Beruflich Dokumente
Kultur Dokumente
~
LK 66071.9fD45 rev D
-~
2VO4VO2 5 /
";Ii' .
The safety valves are designed according to the ASME code. All the safety valves are set in workshop by the manufacturer. The steam safety valves which are according to ASME I have to be tested on site. The set popping, the accumulation ~nd the blow down of these safety valves have to be calculated under the real operating conditions. The steam safety valves have two rings for the here-above mentioned calibration.
The steam safety valves at the superheater o~tlet must always open prior to the safety val ves on the drum.
Accumulation: full opening of the safety valve Set pressure: popping of the safety valve Blow down: closing of the valve once opened
"""
~LWF0000
.' j
/.
~LWF0000
4 I :P superheater outlet
~-
~102
5
!ii'4~
IP SAFETY VAL VES SET PRESSURE r IF drum .4 Reheater in!et ~14 R~heater~t~et .
GT loQo/c Tamb: 15;'
~LWF0000
~LWF0000