Sie sind auf Seite 1von 6

Safety Data Sheet

MAGNAFLOC LT7992
Revision date : 05.07.2010 Version: 1.2 Page: 1/6 (30485456/SDU_GEN_CA/EN)

1. Product and Company Identification


Company BASF Canada Inc. 100 Milverton Drive Mississauga, ON L5R 4H1, CANADA 24 Hour Emergency Response Information CANUTEC (reverse charges): (613) 996-6666 BASF HOTLINE: (800) 454-COPE (2673)

2. Hazards Identification
Emergency overview

Signal word: Colour: Appearance: State of matter: Odour: Health: Physical/Chemical hazards:
Potential health effects

CAUTION: ! straw yellow liquid liquid Slightly amine This product has no known adverse effect on human health. Spills are very slippery.

Primary routes of entry: Skin, Eyes, Inhalation, Ingestion Chronic exposure: Prolonged or repeated contact may cause eye and skin irritation. Inhalation of mist or vapor may cause irritation of the upper respiratory passages with coughing and discomfort.

3. Composition/Information on Ingredients
This material does not contain any hazardous components that are reportable according to WHMIS criteria.

4. First-aid Measures
Inhalation: Remove to fresh air, if not breathing give artificial respiration. If breathing is difficult, give oxygen and get immediate medical attention.

Safety Data Sheet


MAGNAFLOC LT7992
Revision date : 05.07.2010 Version: 1.2 Skin: If clothing is contaminated, remove and launder before reuse. After contact with skin, wash immediately with plenty of water and soap. Get medical attention if irritation occurs. Eyes: Immediately flush the eye(s) with lukewarm, gently flowing water for 15 minutes or until the chemical is removed. Get immediate medical attention if irritation persists. Ingestion: Do not induce vomiting. If vomiting occurs naturally, have casualty lean forward to reduce the risk of aspiration. Seek medical attention immediately. Page: 2/6 (30485456/SDU_GEN_CA/EN)

5. Fire-fighting Measures
Suitable extinguishing media: carbon dioxide, dry powder, foam, water spray Hazardous combustion products: Carbon and nitrogen oxides., Ammonia., Hydrochloric acid Hazards during fire-fighting: Standard procedure for chemical fires. Cool fire-exposed containers with water. The product is slippery when wet. Restrict pedestrian and vehicular traffic in areas where slip hazard may exist. Protective equipment for fire-fighting: Wear self-contained breathing apparatus and chemical-protective clothing.

6. Accidental Release Measures


Cleanup: Spills are very slippery. Pick up with inert absorbent material (e.g. sand, earth etc.). Scoop into marked containers for disposal as chemical waste. Wear suitable protective equipment. Should not be released into the environment.

7. Handling and Storage


Handling

General advice: As with all industrial chemicals, use good industrial practices when handling. Avoid eye, skin, and clothing contact. Do not inhale. Do not taste or swallow. Use only with adequate ventilation.
Storage

General advice: Keep container tightly closed in a dry, cool and well-ventilated place. Sensitive to cold below 0C (32F). Temperature tolerance:

Safety Data Sheet


MAGNAFLOC LT7992
Revision date : 05.07.2010 Version: 1.2 FROST SENSITIVE PRODUCT > for industrial use only < Page: 3/6 (30485456/SDU_GEN_CA/EN)

8. Exposure Controls and Personal Protection


Engineering Controls: Work in well ventilated areas. Do not breathe vapors or mist.
Personal protective equipment

Respiratory protection: Use NIOSH approved respirator as needed to mitigate exposure. Eye protection: Tightly fitting safety goggles (chemical goggles). Body protection: Wear chemical resistant gloves and protective clothing. General safety and hygiene measures: There are no OSHA or ACGIH exposure guidelines available for component(s) in this product., Eye wash station and safety shower should be available in immediate work area., Select additional protective equipment based upon potential for exposure.

