Beruflich Dokumente
Kultur Dokumente
ZETAG 8814
Revision date : 05.07.2010 Version: 1.2 Page: 1/6 (30481547/SDU_GEN_CA/EN)
2. Hazards Identification
Emergency overview
Physical/Chemical hazards:
Potential health effects
CAUTION: ! colourless emulsion liquid mineral oil-like Contact causes eye irritation, Contact causes skin irritation., Contains petroleum distillates and prolonged contact with mists may cause skin, eye and respiratory tract irritation. Continued overexposure may cause headache and dizziness. Ingestion may cause lung complications. Spills are very slippery.
Primary routes of entry: Skin, Eyes, Inhalation, Ingestion Chronic exposure: CAUSES EYE IRRITATION. Vapors may irritate eyes and respiratory tract, and result in headacheor dizziness.
3. Composition/Information on Ingredients
Chemical name Ethanaminium, N,N,N-trimethyl-2-[(1-oxo-2propenyl)oxy]-, chloride, polymer with 2propenamide (9CI) ALCOHOLS, (C=12-14)-SECONDARY, ETHOXYLATED Distillates (petroleum), hydrotreated light CAS Number 69418-26-4 Content (Weight) 15.0 - 40.0 % Hazardous Y
84133-50-6 64742-47-8
Y Y
4. First-aid Measures
Inhalation: Remove to fresh air, if not breathing give artificial respiration. If breathing is difficult, give oxygen and get immediate medical attention. Skin: If clothing is contaminated, remove and launder before reuse. After contact with skin, wash immediately with plenty of water and soap. Get medical attention if irritation occurs. Eyes: Immediately flush the eye(s) with lukewarm, gently flowing water for 15 minutes or until the chemical is removed. Get immediate medical attention if irritation persists. Ingestion: Do not induce vomiting. If vomiting occurs naturally, have casualty lean forward to reduce the risk of aspiration. Seek medical attention immediately.
5. Fire-fighting Measures
Suitable extinguishing media: carbon dioxide, dry powder, foam Unsuitable Extinguishing Media: If water is used, restrict pedestrian and vehicular traffic in areas where slip hazard may exist. Hazardous combustion products: Burning may produce oxides. Hazards during fire-fighting: Standard procedure for chemical fires. Cool fire-exposed containers with water. Spills can cause very slippery conditions on floors. Protective equipment for fire-fighting: Wear self-contained breathing apparatus and chemical-protective clothing.
General advice: As with all industrial chemicals, use good industrial practices when handling. Avoid eye, skin, and clothing contact. Do not inhale. Do not taste or swallow. Use only with adequate ventilation. Clean up spills promptly Protection against fire and explosion: None known
Storage
General advice: Keep container tightly closed in a dry, cool and well-ventilated place. Avoid extremes of temperature. Keep from freezing. Temperature tolerance: Keep from freezing. > for industrial use only <
ACGIH
200 mg/m3 TWA: 200 mg/m3 Non-aerosol (as total hydrocarbon vapor) P: Application restricted to conditions in which there are negligible aerosol exposures. SKIN_DES: Non-aerosol (as total hydrocarbon vapor) Can be absorbed through the skin
Engineering Controls: Work in well ventilated areas. Do not breathe vapors or mist.
Personal protective equipment
Respiratory protection: Use NIOSH approved respirator as needed to mitigate exposure. Eye protection: Tightly fitting safety goggles (splash goggles) (EN 166) Body protection: Wear chemical resistant gloves and protective clothing. General safety and hygiene measures: Eye wash station and safety shower should be available in immediate work area., Select additional protective equipment based upon potential for exposure.
Substances to avoid: Strong oxidizing agents, strong acids, strong bases. Possibility of Hazardous Reactions: No hazardous reactions known. Hazardous decomposition products: No decomposition expected under normal storage conditions.
Information on: Distillates (petroleum), hydrotreated light Inhalation of vapors and mists is harmful. ---------------------------------Skin irritation:
Not tested Component(s) in greater than 1 percent concentration is known to be an irritant. Information on: ALCOHOLS, (C=12-14)-SECONDARY, ETHOXYLATED CAUSES SKIN IRRITATION.
Product has not been tested. Component(s) in greater than 1 percent concentration is known to be an irritant. Information on: ALCOHOLS, (C=12-14)-SECONDARY, ETHOXYLATED Causes eye burns.
---------------------------------Skin Sensitization:
Information on: Distillates (petroleum), hydrotreated light Sensitization: no data available ---------------------------------Carcinogenicity: None of the components in this product at concentrations greater than 0.1% are listed by IARC; NTP, OSHA or ACGIH as a carcinogen.
Not classified as a dangerous good under transport regulations. Not classified as a dangerous good under transport regulations. Not classified as a dangerous good under transport regulations.
International Air Transport Association (IATA) International Maritime Dangerous Goods Code (IMDG)
Workplace Hazardous Materials Information System (WHMIS Classification): D-2B Materials Causing Other Toxic Effects - Toxic material
This product is WHMIS controlled. Significant New Activity Conditions (SNAC): This product does not contain any components subject to a SNAC Notice.
International Regulations
Chemical Weapons Convention: This product does not contain any component(s) listed under the Chemical Weapons Convention Schedule of Chemicals.
ZETAG 8814 is a registered trademark of BASF Canada or BASF SE Due to the merger of CIBA and BASF Group all Material Safety Data Sheets have been reassessed on the basis of consolidated information. This may have resulted in changes of the Material Safety Data Sheets. In case you have questions concerning such changes please contact us at the address mentioned in Section I. END OF DATA SHEET