeders. It is hoped
that developers of distribution
analysis
programs will use these test systems to test
their programs and to present results in
future papers.
BASIC DATA
The following data will be common
three systems:
4
5
Connection
WYe
WYe
WYe
Delta
Delta
Delta
Model
Constant kW, kVAr
Constant I
Constant Z
Constant kW, kVAr
Constant I
Constant Z
for all
Shunt Capacitor
Shunt capacitor banks may be three-phase wye
or delta connected and single-phase connected
line-neutral or line-line. The capacitors are
modeled as constant susceptance and specified
as nameplate rated kVAr.
Overhead Spacinu Models
The Spacing ID numbers and type for
lines are summarized in Table 2.
overhead
Table 2
510
~~
Type
Three-phase, 4 wire
Two-phase, 3 wire
Single-phase, 2 wire
976
1
I
Voltage Level
desired voltage (on a
120 volt base ) to be held at the
regulating point.
2.
Bandwidth
the voltage level tolerance
usually assumed to be 2 volts.
3.
4.
PT Ratio
turns ratio of the potential
transformer feeding the compensator
circuit.
5.
ID #500
ID #505
Figure 1
ID #510
AA
ACSR
500,000
AA
336,400
ACSR
ACSR
AA
ACSR
CU
4/0
2/0
1/ 0
1/ 0
#2
#2
#4
#lO
#I2
# 14
AA
ACSR
ACSR
CU
CU
CU
Table 3
556,500
1,000,000
Conductor Data
Conductor Type
1.
Res.
Dia.
fohm/mi.l
finl
0.105
1.150
0.186
0.927
0.206
0.813
0.306
0.721
0.592
0.563
0.769
0.414
1.120
0.398
0.607
0.368
1.540
0.292
1.690
0.316
2.550
0.257
5.903
0.102
9.375
0.081
14.872
0.064
GMR
fftl
0.03680
0.03110
0.02600
0.02440
0.00814
0.01250
698
730
483
530
340
230
0.00446 230
0.01113 310
0.~0883 156
0.00418 180
0.00452 140
0.00331
80
0.00262
75
0.00208
20
Load Types
a. All spot loads
b. Wye and delta connected
c. Mixture of constant kW,kVAR,
constant Z and constant I.
2.
Line Types
a. Three-phase overhead (all
combinations of a ,b ,c)
b. Two-phase overhead
(Combinations of a,b,c)
c. Single-phase overhead
(a-n, b-n and c-n)
d. Three-phase underground
3.
Voltage Regulators
a. Three-phase, gang operated
b. Three single-phase, wye connected
c. Two single-phase, open wye connected
d. Single-phase, line-to-neutral
connected
4.
Shunt Capacitors
a. Three-phase
b. Single-phase
5.
Substation
a. Three-phase short circuit MVA and
angle at the high voltage terminals
of the substation transformer.
b. Substation transformer ratings and
impedance.
c. Substation transformer output
voltages
6.
Motor
a. Step-down transformer
b . Starting kVA and power factor given
c. Running power factor
this
Figure 2
The
substation
feeder is rated:
transformer serving
5,000 kVA
115 delta-4.16 grounded wye kV
Z = 1.0 + j8.0 %
at
this
BUS A BUS B
1
1
1
3
3
5
7
2
3
7
4
5
6
8
8
12
13
14
34
18
152
11
13
13
13
14
8
9
LENGTH CONFIG.
(FT.)
CODE
175.0
250.0
300.0
200.0
325.0
250.0
200.0
225.0
225.0
300.0
425.0
150.0
825.0
0.0
250.0
10
11
1
11
11
11
1
10
9
1
9
11
2
506
9
978
Table 4
(continued)
Table 4
(continued)
IEEE 1 2 3 BUS RADIAL DISTRIBUTION SYSTEM
LINE SECTION DATA
BUS A BUS B
14
15
15
18
18
18
19
21
21
23
23
25
25
26
26
27
28
29
30
31
34
35
35
36
36
38
40
40
42
42
44
44
45
47
47
49
50
52
53
54
54
55
57
57
58
60
60
60
61
62
63
64
65
67
67
67
68
69
70
72
72
73
74
76
76
77
78
10
16
17
19
21
135
20
22
23
24
25
26
28
27
31
33
29
30
250
32
15
36
40
37
38
39
41
42
43
44
45
47
46
48
49
50
51
53
54
55
57
56
58
60
59
61
62
160
610
63
64
65
66
68
72
97
69
70
71
73
76
74
75
77
86
78
79
LENGTH CONFIG.
