Beruflich Dokumente
Kultur Dokumente
STANDARDS ACTIONS
30-Day Public Review from April 19, 2013 to May 19, 2013
Volume V, Issue 13
STANDARDS ACTIONS
2nd Public Review (Full) of BSR/ASHRAE/IES Ad 1st Public Review of BSR/ASHRAE/IES Adden
This addendum is in response to a CMP. The economic analysis did not extend above 24 pipe size, so require ments for larger pipes have been eliminated. 1st Public Review of BSR/ASHRAE/IES Adden dum dr to ANSI/ASHRAE/IES Standard 90.1 2010, Energy Standard for Buildings Except Low Rise Residential Buildings This addendum modifies the definition of building en trance for clarity. 1st Public Review of BSR/ASHRAE/IES Adden dum dt to ANSI/ASHRAE/IES Standard 90.1 2010, Energy Standard for Buildings Except Low Rise Residential Buildings This addendum was generated in response to a continu ous maintenance proposal to remove requirements to control lighting that is not part of the building permit to exempt some sign lighting in the lighting control watt age calculation. 1st Public Review of BSR/ASHRAE/IES Adden st 1 Public Review of BSR/ASHRAE/IES Adden dum du to ANSI/ASHRAE/IES Standard 90.1 dum dp to ANSI/ASHRAE/IES Standard 90.1 2010, Energy Standard for Buildings Except Low 2010, Energy Standard for Buildings Except Low Rise Residential Buildings Rise Residential Buildings This addendum requires waterside economizers for This addendum modifies language introduced in adden chilled water systems including nonfan systems such dum ar to 90.12010, specifically it revises the defini as radiant cooling or passive chilled beam systems and tion of walkin cooler to match the temperature defi for systems with small individual chilledwater fan sys nitions in federal regulations tems such as fan coils or chilled beams. Provisions are added to avoid implementations that result in excessive heat rejection energy.
Volume V, Issue 13
STANDARDS ACTIONS
1st Public Review of BSR/ASHRAE/ASHE Addendum y to ANSI/ASHRAE/ASHE Standard 1702008, Ventilation of Health Care Facilities This proposed addendum adds restrictions on the use of duct lining. These requirements are similar to those of the 2010 FGI Guidelines for the Design and Construction of Health Care Facilities, but have been clarified.
1st Public Review of BSR/ASHRAE/ASHE Addendum z to ANSI/ASHRAE/ASHE Standard 170-2008, Ventilation of Health Care Facilities This proposed addendum clarifies requirements for an Emergency Department examination/treatment room. The function of the Emergency Department examination/ treatment room is described in FGI-2010 Paragraph 2.23.1.3.6.
Volume V, Issue 13
STANDARDS ACTIONS
1st Public Review of BSR/ASHRAE/ASHE Adden- 1st Public Review of BSR/ASHRAE Addendum au
The purpose of this addendum is to deprecate execution of GetAlarmSummary since addendum 135-2010af made the GetEventInformation service execution required for all devices that support event reporting. The addendum also dep45-Day Public Review from recates execution of GetEnrollmentSummary because this April 19, 2013 to June 3, 2013 complex service does not provide enough information to st 1 Public Review of BSR/ASHRAE Addendum o to acknowledge an event. ANSI/ASHRAE Standard 55-2010, Thermal Envi 1st Public Review of BSR/ASHRAE Addendum aw ronmental Conditions for Human Occupancy to ANSI/ASHRAE Standard 135-2012, BACnet - A Data Communication Protocol for Building AutomaThis proposed addendum clarifies the normative language tion and Control Networks that appears in Section 7 (Evaluation of the Thermal Environment) of the body of the Standard. This revised Section 7 provides standardized measurement methods for the evaluation of comfort conditions in existing buildings. The intention is to assist users of the Standard in understanding what is actually happening in buildings. Use of standardized methods allows better comparison among different buildings and in the same building under a variety of conditions. The methods have also been simplified when compared to previous versions of Standard 55. The purpose of this addendum is to extend the CHANGEOF-STATE event algorithm for all discrete types, add a new event algorithm, CHANGE_OF-DISCRETE_VALUE, add a new fault algorithm, FAULT_OUT_OF_RANGE, extend the Loop Object Type to support specific low and high error limits, add the ability to report faults to date and time related value objects, and add the ability to report faults to the Command, Device, and Notification class objects.
