Sie sind auf Seite 1von 28

Distributed by: www.minilablaser.

com

Distributed by: www.minilablaser.com

INTRODUCTION

This Servicing Manual outlines the maintenance and servicing procedures for the Multi-film Carrier MFC10Y of the Fujifilm Digital Minilab FRONTIER 350/370 SP1500/SP2000 and LP1500SC/LP2000SC. This manual is a professional publication provided for qualified service personnel or persons fully trained in equipment service procedures. All other personnel and operators are restricted from servicing the MFC10Y. When maintenance service is needed, be sure to contact qualified service personnel.
Precautions Generally Applying to All Servicing Operations ! WARNING When servicing internal machine parts, make sure the power switch and the main power supply on the power distribution board are both set to the OFF position. If the main power is left ON, electricity will flow as far as the power switch and power supply section, and this can cause electric shocks and/or short-circuiting. If the power is left on, there is also the possibility for the machine to be accidentally activated causing damage to the machine and/or bodily injury. ! CAUTION The light source section and dryer will be hot to the touch. Wait 15 minutes after turning off the power before commencing with servicing procedures. Wear gloves when handling the optical system parts to keep the parts free from fingerprints. When mounting machine parts, take care not to sandwich any of the wires. Each of the connectors is provided with a symbol indicating what it is to be connected to. Make sure the connectors are connected to connectors, harness ends or parts bearing the corresponding symbols. The plastic connectors have a locking catch on the plug (male) end. To disconnect one of these connectors, loosen the catch first; when connecting, make sure the catch engages (locks).

Service Manual Appropriations 1. All rights are reserved by the Fuji Photo Film Co., Ltd. (FUJIFILM). 2. Manual usage is restricted to FUJIFILM equipment-related technical and service personnel. 3. This manual contains exclusive information relating to FUJIFILM equipment and is therefore proprietary. Unauthorized disclosure is prohibited. 4. FUJIFILMs prior consent is required in regard to the following.
K K K

Manual copying in whole or in part. Disclosure of manual contents to unauthorized personnel. Manual uses for purposes other than technical service.

Distributed by: www.minilablaser.com

Contents

Contents

1. Installation .................................................................................................................................................. 2
1.1 1.2 1.3 1.4 Film Carrier MFC10Y Registration (Menu 44P) ................................................................................... 2 Carrier Focus Position Adjustment (Menu 43C) ................................................................................... 2 MFC10Y Monitor Image Position Adjustment (Menu 44H) .................................................................. 3 Scanner Correction (Menu 13) ............................................................................................................. 3

2. Main Specification and Outline .......................................................................................................... 5


2.1 2.2 Main Specifications .............................................................................................................................. 5 Outline .................................................................................................................................................. 5 2.2.1 MFC10Y External View ................................................................................................................ 5 2.2.2 MFC10Y Internal View ................................................................................................................. 6 2.2.3 Film Mask Sensor Matrix ............................................................................................................. 6 2.2.4 CYA20 Circuit Board .................................................................................................................... 7

3. Operation Sequences ............................................................................................................................. 8


3.1 3.2 3.3 3.4 3.5 3.6 3.7 Normal Operation Sequence ................................................................................................................ 8 MFC10Y Installation Sequence ............................................................................................................ 9 Cleaning and Scanner Correction Sequence ..................................................................................... 10 Pre-scanning and AF Sequence ........................................................................................................ 11 Fine-scanning Sequence ................................................................................................................... 12 Scanning Completion Sequence ........................................................................................................ 12 Film Feed Sequence .......................................................................................................................... 13

4. Maintenance Menu ................................................................................................................................ 14


4.1 4.2 4.3 4.4 MFC10Y I/O Check (44G) .................................................................................................................. 14 MFC10Y Monitor Image Position Adjustment (44H) .......................................................................... 14 MFC10Y Machine Data Setup (44S) .................................................................................................. 16 MFC10Y Working Information (44L) .................................................................................................. 16

5. I/O Parts Location .................................................................................................................................. 18 6. Parts Replacement and Adjustment .............................................................................................. 19