CODE
(FT.1
250.0
375.0
350.0
250.0
300.0
0.0
325.0
525.0
250.0
550.0
275.0
350.0
200.0
275.0
225.0
500.0
300.0
350.0
200.0
300.0
100.0
650.0
250.0
300.0
250.0
325.0
325.0
250.0
500.0
200.0
200.0
250.0
300.0
150.0
250.0
250.0
250.0
200.0
125.0
275.0
350.0
250.0
250.0
750.0
250.0
550.0
250.0
0.0
0.0
175.0
350.0
425.0
325.0
200.0
275.0
250.0
275.0
325.0
275.0
275.0
200.0
350.0
400.0
400.0
700.0
100.0
225.0
BUS
A
BUS
A
78
80
81
81
82
84
86
87
87
89
89
91
91
93
93
95
97
97
98
99
100
101
101
102
103
105
105
106
108
108
109
110
110
112
113
135
150
152
160
197
80
81
82
84
83
85
87
88
89
90
91
92
93
94
95
96
98
197
99
100
450
102
105
103
104
106
108
107
109
350
110
111
112
113
114
35
1
52
67
101
LENGTH CONFIG.
CODE
(FT. 1
9
11
11
9
2
506
9
10
2
11
2
7
2
7
11
9
2
2
2
11
11
8
1
9
10
10
11
1
10
1
9
1
9
4
4
4
4
1
1
1
3
1
10
3
10
5
12
506
3
12
12
12
12
9
3
3
9
9
9
11
3
11
475.0
175.0
250.0
675.0
250.0
475.0
450.0
175.0
275.0
250.0
225.0
300.0
225.0
275.0
300.0
200.0
275.0
0.0
550.0
300.0
800.0
225.0
275.0
325.0
700.0
225.0
325.0
575.0
450.0
1000.0
300.0
575.0
125.0
525.0
325.0
375.0
400.0
400.0
350.0
250.0
6
6
6
11
6
11
6
9
6
10
6
11
6
9
6
10
3
506
3
3
3
11
3
11
11
10
3
10
9
3
9
9
9
9
9
4
1
1
6
3
2
3
4
5
6
7
8
9
11
10
11
6
3
6
6
A
C
B
C
B
A
A
A
A
B
C
_I--
B
A
C
B
A
C
C
B
N
N
N
C
B
A
A
C
B
N
N
N
N
N
N
N
N
PHASE
COND
ACSR
336,400
336,400
336,400
336,400
336,400
336,400
336,400
336,400
1/ 0
1/ 0
1/0
26/7
26/7
26/7
26/7
26/7
26/7
26/7
26/7
NEUTRAL
COND SPACING
ACSR
ID
4/0 6 / 1
4/0 6 / 1
4/0 6 / 1
4/0 6 / 1
4/0 6 / 1
4/0 6 / 1
4/0 6 / 1
4/0 6 / 1
1/0
1/0
1/0
500
500
500
500
500
500
505
505
510
510
510
T-
---
979
512
Table 7
Three-phase
underground
1 ine
consisting
of three
1/0
copper
concentric
neutral
cables.
The
cables are spaced 6 inches apart on a
below
horizontal plane 40 inches
ground.
The
concentric
neutral
consists of 10-#14 copper conductors.
The outside diameter of the cable
(over the concentric neutral) is 0.97
inches.
506
3 -
Data
for
Table 6
PHASE A
PHASE B
KVAR
83
200.00
88
50.00
90
92
Total ***
250.00
***
Table 7
system
PHASE C
KVAR
KVAR
200.00
200.00
50.00
50.00
250.00
250.00
Data
for
this
Table 7
IEEE 123 BUS RADIAL DISTRIBUTION SYSTEM
BUS LOADS AS K W AND KVAR
BUS LOAD
NO. MDL.
