Beruflich Dokumente
Kultur Dokumente
Applicability
Introduction
Some customers may complain that the glove box may fall down after servicing the HVAC air cabin
filter. The instrument panel pin can become damaged during the removal/installation process
creating a condition where the damper does not seat properly. The following service procedure has
been provided for successful removal/installation of the glove box.
Warranty Information
Removal Procedure
1 Stopper
Installation
1. Pull the bottom of the dampener out until the clip Figure 4.
hole is visible.
1 Protective Tape
2 Stubby flate-blade screwdriver
2. Insert the tip of a Stubby flat-blade screwdriver into the clip hole to prevent the piston of the
dampener from retracting.
NOTE
Tape the screwdriver tip before use.
NOTE
• Always pull out the plunger and lock it in the extended position before installation
• Do not install the dampener to the instrument panel and then pull out the plunger. This will
cause the pin on the instrument panel to become weak or break
1 Stopper