6.1 6.2 6.3 6.4 6.5 6.6 6.7 6.8 6.9 6.10 6.11 6.12 6.13 6.14 6.15 6.16 6.17 6.18 6.19 6.20 6.21 Film Feed Roller Replacement ........................................................................................................... 19 Film Press Roller Replacement .......................................................................................................... 19 Front Cover Removal/Reinstallation .................................................................................................. 19 Keyboard Circuit Board (D487 to D490) Replacement ...................................................................... 19 Feed Section Cover Removal/Reinstallation ...................................................................................... 19 Film Feed Motor Section Cover Removal/Reinstallation .................................................................... 20 SSD20 Circuit Board (Indicator Lamp L481/Film Slider Home Position Sensor D485) Replacement ....... 20 Film Slider Opening/Closing ............................................................................................................... 20 MSB20 Circuit Board (Film Mask Sensors D480 to D484) Replacement .......................................... 21 Film Feed Gear Bracket Replacement ............................................................................................... 21 Film Pressure Solenoid (S480) Replacement .................................................................................... 21 Front Guide Shaft/Guide Bushing/Seal Replacement ........................................................................ 22 Film Slider Removal/Reinstallation .................................................................................................... 22 Rear Guide Shaft/Guide Bushing/Seal Replacement ........................................................................ 22 Back Light (L480) Replacement ......................................................................................................... 23 Film Feed Motor (M481) Replacement .............................................................................................. 23 Circuit Board Section Cover Removal/Reinstallation ......................................................................... 24 CYA20 Circuit Board Replacement .................................................................................................... 24 Plug-in Connector Replacement ........................................................................................................ 24 Film Slider Feed Motor Drive Circuit Board Replacement ................................................................. 24 Film Slider Feed Motor (M480) Assembly/Film Slider Feed Thread Shaft/ SSJ20 Circuit board (Film Slider Stop Sensor D486) Replacement ........................................... 25 6.22 Diffusion Plate Replacement .............................................................................................................. 26

Distributed by: www.minilablaser.com

1. Installation 1. Installation

1.1

Film Carrier MFC10Y Registration (Menu 44P)

5. Install the glare shield to the scanner section as shown.

1. Start up the SP1500/SP2000. 2. Install the film carrier MFC10Y without the mask.
Rail

Glare Shield

EZ1440

Mark

1.2
EZ1439

Carrier Focus Position Adjustment (Menu 43C)

Multi-film Carrier MFC10Y

The error message E-1119 Focus position adjustment for each carrier not performed. Call a technical representative. appears. 3 . Open the [44P] Film Carrier ID Setup/Delete screen. The Carrier ID and Carrier Type are displayed in the Installed carrier box automatically.

1. Install the mask on the carrier, insert the film and align it with the mask.
Mask

Film
EZ1445

2. Open the [43C] Carrier Focus Position Adjustment screen.

4. Click [Backup]. The carrier data are saved from the carrier into the hard disk in the main control unit as a backup file. After completion of saving, the carrier ID and type are listed in the Backup completion carrier box..

Distributed by: www.minilablaser.com

1. Installation

3. Click [Run]. The message Load the film appears.

1.4

Scanner Correction (Menu 13)

1. Open the [13] Scanner Correction screen of the 1 Preoperational Check menu.

4. Insert a good focused film in the film mask. 5. Click [OK]. The focus position is adjusted and adjustment value is displayed. The message Focus position adjustment is completed appears and the [Run] button is changed to the [Regist] button. 6. Click [Regist]. Operation returns to the 4 Setup and Maintenance screen. 7. Repeat steps 1 to 6 for all masks to be used. 2. Click [OK]. The message I-1490 appears.

1.3

MFC10Y Monitor Image Position Adjustment (Menu 44H)

Perform menu 44H MFC10Y Monitor Image Position Adjustment for all masks to be use (see section 4.2).

3. Click [Clean]. The film slider modes to the diffusion plate cleaning position. The message I-1491 appears.

Distributed by: www.minilablaser.com

1. Installation

4. Remove the carrier and clean the upper and lower surfaces of the diffusion plate using the blower brush.
Diffusion Plate Upper Surface

After the completion of the correction, the [Skip] button is changed to the [End] button.

Blower Brush
EZ1442

Diffusion Plate Lower Surface

Blower Brush

7. Click [End]. 8. Skip the pre-operational check menu and return to the main menu screen.

EZ1443

5. Reinstall the carrier. 6. Click [End]. The message disappears. The scanner correction is automatically started.

Distributed by: www.minilablaser.com

2. Main Specification and Outline 2. Main Specification and Outline

2.1
Type

Main Specifications
Item Reciprocating film slider 135, 240, 110, 126, 120, 220 Reversal film and negative film 135F, 135P, 135HV, 135H, 240, 135/240 mount (135 and 240 are changed by replacing switch button.), 64.5, 66, 67, 68, 69, 110, 126 Specifications

Film size Film type Film mask

2.2
2.2.1

Outline
MFC10Y External View

Feed Section Cover

Mark

Circuit Board Section Cover Film Feed Motor Section Cover

Indicator Lamp (L481) Front Cover

Film Slider

Keyboard Circuit Board (D487 to D490) D487: Right-hand Frame Adjustment Key D488: Right-hand Frame Feed Key D489: Left-hand Frame Feed Key D490: Left-hand Frame Adjustment Key

EZ1390

Distributed by: www.minilablaser.com

2. Main Specification and Outline

2.2.2

MFC10Y Internal View

Film Slider Feed Motor (M480) Film Slider Stop Sensor (D486)

Plug-in Connector

Film Slider Feed Motor Drive Circuit Board

Film Slider Feed Thread Shaft

Film Pressure Solenoid (S480)

Film Slider

Rear Guide Shaft

Back Light (L480)