9. Physical and Chemical Properties


Colour: Form: State of matter: Odour: pH value: Evaporation rate: Lower explosion limit: Upper explosion limit: Flash point: Self-ignition temperature: straw yellow liquid liquid Slightly amine approx.6 Not tested not determined not determined > 100 C Not tested Not tested Not tested > 100 C Not tested approx. 1.0 g/cm3 1.035 Not tested Not applicable Not tested miscible Not tested

Melting point: Boiling point: Vapour pressure: Density: Relative density: Vapour density: Partitioning coefficient noctanol/water (log Pow): Viscosity, dynamic: Solubility in water: Solubility in other solvents:

10. Stability and Reactivity


Stability:

Safety Data Sheet


MAGNAFLOC LT7992
Revision date : 05.07.2010 Version: 1.2 Page: 4/6 (30485456/SDU_GEN_CA/EN) Stable Conditions to avoid: Avoid temperature extremes, especially frost and freezing conditions. Substances to avoid: Strong oxidizing agents., May react slowly with iron, copper, and aluminium resulting in corrosion and discoloration of product. Possibility of Hazardous Reactions: No hazardous reactions known. Hazardous decomposition products: No decomposition expected under normal storage conditions.

11. Toxicological Information


Acute oral toxicity:

LD50 / oral / rat: > 5,000 mg/kg (Active Ingredient)


Acute inhalation toxicity:

not determined
Acute dermal toxicity:

dermal: Not determined.


Skin irritation:

Mild skin irritant. (Rabbits) (Active Ingredient)


Eye irritation:

(Rabbits) Mild eye irritant. (Active Ingredient)


Skin Sensitization:

not determined
Subacute toxicity:

not determined
Subchronic Toxicty:

not determined
Chronic toxicity:

not determined Genetic toxicity: Not determined. Carcinogenicity: None of the components in this product at concentrations greater than 0.1% are listed by IARC; NTP, OSHA or ACGIH as a carcinogen. Reproductive toxicity: not determined Developmental toxicity/teratogenicity: not determined

12. Ecological Information


Toxicity to fish: 96 h/LC50: > 10 mg/l By analogy with a product of similar composition

Safety Data Sheet


MAGNAFLOC LT7992
Revision date : 05.07.2010 Version: 1.2 Toxicity to aquatic invertebrates: 48 h/EC50: > 10 mg/l By analogy with a product of similar composition Toxicity to aquatic plants: Not tested Toxicity to microorganisms: Not tested Biodegradation: Not tested Other ecotoxicological advice: This product contains polymer(s) that may be toxic to aquatic organisms when tested in pure (distilled) water. Toxicity is greatly reduced byparticles in natural water. Page: 5/6 (30485456/SDU_GEN_CA/EN)

13. Disposal Considerations


Waste disposal of substance: Dispose of in accordance with local regulations.

14. Transport Information


TDG (Canada) Road transport

Special shipping information: Special shipping information: Special shipping information:

Not classified as a dangerous good under transport regulations. Not classified as a dangerous good under transport regulations. Not classified as a dangerous good under transport regulations.

International Air Transport Association (IATA) International Maritime Dangerous Goods Code (IMDG)

15. Regulatory Information


Canada: Domestic Substances List (DSL): US: Toxic Substances Control Act (TSCA): All components either exempt or listed on the DSL All component(s) comprising this product are either exempt or listed on the TSCA inventory

Canada Regulations

Workplace Hazardous Materials Information System (WHMIS Classification): This product is not WHMIS controlled. Significant New Activity Conditions (SNAC): This product does not contain any components subject to a SNAC Notice.
International Regulations

Chemical Weapons Convention:

Safety Data Sheet


MAGNAFLOC LT7992
Revision date : 05.07.2010 Version: 1.2 Page: 6/6 (30485456/SDU_GEN_CA/EN) This product does not contain any component(s) listed under the Chemical Weapons Convention Schedule of Chemicals.

16. Other Information


Product Safety Contact: Prepared by: Date / Revised: Rodica Romanovschi (905) 812-7280 Generation date

This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations and the MSDS contains all the information required by the Controlled Products Regulations.

MAGNAFLOC LT7992 is a registered trademark of BASF Canada or BASF SE Due to the merger of CIBA and BASF Group all Material Safety Data Sheets have been reassessed on the basis of consolidated information. This may have resulted in changes of the Material Safety Data Sheets. In case you have questions concerning such changes please contact us at the address mentioned in Section I. END OF DATA SHEET

Das könnte Ihnen auch gefallen