1
2
4
5
6
7
9
10
11
12
16
17
19
20
22
24
28
29
30
31
32
33
34
35
37
38
1
1
1
2
3
1
1
2
3
1
1
1
1
2
3
1
2
3
1
1
1
2
3
4
3
2
PH-1
PH-1
PH-2
PH-2
PH-3
PH-3
KW
KVAR
KW
KVAR
KW
KVAR
38.47
0.00
0.00
0.00
0.00
19.23
38.47
19.23
38.47
0.00
0.00
0.00
38.47
38.47
0.00
0.00
38.47
38.47
0.00
0.00
0.00
38.47
0.00
38.47
38.47
0.00
19.22
0.00
0.00
0.00
0.00
9.61
19.22
9.61
19.22
0.00
0.00
0.00
19.22
19.22
0.00
0.00
19.22
19.22
0.00
0.00
0.00
19.22
0.00
19.22
19.22
0.00
0.00
19.23
0.00
0.00
0.00
0.00
9.61
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
19.23
0.00
0.00
0.00
0.00
38.47
0.00
0.00
0.00
0.00
0.00
0.00
9.61
0.00
0.00
0.00
0.00
19.22
0.00
0.00
0.00
0.00
0.00
38.47
19.23
38.47
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
19.23
0.00
0.00
0.00
9.61
0.00
0.00
38.47
19.23
0.00
0.00
0.00
38.47
0.00
0.00
38.47
19.23
19.23
0.00
38.47
0.00
0.00
0.00
0.00
19.22
9.61
19.22
0.00
0.00
0.00
0.00
0.00
19.22
9.61
0.00
0.00
0.00
19.22
0.00
0.00
19.22
9.61
9.61
0.00
19.22
0.00
0.00
0.00
(continued)
IEEE 123 BUS RADIAL DISTRIBUTION SYSTEM
BUS LOADS AS K W AND KVAR
BUS LOAD
NO. MDL.
39
41
42
43
45
4
47
4
49
50
51
52
53
55
56
58
59
6
62
63
6
65
66
68
69
70
71
73
74
75
76
77
I9
8
82
83
84
85
86
87
88
1
1
1
3
2
6 1
2
8 3
1
1
1
1
1
3
1
2
1
0 1
3
1
4 2
6
1
1
1
1
1
1
3
1
5
1
3
1
1
1
1
1
90
92
94
95
96
98
99
100
102
103
104
106
107
109
111
112
113
114
*Total*
1
1
1
2
1
1
1
1
1
1
3
1
1
1
1
1
1
1
2
3
1
PH-1
PH-1
PH-2
PH-2
PH-3
PH-3
KW
KVAR
KW
KVAR
KW
KVAR
0.00
19.23
0.00
0.00
0.00
0.00
34.19
68.38
34.19
38.47
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
38.47
0.00
0.00
68.38
76.93
0.00
0.00
0.00
0.00
38.47
38.47
38.47
68.38
0.00
0.00
0.00
0.00
19.23
19.23
38.47
0.00
0.00
0.00
0.00
38.47
0.00
0.00
0.00
0.00
0.00
38.47
19.23
38.47
38.47
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
9.61
0.00
0.00
0.00
0.00
26.46
52.91
26.46
19.22
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
19.22
0.00
0.00
52.91
38.44
0.00
0.00
0.00
0.00
19.22
19.22
19.22
52.91
0.00
0.00
0.00
19.23
0.00
19.23
19.23
34.19
68.38
34.19
0.00
19.23
38.47
38.47
19.23
0.00
0.00
0.00
19.23
0.00
38.47
0.00
34.19
0.00
19.23
38.47
19.23
38.47
0.00
0.00
0.00
102.57
0.00
38.47
0.00
38.47
0.00
0.00
0.00
0.00
0.00
38.47
0.00
0.00
38.47
0.00
0.00
38.47
0.00
0.00
0.00
0.00
0.00
0.00
0.00
38.47
19.23
19.23
38.47
19.23
0.00
0.00
9.61
0.00
9.61
9.61
26.46
52.91
26.46
0.00
9.61
19.22
19.22
9.61
0.00
0.00
0.00
9.61
0.00
19.22
0.00
26.46
0.00
9.61
19.22
9.61
19.22
0.00
0.00
0.00
79.37
0.00
19.22
0.00
19.22
0.00
0.00
0.00
0.00
0.00
19.22
0.00
0.00
19.22
0.00
0.00
19.22
0.00
0.00
0.00
0.00
0.00
0.00
0.00
19.22
9.61
9.61
19.22
9.61
19.23
0.00
0.00
38.47
0.00
0.00
34.19
68.38
68.38
0.00
0.00
0.00
0.00
0.00
19.23
19.23
19.23
0.00
0.00
0.00
76.93
34.19
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