5 4 3 2 1

CYA20 Circuit Board

Film Feed Motor (M481) Film Slider Home Position Sensor (D485) Indicator Lamp (L481) Film Mask Sensors 1 to 5 (D480 to D484) Diffusion Plate Front Guide Shaft

EZ1391

2.2.3

Film Mask Sensor Matrix


Film Mask Sensors 1 (D480) ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON 2 (D481) 3 (D482) 4 (D483) 5 (D484)

Film Mask 110 240 135F 135H 135P 135HV 126 135/240M 64.5 66 67 68 69

ON: Sensor (Micro Switch) ON

Distributed by: www.minilablaser.com

2. Main Specification and Outline

2.2.4

CYA20 Circuit Board


Check Points TP2 (+5V) to TP14 (DGND) TP7 (+24V) to TP6 (PGND)

Power Supply +5V +24V

ALTERA

EZ1723

Distributed by: www.minilablaser.com

3. Operation Sequences 3. Operation Sequences

3.1

Normal Operation Sequence


The SYSTEM START switch is pressed.

Light source and optical system initialization Is the MFC10Y installed? Is the MFC10Y installed? Yes No Yes

No

MFC10Y is removed.

MFC10Y Installation Sequence

MFC10Y Installation Sequence

Is pre-operational check started? Yes Mask should be removed.

No

Cleaning and Scanner Correction Sequence No (D480 to D484 are OFF.) Is the mask installed? Yes (Some D480 to D484 are ON.) L480 lights up L480 goes OFF

Is pre-scanning indicated? (Main control unit side) Yes

No No (D487 to D490 are not pressed.) Is film feed indicated?

Pre-scanning and AF Sequence

Yes (One of D487 to D490 is pressed.) Film Feed Sequence

Is printing indicated? (Main control unit side) Yes Fine-scanning Sequence

No

Is canceling indicated? (Main control unit side) Yes

No

Scanning Completion Sequence

Distributed by: www.minilablaser.com

3. Operation Sequences

3.2

MFC10Y Installation Sequence


START

L481 lights up (Red). EEPROM read out. L480 goes OFF.

No (D485 transparent) Is home position sensor turned ON. Yes (D485 shading) M480: clockwise (40mm/sec) 14.0mm Excitation OFF after movement
Film slider stop sensor is observed during movement. No OFF to ON change within 3mm (D486 transparent or shading)

No (D485 shading) Is home position sensor OFF? Yes (D485 transparent) M480: counterclockwise (40mm/sec) 18.2mm
Go to the next step without stopping the M480 if the home position sensor changes to ON during movement (D485 shading). Home position sensor does not change to ON (D485 transparent). Home position sensor does not change to ON (D485 transparent).

M480: counterclockwise (40mm/sec) 165.62mm


Film slider stop sensor is observed during movement. No OFF to ON change within 3mm (D486 transparent or shading)

M480: excitation OFF L481: blinks (Red) Error E-1233

Film slider stop sensor is observed during movement. No OFF to ON change within 3mm Home position sensor changes to ON (D486 transparent or shading). during movement (D485 shading).

M480: clockwise (40mm/sec) 6.0mm fine adjustment value Excitation OFF after movement Mask set position

Film slider stop sensor is observed during movement. No OFF to ON change within 3mm (D486 transparent or shading)

Is mask installed? Yes (Some of D480 to D484 are ON) L480 lights up No (D480 to D484 are OFF.)

M480: excitation OFF L481: blinks (Red). Error E-1240

Sequence completed normally.

Distributed by: www.minilablaser.com

3. Operation Sequences

3.3

Cleaning and Scanner Correction Sequence


START

No Is diffusion plate cleaned? Yes M480: clockwise (50mm/sec) 55.0mm Excitation OFF after movement Diffusion plate cleaning position Clean diffusion plate and press [OK] button.
Home position sensor does not change to ON (D485 transparent). Film slider stop sensor is observed during movement. No OFF to ON change within 3mm (D486 transparent or shading)

Home position sensor does not turn OFF after 14mm movement (D485 shading).

M480: clockwise (50mm/sec) (40mm/sec if carrier is removed and reinstalled) 165.62mm


Go to the next step without stopping the M480 if the home position sensor changes to ON during movement (D485 shading).

M480: excitation OFF L481 blinks (Red) Error E-1233

Film slider stop sensor is observed during movement. No OFF to ON change within 3mm (D486 transparent or shading)

M480: clockwise (50mm/sec) (40mm/sec if carrier is removed and reinstalled) 6.0mm fine adjustment value Excitation OFF after movement Mask set position

Film slider stop sensor is observed during movement. No OFF to ON change within 3mm (D486 transparent or shading)

M480: clockwise (50mm/sec) 45.0mm Excitation OFF after movement Scanner correction position Scanner correction is performed.