Volume V, Issue 13
STANDARDS ACTIONS
PUBLIC REVIEWCALL FOR COMMENTS 1st Public Review of BSR/ASHRAE Standard 1522004R, Method of Test for Determining the Design and Seasonal Efficiencies of Residential Thermal Distribution Systems This revision of Standard 152-2004 prescribes a method of test to determine the efficiency of space heating and/or cooling thermal distribution systems under seasonal and design conditions. The objective is to facilitate annual energy calculations and heating and cooling equipment capacity calculations.
INTERIM MEETINGS
A complete listing of project committee interim meetings is provided on ASHRAEs website at: http://www.ashrae.org/pc-interim-meetings.
PUBLICATION NOTICE
The standards and guideline documents listed below are now available for purchase on the ASHRAE website at: http://www.ashrae.org/published-standards, or by contacting the Sales Department at: ASHRAE, 1791 Tullie Circle, NE, Atlanta, GA 30329-2305. Email: orders@ashrae.org. Fax: 404-321-5479. Telephone: 404.636.8400 (worldwide) or toll free at 1.800.527.4723 for orders in the U.S. and Canada. Addenda may be downloaded for free at: http://www.ashrae.org/standards-addenda.
SSPC 189.1, Standard for the Design of HighPerformance Green Buildings Except Low-Rise Residential Buildings, will hold a conference call on May 7, 2013 from 11:00 am to 2:00 pm (Eastern) . For additional information contact Bert Etheredge, Staff Liaison to SSPC 189.1 (betheredge@ashrae.org).
Volume V, Issue 13
STANDARDS ACTIONS
JOIN A LISTSERVE
Click on the list below to learn more about ASHRAE Standards Activities
dard 52.2-2007, Method of Testing General Ventilation ASHRAE Standards Actions Air-Cleaning Devices for Removal Efficiency by Particle Size, is now available on the ASHRAE website at: SSPC 41 Standard Methods for Measurement http://www.ashrae.org/standards-interpretations. Interpretation IC 52.2-2007-2 refers to the requirements SSPC 62.1 Ventilation for Acceptable Indoor Air presented in ANSI/ASHRAE Standard 52.2-2007, SecQuality tion 4.6.1, regarding particle counters. The response was approved by SSPC 52.2 on April 15, 2013. SSPC 62.2 Ventilation and Acceptable Indoor Air Quality in Low-Rise Residential Buildings A new official interpretation of ANSI/ASHRAE/ IESNA Standard 90.1-2007 , Energy Standard for SSPC 90.1 Energy Standard for Buildings Except Buildings Except Low-Rise Residential Buildings, is Low-Rise Residential Buildings now available on the ASHRAE website at: http:// www.ashrae.org/standards-interpretations. InterpretaSSPC 90.2 Energy Efficient Design of Low-Rise tion 90.1-2010-17 refers to the requirements presented Residential Buildings in ANSI/ASHRAE/IES Standard 90.1-2010, Section 9.4.1.4(a), relating to Automatic Daylighting Controls for Primary Sidelighted Areas and the light sensor for SPC 90.4 Energy Standard for Data Centers and the photocontrol. The response was approved by SSPC Telecommunications Buildings New! 90.1 on April 16, 2013. SSPC 161 Air Quality within Commercial AirCraft
ERRATA
Errata sheets for the following documents are now available on the ASHRAE website at http://www.ashrae.org/ standards-errata.
SSPC 189.1 Standard for the Design of HighPerformance Green Buildings Except Low-Rise Residential Buildings SPC 201 Facility Smart Grid Information Model
2013, Ventilation and Acceptable Indoor Air Quality in Code Intended Standards, CIS Listserve Low-Rise Residential Buildings, dated April 17, 2013.
Two new errata sheets for ANSI/ASHRAE/IES Standard 90.1-2010, Energy Standard for Buildings Except Low-Rise Residential Buildings, (SI and I-P editions) dated April 17, 2013 and replaces version dated January 18, 2013.
A new errata sheet for ANSI/ASHRAE Standard 1352012, A Data Communication Protocol for Building Automation and Control Networks, dated April 16, 2013.
6