68.38
38.47
0.00
38.47
0.00
0.00
0.00
0.00
19.23
38.47
0.00
38.47
0.00
0.00
19.23
19.23
0.00
38.47
0.00
0.00
0.00
0.00
38.47
38.47
0.00
0.00
0.00
0.00
0.00
9.61
0.00
0.00
19.22
0.00
0.00
26.46
52.91
52.91
0.00
0.00
0.00
0.00
0.00
9.61
9.61
9.61
0.00
0.00
0.00
38.44
26.46
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
52.91
19.22
0.00
19.22
0.00
0.00
0.00
0.00
9.61
19.22
0.00
19.22
0.00
0.00
9.61
9.61
0.00
19.22
0.00
0.00
0.00
0.00
19.22
19.22
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
9.61
9.61
19.22
0.00
0.00
0.00
0.00
19.22
0.00
0.00
0.00
0.00
0.00
19.22
9.61
19.22
19.22
0.00
0.00
0.00
0.00
0.00
0.00
0.00
l**l*****l**ltt***I***l.**;;*****~********;;**;;***;;;;;;**
1369.85 759.43
888.98
519.17 1119.8
634.49
980
5.
Substation
a. Three-phase short circuit MVA and
angle at the high voltage terminals
of the substation transformer.
b. Substation transformer ratings and
impedance.
c. Substation transformer output
voltages
6.
In-line
autotransformer
converting
feeder voltage from 24.9 kV to 4.16 kV.
Regulator Id: 1
Bus A: 150
Bus B:
1
Bandwidth Setting: 2.0 volts
Three-phase, wye connected, compensator
monitoring Phase A
Phase A
PT Ratio
CT Rating
R-Setting
X-Setting
Voltage Level
20.0
700.0
3.0
7.5
this
120.0
.............................................
Regulator Id: 2
Bus A:
9
Bus B: 14
Bandwidth Setting: 1.0 volts
Single-phase connected to Phase A
"B
Phase A
PT Ratio
CT Rating
R-Setting
X-setting
Voltage Level
20.0
50.0
0.4
0.4
120.0
Regulator Id: 3
Bus A: 25
Bus B: 26
Bandwidth Setting: 1.0 volts
Two single-phase connected A-N and C-N
PT Ratio
CT Rating
R-Setting
X-setting
Voltage Level
Phase A
Phase C
20.0
50.0
0.4
0.4
120.0
20.0
50.0
0.6
0.4
120.0
Regulator Id: 4
Bus A: 160
Bus B:
67
Bandwidth Setting: 2.0 volts
Three single-phase connected in wye
PT Ratio
CT Rating
R-Setting
X-setting
Voltage Level
Phase A
Phase B
20.0
300.0
0.6
1.3
124.0
20.0
300.0
1.4
2.6
124.0
Phase C
20.0
300.0
0.2
1.4
124.0
.............................................
Figure 3
IEEE 34 BUS RADIAL DISTRIBUTION FEEDER
2.
Load Types
a. Spot and distributed loads
b. All wye connected
c. All constant kW,kVAr
Line Types
a. Three-phase overhead
b. Single-phase overhead
(a-n, b-n and c-n)
3.
Voltage
Regulators
regulators wye connected
4.
Shunt Capacitors
34
The
substation transformer
feeder is rated:
serving
2 ,500 kVA
345 delta-24.9 grounded wye kV
z 3: 1.0 + j8.0 %
single-phase
- balanced three-phase
this
are
98 1
Table 8
T a b l e 10
BUS
B
800
802
806
808
808
812
814
816
816
818
820
824
824
828
830
832
832
834
834
836
836
842
844
846
850
852
854
854
858
858
860
8 62
888
802
806
808
810
812
814
850
818
824
820
822
826
828
830
854
858
888
860
842
840
862
844
846
848
816
832
856
852
864
834
836
838
890
LENGTH CONFIG.