Film slider stop sensor is observed during movement. No OFF to ON change within 3mm (D486 transparent or shading)

Home position sensor does not turn OFF after 14mm movement (D485 shading)

M480: counterclockwise (50mm/sec) 165.62mm


Go to the next step without stopping the M480 if the home position sensor changes to ON during movement (D485 shading).

Home position sensor does not change to ON (D485 transparent).

M480: excitation OFF L481 blinks (Red) Error E-1233

Film slider stop sensor is observed during movement. No OFF to ON change within 3mm (D486 transparent or shading)

First time completed.

M480: counterclockwise (50mm/sec) 6.0mm fine adjustment value Excitation OFF after movement

Film slider stop sensor is observed during movement. No OFF to ON change within 3mm (D486 transparent or shading)

Mask set position

Second time completed. M480: excitation OFF L481 blinks (Red) Error E-1240

Sequence completed normally.

10

Distributed by: www.minilablaser.com

3. Operation Sequences

3.4

Pre-scanning and AF Sequence


START

L480 goes OFF. S480: ON (except mount mask) Waiting 0.2 sec to stabilizing Pre-scanning M480: clockwise (40 or 50mm/sec) Speed and movement are depend on kind of mask. L481 lights up (Green) during moving scanning range. Exciting OFF after movement
Film slider stop sensor is observed during movement. No OFF to ON change within 3mm (D486 transparent or shading)

Home position sensor does not turn OFF after 14mm movement (D485 shading)

Moving to standard AF position M480: counterclockwise (50mm/sec) Movement depends on kind of mask. Moving to center of mask opening Excitation OFF after movement

M480: excitation OFF S480: OFF L481 blinks (Red) Error E-1233

Film slider stop sensor is observed during movement. No OFF to ON change within 3mm (D486 transparent or shading)

Auto Focusing

Does AF succeed? Yes

No

M480: clockwise (50mm/sec) 5.0mm

Film slider stop sensor is observed during movement. No OFF to ON change within 3mm (D486 transparent or shading)

Auto focusing again Moving to pre-scanning end position M480: clockwise (50mm/sec) Movement depends on kind of mask. Moving to pre-scanning end position Excitation OFF after movement

Film slider stop sensor is observed during movement. No OFF to ON change within 3mm (D486 transparent or shading)

Sequence completed normally.

M480: excitation OFF S480: OFF L481 blinks (Red) Error E-1240

11

Distributed by: www.minilablaser.com

3. Operation Sequences

3.5

Fine-scanning Sequence
START

M480: counterclockwise (50mm/sec) Movement depends on scanning range. Excitation OFF after movement Fine-scanning entrance start position L481 lights up (Green)

Film slider stop sensor is observed during movement. No OFF to ON change within 3mm (D486 transparent or shading)

M480: counterclockwise (2 to 30mm/sec) Movement depends on trimming. Excitation OFF after movement Fine-scanning end position L480 lights up

Film slider stop sensor is observed during movement. No OFF to ON change within 3mm (D486 transparent or shading)

M480: excitation OFF L481 blinks (Red) Error E-1240

Sequence completed normally.

3.6

Scanning Completion Sequence


START
Home position sensor does not change to ON (D485 transparent). Movement depends on scanning range. Excitation OFF after movement

M480: counterclockwise (50mm/sec) 165.62mm


Go to the next step without stopping the M480 if the home position sensor changes to ON during movement (D485 shading)

S480: OFF

M480: excitation OFF S480: OFF L481 blinks (Red) Error E-1233

M480: counterclockwise (50mm/sec) 6.0mm fine adjustment value Excitation OFF after movement Mask set position L480 lights up

Film slider stop sensor is observed during movement. No OFF to ON change within 3mm (D486 transparent or shading) Film slider stop sensor is observed during movement. No OFF to ON change within 3mm (D486 transparent or shading)

M480: excitation OFF S480: OFF L481 blinks (Red) Error E-1240

Sequence completed normally.

12

Distributed by: www.minilablaser.com

3. Operation Sequences

3.7

Film Feed Sequence


START

No (D487 to D490: No change) Does key pressing method change? Yes (D487 to D490: Change)

Is pre-scanning indicated? (Main control unit side) No

Yes

Interval 1 sec

Is mask except for mount mask installed? Yes

No

Sequence completed normally.

Is right-hand frame feed key pressed? No (D488: OFF)

Yes (D488: ON)

M481: counterclockwise (194mm/sec) Feed length depends on kind of mask. Excitation OFF after movement Interval 50msec

Is left-hand frame feed key pressed? No (D489: OFF)

Yes (D489: ON)

M481: clockwise (194mm/sec) Feed length depends on kind of mask. Excitation OFF after movement Interval 50msec

Is right-hand frame adjustment key pressed? No (D487: OFF)

Yes (D487: ON)

M481: counterclockwise (7.3mm/sec) Feed length is 1.4mm. Excitation OFF after movement Interval 50msec

Is left-hand frame adjustment key pressed? No (D490: OFF)

Yes (D490: ON)

M481: clockwise (7.3mm/sec) Feed length is 1.4mm. Excitation OFF after movement Interval 50msec

13

Distributed by: www.minilablaser.com

4. Maintenance Menu 4. Maintenance Menu

4.1

MFC10Y I/O Check (44G)

4.2

[Selection]
Select 4 Setup and Maintenance 4 Carrier Adjustment/ Maintenance G MFC10Y I/O Check .

