Beruflich Dokumente
Kultur Dokumente
Removal
1. Detach the power steering fluid expansion tank from the wheelhouse panel and position it to one side.
3. Start the engine and turn the air conditioning (A/C) switch to the ON position. 4. NOTE: Make sure that the A/C compressor runs
during low-pressure cutoff switch removal. Connect a 20 A fuse rated jumper wire between Pin 1 and Pin 4, harness side, of the low-pressure cutoff switch electrical connector.
5.
WARNING: Make sure that the low-pressure cutoff switch valve closes completely after removal of the low-pressure cutoff switch to prevent loss of refrigerant. Failure to follow this instruction may result in personal injury. Remove the low-pressure cutoff switch. Discard the O-ring seals.
Installation
1. NOTE: Install new low-pressure cutoff switch O-ring
1 of 2
7/18/2009 10:52 PM
http://127.0.0.1:8888/wsm/js/procedure.do?variantId=361&proc-uid=...
seals with clean refrigerant oil prior to installation. To install, reverse the removal procedure.
2 of 2
7/18/2009 10:52 PM