Beruflich Dokumente
Kultur Dokumente
M-ALMITE SEALER
(Sealing Agent for Low Temperature Anodized Aluminum Coating )
PROPERTIES
Normal Range
Concentration 7 g/L 3.5 g/L~10.5 g/L
Ph 6.0 6.0 ± 1.0
Temperature 60 ℃ 60 ℃~98 ℃
Time 15min 10~30min
SOLUTION MAKE-UP
1 , Concentration:
1, The concentration ranges available are 3.5 – 10.5 g/lit. and the optimum on is 7 g/lit.
2. A higher concentration generally increases the corrosion resistance and sealing efficiency,
But the excess tends to cause precipitations and smut or to increase the consumption by
drag-out.
3. With the concentration of M-ALMITE SEALER below 3.5 g/lit., the corrosion resistance and
sealing efficiency reduce. Add then M-ALMITE SEALER at a rate of about 3.5 g/lit.
4. The control of the concentration should be performed in principle by means of analysis for
the Nickel.
2, PH of Bath
1, The PH of the sealing bath should be maintained between 5.0 and 6.0 and preferably at 6.0
± 1.0. The control of PH in important, and a daily check should be made.
2. The value of PH, when lower than 5.0, causes the corrosion resistance and sealing
efficiency to reduce and hence adjust it to maintain the proper value by means of diluted
ammonium hydroxide solution, sodium acetate, etc.
3. A higher PH than 6.0 is liable to produce precipitations and to cause powdering. Diluter
acetic acid is available for adjustment of the proper PH.
4. The corrosion and acid – resistance tend to rise as the PH of the bath increases.