MFC10Y Monitor Image Position Adjustment (44H)

[Selection]
Select 4 Setup and Maintenance 4 Carrier Adjustment/ Maintenance H MFC10Y Monitor Image Position Adjustment.

[Procedure]
Operation of the motors and solenoids, and status of the sensors can be checked on this menu.

[Procedure]
The mask edge position on the monitor screen can be adjusted on this menu.

1. Connect the multi-film carrier MFC10Y to the plug-in connector on the scanner using the carrier extension cable as shown.

1. Select the [Monitor frame max.]. 2. Click [OK]. Operation returns to the Setup and Maintenance screen. 3. On the printing screen, pre-scan the reversal film. 4. If there is black mask edge on the screen, measure its width.

Carrier Extension Cable


EZ1828

2. Press the button of the output command and check if each part operates normally. 3. Click [OK]. Operation returns to the 4 Setup and Maintenance screen.

<Example> Case of 135 Mount The top black edge is 1.0mm, bottom black edge is 2.0mm, left-hand black edge is 3.0mm and right-hand black edge is 6.0mm.

NOTE: In the case of negative film, the edges are white.

14

Distributed by: www.minilablaser.com

4. Maintenance Menu

5. Open the [44H] MFC10Y Monitor Image Position Adjustment screen.

8. Enter the input value in the appropriate box in the screen. 9. Select the [Monitor frame standard]. 10. Click [OK]. Operation returns to the 4 Setup and Maintenance screen. 11. On the printing screen, pre-scan the reversal film and make sure there is no black mask edge on the screen.

6. Calculate (A) by using the formulae in the table below. <Example> T(+) D(): (A) = (Top Bottom) 2 = (1.0 2.0) 2 = 0.5 R(+) L(): (A) = (Right Left) 2 1.0 = (6.0 3.0) 2 1.0 = 0.5 7. Calculate input value from value (A) using the formulae the table below. <Example> T(+) D(): Since (A) < 0, Input value = (A) 0.3 = 0.5 0.3 = 0.8 R(+) L(): Since (A) > 0, Input value = (A) 0.3 = 0.5 0.3 = 0.2

12. If there is black mask edge, repeat steps 1 through 11.

Item T(+) D()

Mask Type 135F 135M (Mount) 135P 135HV 135H 240 240M (Mount) 64.5 66 67 68 69 110 126 135F 135M (Mount) 135P 135HV 135H 240 240M (Mount) 64.5 66 67 68 69 110 126

Formula for (A) (A) = (Top Bottom) 2

Formula for input value In the case of (A) 0 In the case of (A) < 0 Input value = (A) Input value = (A) 0.3

(A) = (Top Bottom) 2 0.86 (A) = (Top Bottom) 2 Input value = (A) 0.1

R(+) L()

(A) = (Top Bottom) 2 0.6 (A) = (Top Bottom) 2 (A) = (Right Left) 2 1.5 (A) = (Right Left) 2 1.0

Input value = (A) 0.3

(A) = (Right Left) 2 1.5 (A) = (Right Left) 2 0.86 1.2 (A) = (Right Left) 2 0.5 (A) = (Right Left) 2 0.7 (A) = (Right Left) 2 0.5 (A) = (Right Left) 2 0.7 (A) = (Right Left) 2 0.6 0.6 (A) = (Right Left) 2 + 3.0 Input value = (A) 0.1

Input value = (A) 0.3

15

Distributed by: www.minilablaser.com

4. Maintenance Menu

4.3

MFC10Y Machine Data Setup (44S)

4.4

MFC10Y Working Information (44L)

[Selection]
Select 4 Setup and Maintenance 4 Carrier Adjustment/ Maintenance S MFC10Y Machine Data Setup .

[Selection]
Select 4 Setup and Maintenance - 4 Carrier Adjustment/ Maintenance - L MFC10Y Working Information

[Procedure]
Set the machine data of the MFC10Y. 1. Install the MFC10Y. 2. Open the MFC10Y Machine Data Setup screen.

[Procedure]
Confirm the MFC10Y working information. The working information can be written to the EEPROM of the carrier or floppy disk before returning the carrier to the factory.

1. Select the Mask Type. 3. Check the values.

NOTE: The values should not be changed except when there is a special instruction from FUJIFILM.
4. Click [OK]. Operation returns to the 4 Setup and Maintenance screen.

