Beruflich Dokumente
Kultur Dokumente
VIEW ASSEMBLY VIDEO AND INSTRUCTION MANUAL AT www.zhengteusa.com Before assembly, read these instructions carefully. Assemble the canopy in the location where you intend to use it. 2 or more people are recommended for assembly.
WARNING: Keep all flame and heat sources away from this canopy fabric.
This canopy is meant for vehicle / boat storage and should bot be used for public gatherings. Please check with your local regulations prior to purchasing this item. Some municipalities have restrictions and requirements. This canopy should not be used during heavy wind, ice, or snow conditions. The accumulation of snow and ice on canopy roof may pose a safety concern. Under severe weather conditions, disassemble your canopy and store indoors. It is strongly recommended that the canopy remain secure to the ground at all times via the base plates and nylon straps supplied. Avoid placing the unit on soft ground and ground that is prone to flooding. MADE IN CHINA For parts or customer service, please call 1-800-867-9018 or email: service @ zhengteusa.com Monday - Friday, 8:30 am - 4:30 pm Pacific Time
1
PARTS LIST
PART A B C C1 D E F G H I J K L M N O P Q R S T U V DESCRIPTION Incline Bar Horizontal Bar Post Post 1 3-Way Corner 4-Way Corner Awning Arm Awning Front Girder Bolt (M6X16mm) Bolt (M6X30mm) Pin Base Plate Bolt & Nut Canopy Roof Side Panel with Door Side Panel without Door End Panel End Panel Elastic Ball Strap Ground Stake Nylon Stap Allen Wrench Expansion Bolt ILLUSTRATION QUANTITY 8 9 6 2 6 6 2 1 4 2 2 8 8 1 1 1 1 1 50 12 4 1 8
NOTE: INCLINE BARS (A) ARE PACKED INSIDE POSTS (C) AND (C1).
2
There are hooks attached to the four corners of the canopy roof (M). Insert these hooks into the pre-drilled holes on the four corner posts (C). See diagram below.
BASE PLATE ASSEMBLY Insert base plates (K) on to the bottom of the posts (C) and secure using the nuts and bolts (L).
FINAL ASSEMBLY
1. Remove hooks from the corner posts. 2. Secure adjacent panels with hook and loop fasteners on edge of each panel.
3. Secure panels to the posts with the 3 hook and loop fasteners attached to the side panels.
4. Insert the hooks into the pre-drilled holes at the bottom of each post (C, C1).
5. Insert the elastic ball strap (R) through the grommet in the end panel, through the grommets in the roof canopy corner, then through the side pabel grommet. Stretch the elastic band over the ball.
AWNING ASSEMBLY
Attach awning arms (F) to the posts (C1) using bolts (H). See diagram below. Connect fabric fasteners on the roof (M) with the fabric fasteners on the side panels (N, O).
Step 1
Step 2
Step 3
Step 4
Step 5
Step 6
Step 7