Beruflich Dokumente
Kultur Dokumente
02
PRODUCT SPECIFICATION
OPERATION: Application: Refrigerant: Operation: Cooling: L.B.P. R600a Capillary Static Max. Ambient Temp: (1) Max. Steady Discharge Temp: (1,2) Max. Peak Discharge Temp: Max. Steady Condensing Temp: (2) Max. Peak Condensing Temp: Max. Winding Temp: Max. Impurities: Max.Total Compressor Water Content: 43C 120C 135C 60C 70C 130C 30 mg 100 mg
COMPRESSOR: Displacement: Bore: Stroke: 6.75 cc 23.6 mm 16.0 mm Oil Type: (4) Viscosity: Suction Muffler: Mineral 7 cSt Semi-direct
ELECTRICAL: Power Supply: Voltage Limits: Frequency: Phase: 220 - 240V 187 - 264V 50 Hz 1 ph Motor Type: Locked Rotor Current: RSIR / RSCR * 7.0 / 3.3 A**
26.1 34.6
** Maximum current / Measured after 4 seconds For rated performance, (1) Measured 5cm. from the shell with insulated thermocouples (2) For transient conditions during 'Pull Down' (3) Net weight is with oil but without electrics (4) Measured at 40C the suction line must be connected to the stub marked 'AS' on the attached drawing.
AE 1373.1
May '07
Page 1
ACC reserves the right to change the data without prior notice
HVY67AA.02
PRODUCT SPECIFICATION
ELECTRICAL COMPONENTS: ECC Starting Device: Starting Device: (1) Starting Device: PTC Resistance: Run Capacitor: PROTECTORS:
Type Open C Close C U.T.C
Time Check Current
14
3.0 F
Electrica
T 0619 / kk
BDG
AE 25 FY x
BDG 'x' Codes: 6 for terminal boards Mod.89,90 8 for terminal board Mod.91
Electrica 'kk' Codes: 05 for terminal boards Mod.89,90 07 for terminal board Mod.91
AE 1373.1
May '07
Page 2
ACC reserves the right to change the data without prior notice
HVY67AA.02
PRODUCT SPECIFICATION
PERFORMANCE:
0,72 Amps 0,68 0,64 0,60 0,56 0,52 0,48 120 Input Watts 110 100 90 80 70 60 1,85 C.o.P. 1,75 1,65 1,55 1,45 1,35 1,25 1,15 1,05 215 Capacity 200 Watts 185 170 155 140 125 110 95 80 65 -35 -30 -25 -20 -15 Evaporating Temperature (C) -10 -5
Test Conditions: Condensing Temp: Liquid Temp: Gas Return Temp: Ambient Temp: ASHRAE 55C 32C 32C 32C CECOMAF 55C 55C 32C 32C (Graphs are at ASHRAE conditions)
Evaporating Temperature C
-30
70 1,11 57 0,90 63 0,50
-25
98 1,30 80 1,07 75 0,53
-23,3
107 1,36
-20
128 1,48 105 1,22
-15
164 1,66 135 1,36 99 0,62
-10
205 1,83 168 1,50 112 0,68
ASHRAE: CECOMAF:
W W/W W W/W W A
79 0,54
86 0,57
AE 1373.1
May '07
Page 3
ACC reserves the right to change the data without prior notice
HVY67AA.02
PRODUCT SPECIFICATION
PERFORMANCE:
Amps 0,58 0,54 0,50 0,46 0,42 0,38 0,34 0,30 Input Watts 115 105 95 85 75 65 C.o.P. 55 2,00 1,90 1,80 1,70 1,60 1,50 1,40 1,30 1,20 1,10 Capacity WATTS 210 200 190 180 170 160 150 140 130 120 110 100 90 80 70 -35 -30 -25 -20 -15 Evaporating Temperature (C) -10 -5
Test Conditions: Condensing Temp: Liquid Temp: Gas Return Temp: Ambient Temp: ASHRAE 55C 32C 32C 32C CECOMAF 55C 55C 32C 32C (Graphs are at ASHRAE conditions)
Evaporating Temperature C
-30
70 1,16 57 0,95 60 0,32
-25
98 1,38 80 1,13 71 0,36
-23,3
108 1,45
-20
129 1,58 106 1,29
-15
165 1,77 136 1,46 93 0,47
-10
207 1,95 170 1,60 106 0,54
ASHRAE: CECOMAF:
W W/W W W/W W A
75 0,38
82 0,41
AE 1373.1
May '07
Page 3a
ACC reserves the right to change the data without prior notice
HVY67AA.02
PRODUCT SPECIFICATION
Circuit Diagram for ECC Terminal Board Standard Version
Appliance, Lights etc. Motor Protector Thermostat y
Mounting Accessories
2 1 x
L PTC N
E y
1 x
5th Optional
x = 26mm or 28.5mm y = 9mm or 10.3mm Other sizes available 1. Rubber grommet 2. Sleeve 3. Washer 4. Steel pin 5. Clip
L PTC N
5th Optional
Upright
Electrics Up
L PTC N
Logo
Model
Production Date
5th Optional
Refrigerant
< SUCTION
Check Digit
AE 1373.1
May '07
Page 4
ACC reserves the right to change the data without prior notice