2. Click [Write Working Info]. The dialog below appears.

3. Select the Carrier EEPROM or FD. 4. Insert the floppy disk into the disk drive of the main control unit.

16

Distributed by: www.minilablaser.com

4. Maintenance Menu

5. Click [Start]. The dialog box below appears.

6. Click [OK]. Writing starts. When writing is completed, the dialog box below appears.

7. Click [OK]. The dialog box disappears. 8. If the data clear is required, click [Clear] The confirmation dialog box appears. 9. Click [OK]. The dialog box disappears. 10. Click [OK]. Operation returns to the 4 Setup and Maintenance screen.

17

Distributed by: www.minilablaser.com

5. I/O Parts 5. I/O Parts Location Location

EZ1438

Code D480 D481 D482 D483 D484 D485 D486 D487 D488 D489 D490 L480 L481 M480 M481 S480

Name Film Mask Sensor 1 Film Mask Sensor 2 Film Mask Sensor 3 Film Mask Sensor 4 Film Mask Sensor 5 Film Slider Home Position Sensor Film Slider Stop Sensor Right Frame Adjustment Key Right Frame Feed Key Left Frame Feed Key Left Frame Adjustment Key Back Light Indicator Lamp Film Slider Feed Motor Film Feed Motor Film Pressure Solenoid Micro Switch Micro Switch Micro Switch Micro Switch Micro Switch

Remarks

Photo Interrupter Photo Interrupter Keyboard Circuit Board Keyboard Circuit Board Keyboard Circuit Board Keyboard Circuit Board DC24V Lamp for Light Table Green/Red LED 5-phase Pulse Motor Stepping Motor Solenoid

18

Distributed by: www.minilablaser.com

6. Parts Replacement and Adjustment 6. Parts Replacement and Adjustment

6.1

Film Feed Roller Replacement

6.3

Removal
1. Remove the two bearing holders and the film feed roller from the mask by unscrewing the two screws.
Screws (2) Bearing Holders (2) Film Feed Roller

Front Cover Removal/ Reinstallation

6.4

Keyboard Circuit Board (D487 to D490) Replacement

Removal
1. Remove the front cover by unscrewing the two screws.

Removal
1. Remove the front cover (see section 6.3). 2. Remove the cover, keyboard circuit board and four keys by unscrewing the two screws.
Screws (2) Cover Keyboard Circuit Board Keys (4)

Front Cover Screws (2)

EZ1394

EZ1397

Installation
Install the roller in the reverse order of removal.

2. Disconnect the connector (KEY1A).


Connector (KEY1A)
EZ1399

6.2

Film Press Roller Replacement

Installation
Install the circuit board in the reverse order of removal.

Removal
1. Remove the roller and two coil springs by unscrewing the bind screw.
EZ1398

6.5

Roller

Feed Section Cover Removal/ Reinstallation

Reinstallation Removal
Re-install the cover in the reverse order of removal. 1. Remove the feed section cover by unscrewing the three screws.
Screws (3)
Coil springs (2)

Bind Screw

Feed Section Cover

EZ1395

Installation
Install the roller in the reverse order of removal.

EZ1396

Reinstallation
Reinstall the cover in the reverse order of removal.

19

Distributed by: www.minilablaser.com

6. Parts Replacement and Adjustment

6.6

Film Feed Motor Section Cover Removal/ Reinstallation

6.7

Removal
1. Remove:

SSD20 Circuit Board (Indicator Lamp L481/Film Slider Home Position Sensor D485) Replacement

4. Remove the two M3 6 screws and lift the thread shaft nut retaining plate.

NOTE: Take care not to damage the guide shaft when sliding the retaining plate. Damage on the guide shaft may cause improper film slider feeding result in unacceptable prints.
Thread Shaft Nut Retaining Plate Film Slider Feed Motor M3 6 Screws (2)

Removal
Front cover (see section 6.3). Feed Section Cover (see section 6.5). 2. Move the film slider to the right side fully by turning the film slider feed motor by hand. 3. Remove the film feed motor section cover by unscrewing the screw.
Film Slider Feed Motor Screw Film Slider

1. Remove the film feed motor section cover (see section 6.6). 2. Disconnect the connector (SSD1) from the circuit board. 3. Remove the circuit board by unscrewing the screw.
Film Slider Home Position Sensor (D485) Connector (SSD1) Screw

Film Slider

Front Guide Bushing Retaining Plate M3 6 Screw Front Guide Shaft


EZ1403

5. Open the film slider slightly and disconnect the printed wire from the circuit board by releasing the lock on the connector.

Film Feed Motor Section Cover


EZ1400

SSD20 Circuit Board

Indicator Lamp (L481)


EZ1402

NOTE: The printed wire may be damaged if the film slider is opened fully without disconnecting the printed wire.
Film Slider

Reinstallation Reinstallation
Reinstallation is essentially in the reverse order of removal. Reinstall the circuit board in the reverse order of removal.

NOTE: Insert the tab on the cover into the groove in the carrier base.