CODE
(FT.1
2580.0
1730.0
32230.0
5840.0
37500.0
29730.0
10.0
1710.0
10210.0
48150.0
13740.0
3030.0
840.0
20440.0
520.0
4900.0
301
301
301
303
301
301
301
302
301
302
302
303
301
301
301
301
55
301
301
301
301
301
301
301
301
301
303
301
302
301
301
304
300
0.0
2020.0
280.0
860.0
280.0
1350.0
3640.0
530.0
310.0
10.0
23330.0
36830.0
1620.0
5830.0
2680.0
4860.0
10560.0
B
B
A
B
A
A C N
A C N
N
N
N
1/ 0
#2 6/1
#4 6/1
#4 6/1
#2 6/1
844
848
100.00
150.00
100.00
150.00
100.00
150.00
250.00
250.00
Total
........................
for this
PH-1
PH-1
PH-2
PH-2
PH-3
PH-3
KW
KVAR
KW
KVAR
KW
KVAR
15.94
7.09
106.83
15.57
21.62
19.91
8.86
133.44
19.45
27.00
15.94
7.09
106.83
15.57
21.62
167.05
208.66
167.05
19.91
8.86
133.44
19.45
27.00
19.91 15.94
7.09
8.86
133.44 106.83
19.45 15.57
27.00 21.62
1
1
1
1
t*****titt*b*****b**t*t***l*t*.***tt*...*bb**
208.66 167.05
208.66
500
500
510
510
510
806
810
820
822
824
826
828
830
856
858
864
834
836
862
842
844
846
840
838
844
846
848
860
860 836
KVAR
PHASE C
T a b f e 11
NEUTRAL
COND SPACING
ACSR
ID
1/0
#2 6/1
#4 6/1
#4 6/1
#2 6/1
WAR
Table 11
system.
Table 9
300
301
302
303
304
PHASE B
250.00
PHASE A
KVAR
***
CONF
ID PHASING
BUS
NO.
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
PH-1
PH-1
K W KVAR
0.00
0.00
33.90
135.53
0.00
0.00
0.00
6.18
0.00
6.68
0.63
3.99
15.66
27.37
17.49
27.61
9.12
0.00
0.00
0.00
17.52
70.07
0.00
0.00
0.00
3.20
0.00
3.45
0.33
2.06
8.09
14.15
9.04
14.27
4.71
0.00
PH-2
PH-2
PH-3
PH-3
K W KVAR K W
KVAR
13.48
0.00
0.00
0.00
0.00
0.00
1.44
0.00
0.00
2.77
0.00
6.63
57.46
21.74
0.00
0.00
0.00
11.49
Data
for
is
982
Regulator Id: 1
Bus A: 814
Bus B: 850
Bandwidth Setting: 2.0 volts
Three single-phase connected in wye
Phase A
120.0
PT Ratio
CT Rating
R-Setting
X-Setting
Voltage Level
Phase B
120.0
100.0
7.4
4.2
124.0
100.0
4.2
6.2
124.0
b.
c.
Phase C
120.0
100.0
9.6
4.6
124-0
-____-_^__--__--__---------------------------
Phase A
120.0
100.0
2.1
1.2
124.0
Phase B
120 * 0
100.0
2.1
1.2
124.0
and
6. Motor
a. step-down transformer
b. Starting kVA and power factor given
c. Running power factor
The
substation
feeder is rated:
Regulator Id: 2
Bus A: 852
Bus B: 832
Bandwidth Setting: 2.0 volts
Three single-phase connected in wye
PT Ratio
CT Rating
R-Setting
X-Sett ing
Voltage Level
transformer
serving
this
5,000 kVA
115 delta-4.16 grounded wye kV
Z = 1.0 + j8.0 %
Phase C
120.0
100.0
2.1
1.2
124.0
this
are
32
33
33
45
50
52
Figure 4
71
71
71
75
84
92
BUS
B
LENGTH
(FT.)
CONFIG.
CODE
45
32
34
46
32
84
32
84
150
92
911
71
500.0
500.0
503
502
507
503
501
509
501
504
501
508
0.0
300.0
2000.0
800.0
2000.0
300.0
1000.0
500.0
300.0
505
506
0.0
2. Line Types
a. Three-phase overhead & underground
b. Single-phase overhead & underground
3. Voltage
Regulators
regulators wye connected
4.
single-phase
shunt Capacitors
a. Balanced three-phase
b. Single-phase
5. Substation
a. Three-phase short circuit W A and
angle at the high voltage terminals
of the substation transformer.
