Beruflich Dokumente
Kultur Dokumente
Increase in
net head by establishing a negative head at theturbine outlet Converts a large proportion of ke rejected at the outlet into pressure energy Without a draft tube, the pressure at the outlet of the turbine will be equal to the atm pressure. Draft tube increases efficiency
Excitor
DC System
at Idamalayar Power Station A 220V dc system for the Units & 110kV Feeders A 110V dc system for the 66kV IMKM feeder A 48V dc system for the PLCC systems A 24V dc system for the 11kV OD CBs
of
the
UATs
Industries
1),
RY2692/2(UAT
- Type
of
Cooling:
SN,
Frequency:
50Hz
- Impedance: - Tap
Winding:
RY2692/1(UAT
1),
RY2692/2(UAT
2), RY2692/3(Standby)
- Type
of
Cooling:
4.86%, Off and
SN,
Vector Load Winding:
Frequency:
Group:
50Hz
DYn11
1270kg
- Weight
2578kg,
of
Year:
Oil:
1980,
596kg,
Tmax:
Total
45C
Weight:
LA-SC Cubicle
Generator Breakers
- Closing Time
- Opening Time - Dead Time
Generator Breakers
- Closing Time
- Opening Time - Dead Time
Generator Breakers
- Closing Time
- Opening Time - Dead Time
Generator CTs
- Duct CTs
- No of Cores and Spec.
Generator PTs
Generator PTs
Generator Isolators
Generator Isolators
- No CB here
110/66kV Transformer
110/66kV Transformer
110/66kV Transformer
Earth
Mat in
the
Yard
Protections:
Of
the
Machine
Of
the
Feeders
Of
the
Transformers
Start/Stop
Sequence
Relays
for
the
Start/Stop
sequencing
Fire
Protection
Systems
CO2
Flooding
System
for
Generator
Stator
Water
Deluge
system
for
the
GTs
CO2
portable
cylinders
AFFF
portable
cylinders
DCP
portable
cylinders
Cooling -
in Heat
for
the
Lubrication:
CGLU Ejector Works units Servomotors, Guide vane Pump: with from shaft Sealing: not Pelton for medium and high heads? the the seal serves bushings lubrication etc. needs of the
Ventury
principle,
clears
the
water
leakage
side
Oil
Filtering
Units
OPUs
OPU
pumps
redundancy
AOT
HP/LP
Air
Compressor
Systems
Redundancy
Drainage Leakage
Water Collector
Oil bearings
Pump
Pumps
for
removing
the
leakage
oil
from
these
collectors
Measurement
Instrumentation
System:
Condition
Monitoring
RTDs/TSDs
for
temp
measurement
Rotor
temp
measurement
Permit
to
Work
on
Machines/Feeders/Other
Equipments
AVR
Thyristor
Panels
Redundancy
Regulation
Cubicle
Vacuum
Air
Spirng/Air
for
Close
Open
Thrust
bearing Beaing
pads
Russian
design
Pin
type
Thrust
(Kingsbury
Pins)
Semi
Umbrella
advantage
Minimization
of
Iron
cost
Mattress
type
pads
HPOP
system
Jacking
Up
of
Rotor
Necessity
Min
Continous
Operating
Speed
Braking
Brake Saves
lifts due
the to
rotor the
Power
Distribution
for
no
issue
Mode/Condenser mode
Startup
Normal
Spin Generator Generator
Spinning Reserve?
Shutdown
Controlled Action Initiated turbine generator Once initiated vanes/jets GCB control) If trip failed. Initiated Initiated Operates simultaneously Guidevanes/Jets FB opened. If trip
& -
is the no
(Nothing is dont close/GCB time, Controlled Action SHutdown controlled electrical Closing action & Valve
listed happen
are tripping
closed is
very done
Guide in
vanes preset
and is
FB initiated
dont
Catastrophic
Shutdown catastrophic
Or Controlled Action/Emergency SHutdown program fails Commands given to simulataneously close MIV, to Open Emergency