6.8

Film Slider Opening/ Closing


Printed Wire Connector Lock
EZ1404

Film Slider Opening


1. Remove: Front cover (see section 6.3). Feed section cover (see section 6.5). 2. Move the film slider to the right side by turning the film slider feed motor by hand.
Tab Groove
EZ1401

6. Open the film slider fully.

3. Remove the M3 6 screw and slide the front guide bushing retaining plate to the right side.

20

Distributed by: www.minilablaser.com

6. Parts Replacement and Adjustment

Film Slider Closing


Closing of the film slider is essentially in the reverse order of opening.

3. Disconnect the connector and remove the circuit board. 4. Remove the five push buttons.
MSB20 Circuit Board (D480 to D484) Connector

6.11 Film Pressure Solenoid (S480) Replacement


Removal
1. Open the film slider (see section 6.8). 2. Remove the two harness holders by unscrewing the two flat countersunk head screws. 3. Remove the solenoid by unscrewing the flat countersunk head screw.
Solenoid (S480)

NOTE: Always use the M3 6 screws. Longer screws damage the guide shaft and improper operation may result. While pressing the guide bushing retaining plate against the locating pin, tighten the screw.
Locating Pin

Push Buttons (5)


EZ1407

Installation
Install the circuit board in the reverse order of removal.
Screw Guide Bushing Retaining Plate
EZ1405

6.9

MSB20 Circuit Board (Film Mask Sensors D480 to D484) Replacement

6.10 Film Feed Gear Bracket Replacement


Removal
1. Open the film slider (see section 6.8). 2. Remove the gear bracket by unscrewing the flat countersunk head screw.
Flat Countersunk Head Screw

Harness Holders Flat Countersunk Head Screws (2) Flat Countersunk Head Screw
EZ1410

Installation
Installation is essentially in the reverse order of removal.

Removal
1. Open the film slider (see section 6.8). 2. Remove the two bind screws securing the circuit board.
MSB20 Circuit Board

NOTE: Align the hole in the solenoid with the locating pin on the film slider.
Solenoid (S480)

Gear Bracket
EZ1408

Hole Locating Pin

Bind Screws (2)


EZ1406

Installation
Installation is essentially in the reverse order of removal.

EZ1411

NOTE: Face the chamfered side of the bracket down.

21

Distributed by: www.minilablaser.com

6. Parts Replacement and Adjustment

6.12 Front Guide Shaft/ Guide Bushing/Seal Replacement


Removal
1. Open the film slider (see section 6.8). 2. Remove the guide shaft by unscrewing the two screws.

Installation
Installation is essentially in the reverse order of removal.

Reinstallation
Reinstallation is essentially in the reverse order of removal.

NOTE: Tighten the left-hand screw first, then the right hand screw. Lightly apply minilab grease to the guide shaft.
Guide Shaft

NOTE: Always use the M3 6 screws. Longer screw damages the guide shaft and improper operation may result. While pressing the guide bushing retaining plate against the locating pin, tighten the screw.
Locating Pins (2) M3 6 Screws (2)

(For Minilab) Front Guide Shaft Screws (2)


EZ1412

Left-hand Screw (Tighten first)


EZ1414

3. Remove the guide bushing, felt seat and retaining plate from the guide shaft.

6.13 Film Slider Removal/ Reinstallation


Removal

Retaining Plates (2)


EZ1416

NOTE: Take care not to damage the guide shaft with the retaining plate. Damage on the guide shaft may cause improper film slider feeding resulting in unacceptable prints.
Retaining Plate Felt Seal

1. Open the film slider (see section 6.8). 2. Remove the two M3 6 screws and shift the guide bushings and retaining plates. 3. Remove the film slider.

6.14 Rear Guide Shaft/ Guide Bushing/Seal Replacement


Removal
1. Remove the film slider (see section 6.13). 2. Remove the rear guide shaft by unscrewing the two screws.

NOTE: Take care not to damage the guide shaft with the retaining plate. Damage on the guide shaft may cause improper film slider feeding resulting in unacceptable prints.
M3 6 Screws (2)

Guide Bushing Front Guide Shaft


EZ1413

Screws (2)

Rear Guide Shaft


EZ1417

Film Slider

Guide Bushings/ Retaining Plates (2)


EZ1415

22

Distributed by: www.minilablaser.com

6. Parts Replacement and Adjustment

3. Remove the two retaining plates, guide bushings and felt seals from the guide shaft.
Retaining Plates (2) Guide Bushings (2)

6.15 Back Light (L480) Replacement


Removal
1. Open the film slider (see section 6.8). 2. Remove the film feed motor section cover (see section 6.6). 3. Remove the back light by unscrewing the screw.

6.16 Film Feed Motor (M481) Replacement


Removal
1. Remove the back light (see section 6.15). 2. Disconnect the motor connector. 3. Remove the motor bracket by unscrewing the screw.

Felt Seals (2)

Back Light (L480)


Rear Guide Shaft
EZ1418

Screw

Installation
Installation is essentially in the reverse order of removal.

