Beruflich Dokumente
Kultur Dokumente
This information may not, in whole or in part, be copied, photocopied, reproduced, translated or reduced to any electronic medium or machinereadable form without the prior written consent of Hatteland Display AS. The products may not be copied or duplicated in any way.
Hatteland Display AS CAN Module with CO-Processor HT 00254 OPT-A1 Last Revised: Revision#: 13 Mar 2013 07
Specifications
Number of CAN interfaces : 2 independent channels isolated from each other Version : CAN 2.0B Isolation : Galvanic isolation 2kV, CAN1 to CAN2 and port to chassis Protection : Continuous short circuit signal to signal : Continuous short circuit to isolated GND : Continuous shorts to 27V ESD rating on CAN bus : ESD rating of 12kV Human body model Min Baud rate : 64kbit Max baud rate : 500kbit Address mode : 11/29bit Terminating : No termination on PCB, user will put them in connector PCB Connector : Weidmller 1973600000 (SCD 3.81/08/90F 3.2SN BK BX) (Do not connect to this, use Terminal Block) Cable connector : 2 x Weidmller 1792970000 (BCZ 3.81/04/180F SN BK BX) Terminal Block (see illustration below) Cable : Twisted pair, no ground Supported protocols : SAE J1939 Standard Data Bus Interface : NMEA 2000 Standard Data Bus Interface : CANopen 4.0 (CIA DS 301 ver. 4.x) Supported OS Embedded Enterprise (WEE): Microsoft Windows XP Professional (Eng, SP3, SP2c), Microsoft Windows Server 2003/2008/2008R2 (Eng), Microsoft Windows 2003/2008/2008R2 (Eng), Microsoft Windows 7 Professional/Ultimate (Eng, SP1). Linux: openSUSE 11.4, Fedora 15, Ubuntu 10.04 LTS (API in development), Ubuntu 12.04 LTS (API in development). Test and certicate Hatteland Display standard (tested / type approved by the following classification societies): IEC 60945 4th (EN 60945:2002), IACS E10, ClassNK - Nippon Kaiji Kyokai, GL - Germanischer Lloyd, DNV - Det Norske Veritas, ABS - American Bureau of Shipping, CCS - China Classification Society (Pending), BV - Bureau Veritas, LRS - Lloyds Register of Shipping (Pending)
X9 CAN2
In Low Out Low In High Out High In Low Out Low In High Out High
Dimensions might be shown with or without decimals and indicated as mm [inches]. Tolerance on drawings is +/- 1mm. For accurate measurements, check relevant DWG le. Hatteland Display AS, msosen, N-5578 Nedre Vats, Norway Tel: (+47) 4814 2200 - mail@hatteland-display.com - www.hatteland-display.com
1/2