CONF
ID
501
502
503
504
505
PHASING
B
C
C
A
C
A
A
B
C
N
C N
B N
N
N
PHASE
COND
ACSR
556,500 26/7
4/0 6/1
NEUTRAL
COND SPACING
ACSR
ID
4/0
6/1
I/ 0
4/0 6/1
I/ 0
1/ 0
1/ 0
1/ 0
1/ 0
500
500
505
505
510
Table 17
three-phase
transformer
32 71
*TOT&
500 kVA
4160 delta - 480 wye volts
Z = 1.1 + j2.0%
PH-1 PH-1
KW KVAR
16.48
A
single-phase
l
(
0
copper
tape
shielded conductor with a separate 1/0
copper bare peutral. The cable and
bare neutral are buried 40 inches
below ground with a 1.0 inch spacing
between centers.
9.45
67.05
**8*8tli88t8**88***88888*88*88*8**l.****8*******88***8*
16.48
underground
508 - Three-phase
1ine
consisting of three 250,000 CM, AL
concentric
neutral
cables.
The
cables are spaced 6 inches apart on a
horizontal
plane 40 inches
below
ground.
The
concentric
neutral
consists of 13-#14 copper conductors.
The outside diameter of the cable
(over the concentric neutral) is 1.28
inches.
509
9.45
67.05
is
Regulator Id: 1
Bus A: 50
Bus B: 32
Bandwidth Setting: 2.0 volts
Three single-phase connected in wye
PT Ratio
CT Rating
R-Setting
X-Setting
Voltage Level
Phase A
20.0
700.0
3.0
9.0
122.0
Phase B
20.0
700.0
3.0
9.0
122.0
Phase C
20.0
700.0
3.0
9.0
122.0
for
The circuit diagram (not to scale) for
feeder is shown in Figure 5.
this
Table 15
PHASE A
75
911
200.00
***
KVAR
Total . . .
200.00
PHASE B
KVAR
PHASE C
KVAR
200.00
200.00
100.00
. . . . . . . . . . . . . . . . . .
200.00
300.00
Data
for
this
Table 16
IEEE 13 BUS RADIAL DISTRIBUTION SYSTEM
BUS LOADS AS KW AND KVAR
BUS LOAD
NO. MDL.
PH-1
KW
34
45
46
52
71
75
92
911
*Total
42.63 20.18
0.00
0.00
1
1
6
3
4
1
5
2
0.00
PH-1
KVAR
0.00
127.90 85.79
383.70 219.95
486.02 189.07
0.00 0.00
0.00 0.00
PH-2
KW
0.00
PH-2
KVAR
0.00
170.53
230.22
0.00
383.70
68.21
125.09
131.97
0.00
219.95
60.55
0.00
0.00
0.00
0.00
PH-3
KW
PH-3
KVAR
0.00
0.00
0.00
0.00
0.00
0.00
383.70
289.91
170.53
170.53
.:-
0.00
0.00
219.95
212.65
151.38
80.74
8*8*8*88*8888*88*88*i**8***888*8**88*88***88**88***88*:8
1040.25 514.99
Table
Loads.
852.66
537.56 1014.67
664.72
Distributed
Figure 5
984
T a b l e 18
2.
Load Types
a. Delta connected spot loads
b. Mixture of constant kW,kVAR,
constant 2 and constant I.
Line Types
underground
All
three-phase
(conthued)
voltage
Regulators
single-phase
regulators open-delta connected
4.
No Shunt Capacitors
5.
Substation
a. Three-phase short circuit MVA and
angle at the high voltage terminals
of the substation transformer.
b. Substation transformer ratings and
impedance.
c. Substation transformer output
voltages
6.
Motor
a. Step-down transformer
b. Starting kVA and power factor given
c. Running power factor
2 ,500 kVA
230 delta-4.8 delta
Z = 2.0 + j8.0 %
BUS
B
LENGTH
(FT.)
CONFIG.
COPE
8
9
9
10
10
11
11
13
14
20
20
27
30
33
34
34
37
38
44
44
75
99
32
31
8
35
36
41
40
4
18
7
6
44
9
34
37
10
38
11
28
29
9
320.0
600.0
320.0
200.0
1280.0
400.0
200.0
520.0
520.0
920.0
600.0
280.0
200.0
560.0
640.0
520.0
400.0
325
323
323
325
325
323
325
323
325
325
323
325
323
323
323
325
323
323
325
325
10
321
delta
3.
