Beruflich Dokumente
Kultur Dokumente
1) Resistance is measured in
A. C.
henries hertz
B. D.
ohms watts
2)
A. B. C. D.
I = VR I = R/V V = IR I = V/R
3)
What is the approximate resistance setting of a rheostat in which 650 mA of current flows with a 150 V source?
A. B. C. D.
9.7 97 23 230
4)
A. B. C. D.
5)
A. C.
conductors semiconductors
B. D.
insulators filters
6)
When the current is 2.5 A, how many coulombs pass a point in 0.2 s?
A. B. C. D.
7)
A. B. C. D.
8)
A certain appliance uses 350 W. If it is allowed to run continuously for 24 days, how many kilowatt-hours of energy does it consume?
A. B. C. D.
9)
A 6 V battery is connected to a 300 load. Under these conditions, it is rated at 40 Ah. How long can it supply current to the load?
A. B. C. D.
1h 200 h 2,000 h 10 h
10)
Which of the following series combinations dissipates the most power when connected across a 120 V source?
A. B. C. D.
11)
Five resistors are connected in a series and there is a current of 3 A into the first resistor. The amount of current into the second resistor is
A. B. C. D.
3A 1A 4A 0.3 A
12)
The currents into a junction flow along two paths. One current is 4 A and the other is 3 A. The total current out of the junction is
A. B. C. D. 13)
1A 7A unknown the larger of the two Five light bulbs are connected in parallel across 110 V. Each bulb is rated at 200 W. The current through each bulb is approximately
A. B. C. D.
14)
When a load resistance is removed from the output of a voltage divider circuit, the current drawn from the source
A. B. C. D.
15)
Find the Thevenin equivalent (VTH and RTH) between terminals A and B of the circuit given below.
A. B. C. D.
16)
When the speed at which a conductor is moved through a magnetic field is increased, the induced voltage
A. B. C. D.
17)
The induced voltage across a coil with 250 turns that is located in a magnetic field that is changing at a rate of 8 Wb/s is
A. B. C. D.
18)
What is the flux density in a magnetic field in which the flux in 0.1 m2 is 600
Wb?
A. B. C. D.
19)
The conductive loop on the rotor of a simple two-pole, single-phase generator rotates at a rate of 400 rps. The frequency of the induced output voltage is
A. B. C. D.
20)
The average value of a 12 V peak sine wave over one complete cycle is
A. B. C. D.
21)
A 10
F, 20
F, 22
F, and 100
A. B. C. D.
F F F F
22)
A sine wave voltage is applied across a capacitor. When the frequency of the voltage is decreased, the current
A. B. C. D.
23)
Two 0.68 F capacitors are connected in series across a 10 kHz sine wave signal source. The total capacitive reactance is
A. B. C. D.
24)
A 2 mH, a 3.3 mH, and a 0.2 mH inductor are connected in series. The total inductance is
A. B. C. D.
25)
The current through a 120 mH coil is changing at a rate of 150 mA/s. The voltage induced across the coil is
A. B. C. D.
______________________