NOTE: Tighten the left-hand screw first, then the right-hand screw. Lightly apply minilab grease to the guide shaft.
Guide Shaft (For Minilab)

Screw
EZ1420

Motor Bracket

Connector
EZ1422

4. Disconnect the connector (L480).

4. Remove the bracket from the motor by unscrewing the two screws.
Screws (2)

Bracket

Left Hand Screw (Tighten first)


EZ1419

Connector (L480)
EZ1421

Film Feed Motor (M481)


EZ1423

Installation
Install the back light in the reverse order of removal.

Installation
Install the motor in the reverse order of removal.

23

Distributed by: www.minilablaser.com

6. Parts Replacement and Adjustment

6.17 Circuit Board Section Cover Removal/ Reinstallation


Removal
1. Open the film slider (see section 6.8). 2. Remove the screw securing the circuit board section cover and shift the cover to the right side to remove it.
Circuit Board Section Cover

6.18 CYA20 Circuit Board Replacement


Removal
1. Remove the circuit board section cover (see section 6.17). 2. Disconnect all connectors from the circuit board. 3. Remove the CYA20 circuit board by unscrewing the screw.
Screw CYA20 Circuit Board

4. Remove the plug-in connector by unscrewing the two screws.

Screws (2) Plug-in Connector


EZ1427

Installation
Install the plug-in connector in the reverse order of removal.

Screw
EZ1424

6.20 Film Slider Feed Motor Drive Circuit Board Replacement


EZ1425

Reinstallation Installation
Reinstallation is essentially in the reverse order of removal.

Removal
1. Remove the feed section cover (see section 6.5). 2. Disconnect the three connectors (CN1, CN2 and CN3) from the circuit board. 3. Remove the driver circuit board by unscrewing the two screws.

NOTE: Insert the three tabs on the rear side of the cover into the grooves first, then insert the left tab into the groove.
Left Tab

Install the circuit board in the reverse order of removal. After installation, download the data from the hard disk into the CYA20 circuit board on the menu 44P Film Carrier ID Setup/ Delete screen.

6.19 Plug-in Connector Replacement


Removal
1. Remove the circuit board section cover (see section 6.17). 2. Disconnect the three connectors (CYA1, CYA2 and CYA3) from the CYA20 circuit board. 3. Remove the screw securing the grounding wire to the carrier base.

CN1

CN2

VR2

VR1

CN3

Rear Tabs (3)


EZ1428

Film Slider Feed Motor Drive Circuit Board

Screws (2)

EZ1429

Screw/Grounding Wire

Installation
Installation is essentially in the reverse order of removal.

NOTE: Do not try to turn the variable resisters (VR1 and VR2). They are adjusted at the factory before shipment.
CYA1 CYA2 CYA3
EZ1426

24

Distributed by: www.minilablaser.com

6. Parts Replacement and Adjustment

6.21 Film Slider Feed Motor (M480) Assembly/Film Slider Feed Thread Shaft/SSJ20 Circuit board (Film Slider Stop Sensor D486) Replacement
Removal
1. Open the film slider (see section 6.8). 2. Loosen the two hex. socket head set screws securing the joint using the 1.27mm hex. wrench. 3. Remove the motor assembly by unscrewing the two screws. 4. Disconnect the motor connector.
Motor Assembly (M480) Hex. Socket Head Set Screws (2) Joint

6. Remove the SSJ20 circuit board by unscrewing the screw and disconnecting the connector.
SSJ20 Circuit board (Film Slider Stop Sensor D486)

3. Install the motor assembly and tighten the two screws while pressing it against the right-hand side front.

NOTE: Pass the motor harness to the right-hand side through the groove in the carrier base.
Motor Assembly

Screw Connector
EZ1432

Motor Harness Screws (2)


EZ1434

Installation
Installation is essentially in the reverse order of removal.

NOTE: Tighten the motor bracket and thread shaft bracket by following the steps below.
1. Loosen the two screws securing the right-hand thread shaft bracket.
Bracket Screws (2) Screws (2)

4. While pressing the right thread shaft bracket against the left-hand side front, tighten the two screws.

Connector
EZ1430

Screws (2) Right-hand Thread Shaft Bracket


EZ1435

5. Remove the thread shaft assembly and two ball bearings.


EZ1433

5. Align the hole in the joint with the Dcut surface on the thread shaft and tighten the two hex. socket head set screws.
Hex. Socket Head Set Screws (2)

2. Install the thread shaft and two ball bearings to the bracket.

NOTE: Do not wipe grease off the thread shaft.

Thread Shaft Assembly Ball Bearings (2)


EZ1431

D-cut Surface Joint


EZ1436

25

Distributed by: www.minilablaser.com

6. Parts Replacement and Adjustment

6.22 Diffusion Plate Replacement


Removal
1. Place the MFC10Y up side down. 2. Remove the diffusion plate by unscrewing the two screws.
Screws (2)

Diffusion Plate
EZ1437

Installation
Install the diffusion plate in the reverse order of removal.

26

Das könnte Ihnen auch gefallen