The
substation transformer
feeder is rated:
BUS
A
serving
this
400.0
200.0
280.0
1.0
1850.0
Table
19
gives
the
Underground
Configuration Codes for this system.
Line
kV
T a b l e 19
are
CONF
ID
PHASING
321
322
323
325
A
A
A
A
B C
B C
B C
B C
AA
1000 KCM
500 KCM
2/0
#2
CONCENTRIC
NEUTRAL
COPPER
20
16
7
10
#lo
#12
#14
#14
SPACING
ID #
321
322
323
325
T a b l e 18
T a b l e 20
BUS
B
LENGTH
(FT.)
CONFIG.
CODE
1
2
2
2
3
3
4
4
5
5
6
7
7
8
2
5
13
3
27
30
14
20
42
12
25
24
22
33
960.0
400.0
360.0
1320.0
240.0
600.0
80.0
800.0
320.0
240.0
280.0
760.0
120.0
320.0
322
325
323
322
325
323
325
323
325
325
325
325
325
323
A-B
B-C
C-A
(Inch) (Inch) (Inch)
2.074
1.603
1.146
1.030
2.074
1.603
1.146
1.030
2.060
1.570
1.120
0.970
Three-phase
500 kVA
transformer rated:
4,800 delta
480 delta volts
= 0.85 + jl.81 %
985
Data
for this
Table 21
IEEE 37 BUS DELTA RADIAL DISTRIBUTION SYSTEM
BUS LOADS AS K W AND KVAR
BUS LOAD
NO. MDL
PH-1
PH-1
PH-2
PH-2
PH-3
PH-3
KW
KVAR
KW
KVAR
KW
KVAR
69.74 350.75
1
4
140.47 69.74 140.47
0.00
84.11
0.00
0.00
0.00
12
4
0.00
84.11
0.00
13
4
0.00 0.00
10.44
0.00
14
5
16.82 8.35
21.03
0.00
0.00
0.00
18
6
84.11 41.76
0.00
84.11
0.00
0.00
0.00
20
4
69.74
21.03
22
5
0.00 0.00 140.47
0.00
20.88
42.06
24
6
0.00 0.00
0.00
42.06
20.88
25
4
0.00 0.00
0.00 0.00
0.00
0.00
42.06
21
4
20.88
42.06
42.06
28
4
42.06 20.88
0.00
0.00
0.00
29
5
4B.06 20.88
0.00 0.00
0.00
0.00
84.11
30
6
41.76
0.00
0.00
84.11
31
6
0.00
0.00
0.00
42.06
0.00
0.00
32
4
0.00
0.00
0.00
33
5
84.11 41.76
0.00
42.06
34
4
0.00
0.00
0.00
0.00
0.00
84.11
0.00 0.00
35
4
20.88
0.00
0.00
0.00
42.06
36
6
37
5
140.47 69.74
0.00
0.00
0.00
0.00
0.00
38
4
126.17 62.64
0.00
0.00
84.11
40
4
0.00
0.00
0.00
42.06
0.00 0.00
0.00
0.00
41
5
0.00
42
6
8.41 4.18
84.11
41.76
4 4 4
42.06 20.88
0.00
0.00
0.00
*Total * * * * * * * i * * * t * * * i i * * t I . * * . i * * * t * * . . * * t . l * * * * * * * * * *
726.74 360.81 638.43 316.% 1086.74
174.!5
41.76
41.76
0.00
0.00
41.76
10.44
0.00
0.00
20.88
20.88
0.00
41.76
0.00
20.88
0.00
20.88
41.76
0.00
0.00
0.00
41.76
20.88
0.00
0.00
539.55
is
Regulator Id: 1
Bus A: 99
Bus B: 1
Bandwidth Setting: 2.0 volts
Two single-phase connected in open-delta
compensator controlled
Phase A
PT Ratio
CT Rating
R-Setting
X-setting
Voltage Level
Phase C
40.0
40.0
350.0
350.0
1.0
0.4
122.0
0.2
0.9
122.0
CONCLUSIONS
The
complete data
for
four
radial
distribution feeders has been
presented.
Developers of radial distribution analysis
programs are encouraged to use these feeders
to test their programs and to compare the
results with the results from other programs.