Beruflich Dokumente
Kultur Dokumente
TRANSCEIVER
1. Connect the transceiverunder test to the proper VOLUME 213 of full rotation
voltage source, as specified by the equipment TONE CONTROL Center
manufacturer. Most mobile units require a SQUELCH Max. unsquelch
power source capable of supplying 13.8.VDC at NOISE LIMITER
(ANL & ANB switch) off
21. ntA recommended tests also specifv tests
RF GAIN Full Gain
for varying the voltage +I5% from 13.8 VDC, Full Gain
(11.5-15.tVDC). The SencorePS43 Porta-Pak MIC GAIN
PA SWITCH In "CB" position
and UPS164 Universal Power Supply have been
especially designedto provide thesevariable vol-
All signal input terminations and transmitter and
tages.
audio output loads, as specified by CB manu-
facturers, have been built into the CB42. No
2 . The following are standard test conditions and additional modifications are required for opera-
performance limits as recommended by leading tion into these calibrated loads.
CB manufacturers. Set the transceiver controls "Power Connec-
to the positions Iisted to perform initial set-up 3. Refer to special note under
for all basic tests. tions."
POWERSUPPLYVARIATIONS
The EIA specifies that all receiver and transmitter The following are the specifications established by
tests be performed with an input of 13.8 VDC for 12 the EIA:
VDC units. The EIA code RS-382 further specifies Varying + 10Vo:
tests to be performed with a raised or lowered supply (r2.4-75.2VDC): TransmitPower + 2dB
voltage to be sure that the receiver will operate u1de1 AudioPower +2dB
diffeient voltage supply conditions. An example of Sensitivity + 2 dB
such variations is found in a72 VoIt automotive elec- Squelch + 2 dB
trical system when the unit is operating just from the
battery (12 Volts nominal) and when the altemator + t S v o( 1 1 . 7 - 1 5 . 8 )FrequencYstabilitY of
or generator circuits are providing maximum charging transmitter to be maintained.
voltage(14-16 Volts).
+ 20vo(11.0-16.6)Unit shall oPerate
The adjustable outputs of the Sencore UPS164 + 3dB
TransmitPower
Universal Power Supply or PS43 Porta-Pak power + 3 dB
SensitivitY
supply allow these various tests to be performed.
RF GENERATOR